- DL manuals
- Audi
- Automobile Electronics
- A6
- Repair Manual
Audi A6 Repair Manual - page 58
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not
permitted unless authorised by AUDI AG. AUDI AG does not guarantee or accept any liability
with respect to the correctness of information in this document. Copyright by AUDI AG.
28 – Ignition system
1
General Information
⇒ “1.1 Safety Precautions”, page 54
⇒ “1.2 Ignition System General Information”, page 54
1.1
Safety Precautions
If Special Testing Equipment is Required During Road Test, Note
the Following
WARNING
♦ Test and measuring equipment must always be secured to
the rear seat and be operated from there by a second per‐
son.
♦ If test and measuring instruments are operated from the
front passenger's seat and the vehicle is involved in an ac‐
cident, there is a possibility that the person sitting in this
seat may receive serious injuries when the airbag is trig‐
gered.
To Reduce the Risk of Personal Injury and/or Damage to the Fuel
Injection and Ignition System, Always Observe the Following
♦ Do not touch or disconnect wires of ignition system when en‐
gine is running or turning at starting RPM.
♦ Always switch ignition off before disconnecting or reconnect‐
ing wires for injection and ignition system, including high volt‐
age wiring and test leads.
♦ If the engine is to be cranked at starting RPM without starting
(e.g. during compression test), disconnect electrical connec‐
tors on ignition coils and on fuel injectors. After performing
work, check and erase DTC memory.
♦ Clean engine only with ignition switched off.
Caution
♦ The battery must only be disconnected and connected with
the ignition switched off, since the Engine Control Module
(ECM) can otherwise be damaged.
♦ Observe safety precautions when disconnecting the battery
⇒ Electrical Equipment; Rep. Gr. 27 ; Removal and Instal‐
lation .
1.2
Ignition System General Information
♦ For trouble-free operation of the electrical components a volt‐
age of at least 12.5 V is necessary.
♦ It is possible that the control module will recognize a malfunc‐
tion and store a DTC during some tests. Therefore after com‐
pleting all checks and repairs the DTC memory must be
checked and if necessary erased.
♦ If the engine only starts briefly and then turns off again after
troubleshooting, repair or checking of the components, it may
be that the immobilizer is blocking the Engine Control Module
Audi A6 2005 ➤
Fuel Injection and Ignition - Edition 03.2008
54
Rep. Gr.28 - Ignition system
Summary of A6
Page 1
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Repair manual audi a6 2005...
Page 2
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. List of workshop manual re...
Page 3
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Contents 24 - fuel injecti...
Page 4
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Audi a6 2005 ➤ fuel inject...
Page 5
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 24 – fuel injection system...
Page 6
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Observe the following if t...
Page 7
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – connect vehicle diagnosi...
Page 8
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Display on -vas 5051- : 1 ...
Page 9
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 1.4 fuel system bleeding t...
Page 10
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2 description and operatio...
Page 11
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 9 - camshaft adjustment va...
Page 12
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 1 - fuel injectors, cylind...
Page 13
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 14 - left electro-hydrauli...
Page 14
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of thro...
Page 15
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of left...
Page 16
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location of elec...
Page 17
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location on rear...
Page 18
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Component location under i...
Page 19
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2.2 air filter assembly ov...
Page 20
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 17 - spreader clip 18 - gr...
Page 21
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 19 - 6 nm 20 - washer 21 -...
Page 22
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2.4 lower intake manifold ...
Page 23
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 17 - seal ❑ replace if dam...
Page 24
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 3 specifications ⇒ “3.1 fa...
Page 25
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 4 diagnosis and testing ⇒ ...
Page 26
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove cover for right l...
Page 27
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect fuel line -ar...
Page 28
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – close shut-off valve of ...
Page 29
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ test box -v.A.G 1598/42-...
Page 30
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – connect test box -v.A.G ...
Page 31
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 5 removal and installation...
Page 32
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – open clips -arrows- on u...
Page 33
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect vacuum line -...
Page 34
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove front engine cove...
Page 35
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect vacuum hose -...
Page 36
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove bolts -arrows- an...
Page 37
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove intake manifold u...
Page 38
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – fasten bolts -arrows- fo...
Page 39
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – to fasten high-pressure ...
Page 40
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. If fuel injectors cannot b...
Page 41
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – clip radial adjustment -...
Page 42
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – press sizing sleeve -t10...
Page 43
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove bolts -1 through ...
Page 44
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical co...
Page 45
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – to fasten high-pressure ...
Page 46
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – pry off caps on wiper ar...
Page 47
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – set adjustment on heat g...
Page 48
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Note the threads of both s...
Page 49
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect check valve -...
Page 50
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove oxygen sensor -2-...
Page 51
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical ha...
Page 52
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Removing – remove rear eng...
Page 53
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove oxygen sensor -1-...
Page 54
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – remove coolant expansion...
Page 55
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 6 special tools special to...
Page 56
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ test box -v.A.G 1598/42-...
Page 57
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. ♦ ring spanner 7-piece set...
Page 58
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 28 – ignition system 1 gen...
Page 59
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. (ecm). Dtc memory must the...
Page 60
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 2 specifications ⇒ “2.1 te...
Page 61
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 3 removal and installation...
Page 62
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect check valve -...
Page 63
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. – disconnect electrical co...
Page 64
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. 4 special tools special to...
Page 65
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...
Page 66
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...
Page 67
Protected by copyright. Copying for private or commercial purposes, in part or in whole, is not permitted unless authorised by audi ag. Audi ag does not guarantee or accept any liability with respect to the correctness of information in this document. Copyright by audi ag. Cautions & warnings = page...