Bailey Unicorn Service Manual - page 12
11
Note: Not all bulbs and lights feature on all
models within a range.
Service Schedule
In order to validate the factory backed warranty
package, your caravan must be serviced by
an approved Bailey Service centre every 12
months (or within 6 weeks of each anniversary
of purchase) in accordance with the NCC
recommended service schedule.
A full listing of the current Approved Bailey
Centres can be found on the Retailer Network
pages of our website @www.bailey-caravans.
co.uk.
In no circumstances should the body shell
fixings be tampered with or adjusted by the
caravan owner. In instances where this has
occurred the warranty will be automatically
invalidated.
Standard Moisture survey for Alu-
tech construction caravans.
The following moisture survey must be
carried out using a calibrated moisture
meter every 12 months by an Approved
Bailey Service Centre.
Readings should be taken on the floor section
of the motorhome in positions where the holes
created by the meter’s probes are not visible
i.e. behind seals, in bed boxes or in cupboard
bases. It is important to make sure
that the probes are free from moisture and the
surface of the floor is free from condensation.
Readings below 20% are considered acceptable.
Readings greater than 20% will
identify areas that need further investigation
and possible remedial work.
All other parts of the Alu-Tech caravan should
be checked visually for moisture ingress.
Thermal Insulation Grade
All Alu-Tech Bailey Caravansare manufactured
and approved by the NCC to EN1645-1 thermal
insulation andheating classification Grade III.
This has been approved using the caravan
heating system both one electric and gas.
Grade III is classified as being able to achieve
an average temperature difference of 35
degrees centigrade between inside the caravan
and outside when the exterior temperature is
-15 degrees.
!
Interior/Other lights
Bulb Type
Bulb Rating
Awning Light
LED
12v/ < 1watt
Locker Spotlights
LED
12v/ < 1watt
Recessed Downlighters
LED
12v/ < 1watt
CIRO ceiling light
G4
12v/ 2 x 10 watt