Bakers pride oven co., inc . 30 pine street new rochelle, ny 10801 (914) 576-0200 phone (914) 576-0605 fax www.Bakerspride.Com web address (800) 431-2745 us & canada info@bakerspride.Com e-mail this equipment has been engineered to provide you with year round dependable service when used according t...
2 important for future reference please complete this information and retain this manual for the life of the equipment. For warranty service and/or parts, this information is required. Model number serial number date purchased notes:.
Index i. Installation instructions section item page 1 general description 4 2 installation 4 3 clearances 4 4 gas connection 4 5 burners 5 6 radiants 5 7 top grates 6 8 lighting 6 9 griddle plates 6 10 additional installation requirements 6 11 installation with casters 6 ii. Operating instructions ...
4. Gas connection: the gas pressure regulator supplied must be installed at the gas inlet of each broiler. Each regulator is adjusted to yield a manifold pressure of 5 in. Water column for natural gas or 10 in. Water column for propane gas. No pressure regulator is required for propane gas in canada...
The broiler and its individual shutoff valve must be disconnected from the gas supply piping system during any pressure testing of that system at test pressures in excess of ½ psig (3.45 kpa). The broiler must be isolated from the gas supply piping system by closing its individual manual shutoff val...
7. Top grates: place a grate over each of the radiants. For normal operation, the pointed side of the grate is facing up. For use with foods that require extra support, the flat side may be used. On xx models, grates can be placed on three levels; two positions are built into the rear of the unit; t...
Ii. Operating instructions 1. Lighting procedure: see section 8 of installation instructions. Once the pilot burners are lit, the broiler may be turned “on” or “off” by turning the control valves on or off as necessary. 2. Broiling procedure: broiler top grates must be hot enough to make black char-...
4. Maintenance: (a) service: shut off the main gas supply before attempting any maintenance on the unit. If required, contact your dealer, the factory, or a local service company to obtain qualified maintenance and repairs. (b) care and cleaning of top grates: the top grates should be cleaned using ...
Iii. Trouble shooting guide caution: take extreme care to assure that, if a valve is opened, a flame is present. If a valve is left open without a flame, turn the valve off and wait at least five minutes before attempting to (re)light. Service should be performed only by a qualified gas technician. ...
(d) if the pilot is lit, positioned correctly, and has a proper flame, close all the burner valves , allow to cool and then remove the top grate and radiant over the burner. Remove the burner by lifting the rear of the burner off the support pin, slide it towards the rear of the broiler, enough to c...
Xx-4, 6, 8, 10, 12 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 4 of 4 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of ...
30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride page 2 of 4 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. 2/05 xx-4, 6, 8, 10, 12 gas cha...
Splash guard, s/s (xx-4) optional splash guard, s/s (xx-6) optional splash guard, s/s (xx-8) optional splash guard, s/s (xx-10) optional splash guard, s/s (xx-12) optional grease pan (xx-4 & 12) 20 3/8", 1 used grease pan (xx-6 & xx-10) 30 7/8", 1 used grease pan (xx-8) 19 5/8", 2 used or (xx-12) 1 ...
58 57 51 48 47 56 55 49 50 54 53 52 46 gas char broiler 30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride figure a exploded view page 2 of 4 note: when ordering, always specify part #, ...
30 pine street • new rochelle • new york • 10801 914 / 576 - 0200 914 / 576 - 0605 1 - 800 - 431 - 2745 www.Bakerspride.Com fax us & canada web address bakers pride parts list (see figure a) 8/03 note: when ordering, always specify part #, model #, serial #, voltage/phase & type of gas. Page 3 of 4 ...
16 what is covered this warranty covers defects in material and workmanship under normal use, and applies only to the original purchaser providing that: * the equipment has not been accidentally or intentionally damaged, altered or misused; * the equipment is properly installed, adjusted, operated a...