Cal Flame BBQ08852P Owner's Manual - page 2
WARNING
If the information in this manual is not followed
exactly, a fire or explosion may result causing
property damage, personal injury or loss of
life.
Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
Do not store an LP cylinder not connected for
use in the vicinity of this or any other appli-
ance. A fire resulting in serious injury or death
may occur.
If you are installing a natural gas grill, you are
responsible for ensuring that the natural gas
line installed is safe to use. LMS will not be
held responsible for an improperly installed gas
line.
Built-in Construction
Location of grill enclosure . . . . . . . . . . . . . . . 3
Construction materials . . . . . . . . . . . . . . . . . 3
Built-in Dimensions . . . . . . . . . . . . . . . . . . . . 4
Enclosure Ventilation . . . . . . . . . . . . . . . . . . 6
Plumbing for Side Burners . . . . . . . . . . . . . . 7
Electrical Supply Requirements . . . . . . . . . . 7
Installation
Installing the Transformer . . . . . . . . . . . . . . 8
Installing Grills in Barbecue Islands . . . . . . 9
Installing the Rotisserie . . . . . . . . . . . . . . . . 9
Gas Connection
Leak Testing Procedure . . . . . . . . . . . . . . . . 10
LP Gas . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
Natural Gas . . . . . . . . . . . . . . . . . . . . . . . . . 12
Using Your Grill
Grill Controls . . . . . . . . . . . . . . . . . . . . . . . . 13
Lighting the Grill . . . . . . . . . . . . . . . . . . . . . 14
Basic Grill Operation . . . . . . . . . . . . . . . . . . 15
Cooking with the Rotisserie . . . . . . . . . . . . 15
Cooking with a Convection Grill . . . . . . . . . 16
Turning On and Off the Lights and Fan . . . 16
Using the Griddle . . . . . . . . . . . . . . . . . . . . . 16
Cleaning and Maintenance
Stainless Steel Care and Cleaning . . . . . . . 17
Cleaning the Interior of Your Grill . . . . . . . 18
Covering Your Grill . . . . . . . . . . . . . . . . . . . 19
Seasonal Cleaning . . . . . . . . . . . . . . . . . . . . 20
Light Bulb Replacement . . . . . . . . . . . . . . . 22
Appendix
Troubleshooting . . . . . . . . . . . . . . . . . . . . . 23
Converting from LP to NG . . . . . . . . . . . . . . 25
Replacement Cover . . . . . . . . . . . . . . . . . . . 28
Installing and Replacing Infrared Burners 28
Limited Warranty . . . . . . . . . . . . . . . . . . . . . 29
Read all instructions before you
operate your grill .
Save these instructions!
Copyright 2011 LMS, Inc. All rights reserved. Duplication
without written consent is strictly prohibited.
Cal Flame™ is registered trademark.
Due to continuous improvement programs, all models, op-
eration, and/or specifications are subject to change without
prior notice.
LTR50001038, Rev. B
5/26/11
250-407
CONTACT INFORMATION
For customer service, please contact your authorized
dealer immediately. If you need additional information
and/or assistance, please contact:
LMS Customer Service Department
1462 East Ninth Street
Pomona, CA 91766.
Toll Free: 1-800-CAL-SPAS
Fax: 1-909-629-3890
California Proposition 65 Warning: Chemicals known
to the State of California to cause cancer, birth de-
fects or other reproductive harm are found in and/or
created by the combustion of natural gas, propane,
butane and other fuels. Always operate this unit as
described in the owner’s manual and in well venti-
lated areas.