- DL manuals
- Cal Flame
- Grill
- C300L/R
- Owner's Manual
Cal Flame C300L/R Owner's Manual
Summary of C300L/R
Page 1
Ltr20081036, rev. A 1/14/08.
Page 2
Warning if the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Do not store an lp cylinder n...
Page 3: Safety Instructions
2008 barbecue island owner’s manual page 1 ltr20081036, rev. A safety instructions placement and location cal flame™ grills and carts are designed for outdoor use only . Never locate this appliance in an enclosed room, under a sealed overhead structure, or in any type of enclosed area such as a gara...
Page 4
Page 2 2008 barbecue island owner’s manual ltr20081036, rev. A safety instructions do not install or operate your grill unit in such a manner that the cross ventilation openings are blocked. Fresh air must be able to pass though installed vents to safeguard against residual gas accumulation. Failure...
Page 5: Barbecue Island Assembly
2008 barbecue island owner’s manual page 3 ltr20081036, rev. A assembly barbecue island assembly unit attachment place the island sections together on the ground. Make sure the ground where the barbecue is placed is as level as possible for best alignment. Note: if the ground is not level, use shims...
Page 6: Rock / Stone Application
Page 4 2008 barbecue island owner’s manual ltr20081036, rev. A assembly rock / stone application place the island sections together on the ground. Make sure the ground where the barbecue is place is as level as possible for best alignment. Note: if the ground is not level, use shims to level out the...
Page 7: Granite Kit Instructions
2008 barbecue island owner’s manual page 5 ltr20081036, rev. A assembly apply mortar to the gaps left open between the island assembly (front and back). Let it dry for 15 to 30 minutes and brush the area where the mortar mix was applied. Prepare grout in a second container. Fill the tile seam with g...
Page 8: Installing New Access Doors
Page 6 2008 barbecue island owner’s manual ltr20081036, rev. A assembly installing new access doors provide a cut out and a door jamb with inside dimensions as follows: 16 1/4” x 19 “ for a single door 28 1/4” x 19 3/8” for double doors secure the steel frame with 16 #10 x 1” truss head phillips scr...
Page 9: G-3100 Canopy Assembly
2008 barbecue island owner’s manual page ltr20081036, rev. A g-3100 sports bar canopy assembly g-3100 canopy assembly canopy assembly and wiring instructions step 1: install the posts.
Page 10
Page 8 2008 barbecue island owner’s manual ltr20081036, rev. A g-3100 sports bar canopy assembly step 2: assembling and wiring the canopy rafters.
Page 11
2008 barbecue island owner’s manual page 9 ltr20081036, rev. A g-3100 sports bar canopy assembly step 3: placing the canopy on the posts.
Page 12: Wiring Diagrams
Page 10 2008 barbecue island owner’s manual ltr20081036, rev. A g-3100 sports bar canopy assembly wiring diagrams power supply wiring diagram audiovisual system wiring diagram.
Page 13
2008 barbecue island owner’s manual page 11 ltr20081036, rev. A g-3100 sports bar canopy assembly dvd / stereo system wiring diagram.
Page 14: Entertainment Options
Page 12 2008 barbecue island owner’s manual ltr20081036, rev. A entertainment options entertainment options some barbecue islands may be equipped with audio/ visual entertainment options. Several options are available and include marine grade cd players and dvd players. Two different tv monitors are...
Page 15: Using The Universal Remote
2008 barbecue island owner’s manual page 13 ltr20081036, rev. A entertainment options using the universal remote control everything you want to do with your entertainment system can be controlled with the universal remote. All of the commands are organized into six areas. Device selection buttons se...
Page 16: Programming The Universal
Page 14 2008 barbecue island owner’s manual ltr20081036, rev. A entertainment options programming the universal remote control the cal spas universal remote has been pre- programmed to function with the entertainment system the spa has been configured with. However, in case you need to reprogram the...
Page 17: Cleaning and Maintenance
2008 barbecue island owner’s manual page 15 ltr20081036, rev. A cleaning and maintenance cleaning and maintenance about natural stone a natural characteristic of granite and marble is its inherent lack of uniformity. Because it is a completely natural material, it can have a great deal of variation ...
Page 18: Tile
Page 16 2008 barbecue island owner’s manual ltr20081036, rev. A cleaning and maintenance the chip can also be filled with colored epoxy to match the surrounding stone. Repairing this kind of damage should be left to other knowledgeable professionals. Tile if spillage occurs, then clean up as soon as...
Page 19: Warranty Information
Warranty information lloyds material supply (lms) offers the following limited warrants against defects in material and workmanship on cal flame barbecue islands and components: lifetime structural warranty lms warrants the structural frame to maintain its integrity. Frame - lightweight, durable gal...
Page 20
See your cal flame barbecue dealer for a copy of the applicable warranty, details and any questions you may have regarding the warranty coverage on your barbecue. Warranty limitations the limited warranty is void if the barbecue island has been subject to negligence, alteration, misuse, abuse, repai...