1. DL manuals
  2. Cal Flame
  3. Grill
  4. LBK-710-SW
  5. Owner's Manual

Cal Flame LBK-710-SW Owner's Manual

Manual is about: Barbecue Island with G4 Grill, Side Burner, and Refrigerator

Summary of LBK-710-SW

  • Page 1

    Ltr50001142, rev. A 4/21/14.

  • Page 2

    Warning if the information in this manual is not followed exactly, a fire or explosion may result causing property damage, personal injury or loss of life. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. Do not store an lp cylinder n...

  • Page 3: Saf

    Lbk-10-sw barbecue island ltr50001142, rev. A saf ety instructions www.Calflamebbq.Com 1 c • al flame™ grills are designed for outdoor use only . Never locate this appliance in an enclosed room, • under a sealed overhead structure, or in any type of enclosed area such as a garage, shed, or breezeway...

  • Page 4: Saf

    Lbk-10-sw barbecue island ltr50001142, rev. A saf ety instructions www.Calflamebbq.Com 2 when handling lp gas line and connectors, • do not allow them to come in contact with any metal surfaces of the cabinet. Do not drop lp connectors. Do not use fuel such as charcoal briquettes in gas • grills. Ga...

  • Page 5: Eparing The Site F

    Lbk-10-sw barbecue island ltr50001142, rev. A pr eparing the site f or the barbecue island www.Calflamebbq.Com 3 preparing the site for the barbecue island the cal flame g4 grill is expected to be use with a cal flame barbecue island . If the g4 grill used separately from barbecue island that it is ...

  • Page 6: Eparing The Site F

    Lbk-10-sw barbecue island ltr50001142, rev. A pr eparing the site f or the barbecue island www.Calflamebbq.Com 4 your barbecue island needs a solid and level foundation. Damage caused by inadequate or improper foundation support is not covered by the warranty. It is the responsibility of the owner t...

  • Page 7: Eparing The Site F

    Lbk-10-sw barbecue island ltr50001142, rev. A pr eparing the site f or the barbecue island www.Calflamebbq.Com 5 electrical requirements you do not need to hire a contractor to install your electrical service, but you must ensure you have all required permits and the installation complies with state...

  • Page 8: Eparing The Site F

    Lbk-10-sw barbecue island ltr50001142, rev. A pr eparing the site f or the barbecue island www.Calflamebbq.Com 6 tank requirements for plumbed-in lp installation, use a convertible regulator and set it for lp gas. Maximum line pressure for plumbed-in propane is 14” wc (3.5 kpa). Minimum line pressur...

  • Page 9: Eparing The Site F

    Lbk-10-sw barbecue island ltr50001142, rev. A pr eparing the site f or the barbecue island www.Calflamebbq.Com 7 natural gas ng service installation and connection natural gas installation of this appliance must conform with local codes or, in the absence of local codes, to the national fuel gas cod...

  • Page 10: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 8 installation and connection 1 . Prepare a proper foundation with stub-ups . Your barbecue island needs a solid and level foundation. Damage caused by inadequate or improper foundation support is not cover...

  • Page 11: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 9 2 . Connect barbecue island to electrical service . 3 . Place the grill and side burner in the cut-outs . You may need a second person to help you with the step. Remove the grill and side burner from thei...

  • Page 12: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 10 assemble a 3/8” pipe nipple to the 3/8” pipe tee using teflon tape or pipe sealant. Use only sealant that 1. Is approved for use on lp gas. Install the pipe tee assembly to the grill intake pipe. Tighten...

  • Page 13: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 11 note: make sure you have converted the grill for natural gas before connecting the gas line to the regulator. See page 28 for instructions on converting the grill from lp to ng. 5 . Connect gas line to g...

  • Page 14: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 12 6 . Connect to gas source . Liquid propane connection use the pressure regulator and hose assembly supplied with the grill, or a regulator and hose assembly with the same specifications. Replacement lp r...

  • Page 15: Installation and Connection

    Lbk-10-sw barbecue island ltr50001142, rev. A installation and connection www.Calflamebbq.Com 13 perform a leak test at least once a year whether the gas supply cylinder has been disconnected or not. In addition, whenever the gas cylinder is connected to the regulator or whenever any part of the gas...

  • Page 16: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 14 using your grill read all instructions before you operate your grill . We recommend you wash your entire grill with soap and water prior to lighting it for the first time. Oils are used during the manufacturing pro...

  • Page 17: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 15 each time you light the grill, check the following: inspect the hose before using the grill. If there is excessive abrasion or wear, or if the hose is cut, it must • be replaced prior to using the grill. See page 6...

  • Page 18: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 16 basic grill operation proper burner flame before lighting, make sure all burner controls are off. Do not attempt to light the burners if the smell of gas is present. Check the connection with a soap and water solut...

  • Page 19: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 17 heat distribution on the cooking grates using the griddle when you place food your cal flame grill, remember that the back of the grill tends to be hotter than the front. As your food cooks, you should periodically...

  • Page 20: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 18 these grill accessories are optional and may be ordered directly from www.Quickbbqparts.Com. You can use your grill as a pizza oven using the pizza brick tray. Made of stone and stainless steel, it fits on any cal ...

  • Page 21: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 19 use turn part of your cal flame grill into a charcoal and gas grill. Turn off the gas and wait for the grill to cool before setting the charcoal tray in place. Placement remove two grates (left or right side) and t...

  • Page 22: Using

    Lbk-10-sw barbecue island ltr50001142, rev. A using your grill www.Calflamebbq.Com 20 the deep fryer helper can turn part of your grill into a deep frying station. It is designed to fit in any cal flame grill. The deep fryer helper set is shipped with its own instructions for placement and use . Rea...

  • Page 23: Cleaning and Maintenance

    Lbk-10-sw barbecue island ltr50001142, rev. A cleaning and maintenance www.Calflamebbq.Com 21 to ensure safe and proper maintenance, we recommend you follow these directions carefully. Clean internal parts of the grill regularly as determined by the amount of use and foods cooked. The entire grill s...

  • Page 24: Cleaning and Maintenance

    Lbk-10-sw barbecue island ltr50001142, rev. A cleaning and maintenance www.Calflamebbq.Com 22 thoroughly clean stains, food, and grime using 1. A sponge or damp cloth with warm water and a mild dish soap. Use fantastik or formula 409 to remove heavier soil. Thoroughly rinse all surfaces and dry them...

  • Page 25: Cleaning and Maintenance

    Lbk-10-sw barbecue island ltr50001142, rev. A cleaning and maintenance www.Calflamebbq.Com 23 important: prior to starting this procedure, turn off all of the gas control knobs, shut off the fuel supply, and disconnect the fuel line. The burners can be removed by removing the locking pins and liftin...

  • Page 26: Cleaning and Maintenance

    Lbk-10-sw barbecue island ltr50001142, rev. A cleaning and maintenance www.Calflamebbq.Com 24 if you haven’t used your grill in a few months, we recommend that you clean the burners and the interior of your grill. Cleaning the burners periodically will keep them burning evenly and cleanly and help p...

  • Page 27: Cleaning and Maintenance

    Lbk-10-sw barbecue island ltr50001142, rev. A cleaning and maintenance www.Calflamebbq.Com 25 replace the burners 6 . Before you replace the burners, inspect the gas valve orifices for cleanliness and condition and the location of the igniters. Set the flame tamers in place before you replace the bu...

  • Page 28: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 26 appendix problem: smell of gas is present solution: check for loose connections in the gas line. Perform a leak test following the procedure described in this manual. Problem: burner does not ignite solution: note: turn of...

  • Page 29: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 27 problem: yellow flame solution: once the entire burner is operating, check the flame color to be sure that it is mostly blue. Some yellow at the tips may be present due to impurities in the fuel. If the flame is golden or ...

  • Page 30: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 28 important: the grill that comes with your lbk-10-sw barbecue island does not include the parts for converting to ng. The gas conversion kit for cal flame grills can be ordered separately. Ordering information can be found ...

  • Page 31: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 29 you will need: 6mm socket or nut driver • two to five 1.9mm orifices (depending on your • grill pipe compound suitable for natural gas • remove the grates, flame tamers, and drip tray a. From the grill. See figure below. R...

  • Page 32: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 30 you will need: 7mm wrench, socket, or nut driver • one or two 1.75mm orifices (depending on • your side burner) pipe compound suitable for natural gas • remove the grate, burner cap and burner a. Diffuser from the side bur...

  • Page 33: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 31 14 13 2 4 10 3 8 11 7 6 1 12 17 16 15 5 9 19 18 20 21 item no. Part part # 17 regulator (ng) bbq04103040 18 main burner valve (ng) bbq04101015 item no. Part number description 1 5burner,frontpanel,39.25 bbq09104051-cc 2 ho...

  • Page 34: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 32 all parts can be used on all three grill sizes except where described below. Item no . Part grill size part # 1 control panel 3 burner bbq10104049-cc 4 burner bbq07104050 5 burner bbq09104051-cc 2 hood 3 burner bbq07100587...

  • Page 35: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 33 disconnect or shut off the lp or natural gas line 1. Connected to the grill. Wait until the burners cool down. Open the hood and remove the grate and flame 2. Tamer on top of the stainless steel burner you want to replace....

  • Page 36: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 34 limited warranty this limited warranty is extended to the original purchaser of a lbk-10-sw barbecue island package manufactured after april 1, 2014 and installed for residential use in the united states of america and can...

  • Page 37: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 35 this limited warranty applies only to barbecues normally used for personal, family, or household purposes and specifically excludes rental or commercial applications. Disclaimers lms shall not be liable for loss of use of ...

  • Page 38: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 36.

  • Page 39: Appendix

    Lbk-10-sw barbecue island ltr50001142, rev. A appendix www.Calflamebbq.Com 37.

  • Page 40

    Locating the product serial number the serial number of your cal flame grill is located on the back and is visible when the hood is down. You will need this number to properly register your grill and activate coverage. Write this information in the space provided below. Grill model: ________________...