Cal Flame LBK-710-SW Owner's Manual - Eparing The Site F
LBK-10-SW Barbecue Island
LTR50001142, Rev. A
Pr
eparing the Site f
or the Barbecue Island
www.calflamebbq.com
6
Tank Requirements
For plumbed-in LP installation, use a convertible
regulator and set it for LP gas.
Maximum line pressure for plumbed-in propane
is 14” WC (3.5 kPa). Minimum line pressure for
propane is 11” WC.
The grill must be used with the gas pressure regulator.
The regulator will control and maintain a uniform
gas pressure in the manifold. The burner orifices
have been sized for the gas pressure delivered by
the regulator.
WARNING: Attempting to operate the grill unit
without the gas regulator installed could cause an
explosion and possible death.
CylinderSpecification
The LP cylinder must be constructed and marked
in accordance with the Specifications for LP-Gas
Cylinders of the U.S. Department of Transportation
or the National Standard of Canada, CAN/CSA-
B339, Cylinders, Spheres and Tubes for
Transportation of Dangerous Goods; and
Commission, as applicable.
Gas Requirements
Converting Gas Grills
IMPORTANT: Cal Flame G Series gas grills are manufactured to operate on liquid propane (LP). However,
they can be converted to operate on natural gas (NG) by an authorized service technician. The grill that
comes with your LBK-10-SW barbecue island does not include the parts for converting to NG. The gas
conversion kit for Cal Flame grills can be ordered separately. Grill conversion instructions can be found
on page 28 and ordering information can be found in this manual on page 31. The part number for the
conversion kit is BBQ07101045.
Any LP gas supply cylinder used with this grill must
be approximately 12 inches in diameter and 18 inches
high.
The maximum fuel capacity is 20 lbs. of propane, or 5
gallons. Full cylinder weight should be approximately
38 lbs. (43.7 lbs. nominal water capacity.) Never fill
the cylinder beyond 80% full.
If you do not have an updated filler valve on your
existing propane tank, you will need to purchase one
at your local hardware store. Without it you will not
be able to attach your tank to your grill or refill the
tank at your local propane refill station.
Transporting and Storing LP Gas
Transport only one cylinder at a time. Ensure the
cylinder is secured in an upright position with the
control valve turned off and the dust cap in place.
Store cylinders outdoors and out of reach of children.
Do not store cylinders in a building, garage, or any
other enclosed area.
Place the dust cap on the cylinder valve outlet whenever
the cylinder is not in use. Only install the type of dust
cap on the cylinder valve outlet that is provided with
the cylinder valve. Other types of caps or plugs may
result in leakage of propane.
Liquid Propane