1. DL manuals
  2. Caliber
  3. Grill
  4. CGP42-2G-1SR-L N WH
  5. Installation & Use Instructions

Caliber CGP42-2G-1SR-L N WH Installation & Use Instructions

Other manuals for CGP42-2G-1SR-L N WH: Installation Use & Care Instructions
Manual is about: Caliber Crossflame Pro Series Outdoor Grills

Summary of CGP42-2G-1SR-L N WH

  • Page 1

    1 models: 42” 3 burner grill: cgp42-2g-1sr-l/n-(wh); (2) grill burners, (1) sear burner,(1) rotisserie burner, wood handle option(wh) 60” 3 burner grill with integral dual power pro side burners: cgp60-2g-1sr-2sb-l/n-(wh); (2) grill burners, (1) sear burner,(1) rotisserie burner, (2) power pro side ...

  • Page 2: Danger:

    Danger: important safety notice: certain liquid propane dealers may fill liquid propane cylinders for use in the grill beyond cylinder filling capacity. This “overfilling” may create a dangerous condition. “overfilled” tanks can build up excess pressure. As a safety device, the tank pressure relief ...

  • Page 3: Table of Contents

    Table of contents pages 3-6 pages 7-9 pages 10-14 pages 15-17 page 18 page 19 pages 20-22 page 23 page 24 page 25 page 26 pages 27-28 care and safety precautions grill placement and installation gas requirements, pressure testing and hookups leak testing electrical connections air shutter adjustment...

  • Page 4

    2 getting to know your caliber grill: (not all features available on all models - cgp60-2g-1sr-2sb model shown below).

  • Page 5: Care and Safety Precautions

    3 care and safety precautions warning! Do not attempt to light grill without reading the lighting instructions section of this manual. This grill is for outdoor use only! For your safety do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any appliance. Test...

  • Page 6

    4 pot holders » use only dry pot holders: moist or damp pot holders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place of pot holders. Do not let pot holders touch hot portions of the grill rack. Grease » grease is flammable. Let hot grease cool before attempting ...

  • Page 7

    5 warning! Spiders and insects can nest in the grill burners , causing gas not to flow through the burner. The gas will flow from the front of the burner into the control panel. This is a very dangerous condition which can cause a fire to occur behind the valve panel, thereby damaging the grill comp...

  • Page 8

    6 » to avoid burns when cooking, use long handled bbq tools. » do not move the appliance during its use. » this unit is for outdoor use only! Do not operate in enclosed areas. This could result in carbon monoxide build-up which would result in injury or death. » when using a grill, be sure that all ...

  • Page 9

    7 grill placement and installation clearance to non-combustible construction*: a minimum of 3” clearance from the back of the grill to non-combustible construction is required for the lid to open freely. It is desirable to allow at least 6” rear and side clearance to non- combustible construction ab...

  • Page 10

    8 during heavy use, the grill will produce considerable smoke. Therefore, locate the grill in a well-ventilated area. Never locate the grill in a building, garage, breezeway, shed or other such enclosed areas without an approved ventilation system for outdoor use. If installing grill in an island in...

  • Page 11

    9 grill placement and installation - cont’d the grill is designed for easy placement into built-in masonry enclosures. For non-combustible applications the grill drops into the opening shown below and hangs from its side flanges. A deck is not required to support it from the bottom. A carpenter’s “s...

  • Page 12: Gas Requirements

    10 gas requirements verify the type of gas supply to be used, either natural or lp, and make sure the marking on the appliance rating plate agrees with that of the supply. The rating plate is located underneath the unit bottom. Never connect an unregulated gas line to the appliance. You must use the...

  • Page 13

    11 42” grill lp gas hook up (type 1 or qcc1 regulator): grills orificed for use with lp gas come equipped with a high capacity hose/regulator assem bly for connection to a standard 20 lb. Lp cylinder (type 1). The lp tank is not included. Connection: 1/2” npt male with a 3/8” flare adapter (included...

  • Page 14

    12 lp tank restraint for built-in installation if the grill is to be installed in a built-in application, then the grill must be installed in accordance with the built–in instal- lation guidelines. If you intend to operate your built-in grill on lp gas utilizing a 20 lb type 1 cylinder, then the bui...

  • Page 15

    13 60” grill lp gas hook up (type 1 or qcc1 regulator): the caliber 60” grill orificed for use with lp gas come equipped with a high capacity hose/regulator assembly for connec- tion to a standard 20 lb. Lp cylinder (type 1). The lp tank is not included. Connection - see diagram below: (1) 45 deg el...

  • Page 16: Pressure Testing and Hookups

    14 pressure testing and hookups caution! Use grill only in non-combustible enclosures. Do not build grill into a combustible enclosure. Pressure testing » the appliance and its individual shut off valve must be disconnected from the gas supply piping system during any pressure testing of that system...

  • Page 17: Leak Testing

    15 leak testing general » although all gas connections to the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly applied to the unit. Periodically...

  • Page 18: 42” Grill Lp Gas:

    16 leak test points 42” grill lp gas: 42” grill nat. Gas: check all gas supply fittings for leaks before each use: leak test point lp tank ng safety shut off valve leak test points leak test points leak test points leak test point.

  • Page 19: 60” Grill Lp Gas:

    17 leak test point main gas supply leak test point lp gas configuration hose kit p/n: 12081 shut off valve to natural gas supply propane tank 2 stage regulator leak test point leak test point leak test point natural gas configuration 60” grill lp gas: 60” grill nat. Gas: leak testing - cont’d. 60”gr...

  • Page 20: Electrical Connections

    18 electrical connections general » the caliber crossflame pro grill is equipped with a 110v electronic ignition system along with 12v panel lighting and interior/exterior lighting. Included with each pro grill is an electrical box that is pre-wired and ready for connect- ing to the 2 leads from the...

  • Page 21: Air Shutter Adjustments

    19 air shutter adjustments burner air shutter adjustment » each burner air shutter is tested at the factory prior to shipment; however, variations in the local gas supply may make it necessary to adjust the air shutters. The flames of the burners should be visibly checked. » flames should be blue an...

  • Page 22: Lighting Instructions

    20 lighting instructions before turning on the burners » ensure that all packaging material has been removed » ensure that the grill has been leak tested and is properly located » check that the radiant trays and grill racks are properly seated » light one burner at a time by turning the desired bur...

  • Page 23: To Match Light The Grill

    21 to match light the grill if the burners do not light after several attempts, then the grill burners, rotisserie burner, or side burners(on some mod- els) may be match lit using a long stem match and the provided match holder arm. Attach the match to the lighter arm which is attached to the drip p...

  • Page 24

    22 to match light the grill(continued) below: to match light the power pro top burner (single or dual) below: to match light the grill sear burner using the grill grilling requires high heat for searing and proper browning. Most foods are cooked at the “medium” setting for the entire cooking time. H...

  • Page 25: Using The Rotisserie

    23 using the rotisserie to light rotisserie (if equipped) open the lid, push and turn the knob to the “hi” position. You will hear a single snap sound at the burner control knob which is the ignition switch sending a spark to the flame electrode mounted under the stainless steel box to the left of t...

  • Page 26

    24 using the power pro™ top burners to light the power pro™ top burner (if equipped) note: on most models there is a front and rear burner operated with independent knobs. When lighting these top power burners, make sure that you are using the intended knob for ignition and use of the front or rear ...

  • Page 27: Care and Maintenance

    25 care and maintenance grill racks it is recommended that the grill racks be cleaned immediately after grilling, after the flame has been turned off. Be sure to wear a barbecue mitt to protect your hands from the heat and steam. Dip a wire brush in tap water and scrub the hot grill racks. Steam cre...

  • Page 28: Warranty

    26 warranty limited lifetime warranty: caliber appliances warrants the brass or stainless steel burners, grill racks and fabricated stainless steel components to be free from defects in materials and workmanship under normal residential use for the lifetime of this product. Defective parts will be r...

  • Page 29: Avertissement

    27 avertissement s’il y a une odeur de gaz: » coupez l’admission de gaz de l’appariel. » Éteindre toute flamme nue. » ouvrir le couvercle. » si l’odeur persiste, appeler immédiatement votre compagnie de gaz ou votre département des incendies. Avertissement » ne pas entreposer ni utiliser de l’essenc...

  • Page 30

    28 » empêcher les enfants de manipuler la bouteille ou de jouer avec. » lorsque la bouteille n’est pas raccordée à l’appareil, en maintenir fermé le robinet. Pour les appareils de cuisson auto- nomes d’exténeur, utiliser une bouteille d’une capacité maximale de 9 kg (20 lb). » ne pas utiliser, entre...

  • Page 32

    Because of continuous product improvement, caliber reserves the right to modify any product specifications. All material contained herein may not be reproduced without prior written consent of caliber appliances. Copyright 2017 caliberappliances.Com caliber appliances 17812 metzler lane, huntington ...