DA Data Cool Series Installation, Operation And Maintanance Manual - page 25
25
Data Aire, Inc.
Monthly Maintenance Inspection Checklist
Model No.__________________
Serial No. ____________________
Prepared by: _______________
Date: ___ / ___/ 201__
Air Filters
___ Check for restricted air flow
Blower Section
___ Blower wheel free of debris moves freely
___ Check motor mounts
Air Distribution Section
___ Check for restriction in grille(s)
Air Cooled Condensing Unit (if applicable)
___ Condensing coil clean
___ Motor Mounts tight
___ Motor fan bearings in good condition
___ Refrigeration lines properly supported
Compressor
___ Check for leaks
Refrigeration Cycle/Section
___ Check crank case temperature
Water/Glycol Fluid Cooler (if applicable)
___ Water regulating valve function
___ Check for water/glycol leaks (piping area)
Glycol Pump(s) (if applicable)
___ Glycol leaks (pump area)
___ Pump operation
___ Auto air vent clean of mineral deposits
Condensate Drain and Pump (if applicable)
___ Check for water leaks
___ Check for restricted air flow
___ Pump operation
Steam Generating Humidifier (if applicable)
___ Check canister for deposits and water level
___ Check condition of steam hose and clamps
Electrical Panel
___ Check contactor operation
Notes: _______________________________
____________________________________
____________________________________
____________________________________
____________________________________
____________________________________
____________________________________
____________________________________
____________________________________
____________________________________