Installation instructions epicure ® cooktop models: esg366, esg486 part no. 65162 rev. K.
Installation instructions .................................................... 8 unpack the cooktop ........................................................ 8 cooktop installation .......................................................... 8 gas line connection ..........................................
1 important information about safety instructions the • important safety instructions and warnings in this manual are not meant to cover all possible prob- lems and conditions that can occur. Use common sense and caution when installing, maintaining or oper- ating this or any other appliance. Always...
2 important safety instructions read the accompanying use and care manual com- • pletely before operating this appliance. Keep packaging materials away from children. Plastic • sheets and bags can cause suffocation. If you receive a damaged product, immediately con- • tact your dealer or builder. Do...
3 product dimensions cooktop width (a) esg366 35 7/8” (911 mm) esg486 47 7/8” (1216 mm) installation requirements warning observe all governing codes and ordinances during • planning and installation. Contact your local building department for further information. To prevent an electric shock hazard...
4 cabinet and countertop layout warning to avoid the risk of fire or personal injury, all minimum and maximum specified clearances on this and the following pages must be maintained or exceeded. General considerations the minimum distance from the back of the cooktop • to a combustible rear wall is ...
5 recommended gas and electrical service location, consult local code b 10” (254 mm) to combustible side wall min. Both sides 1/2” (13 mm) overhang, both sides 1 1/2” (38 mm) typical countertop thickness 7 3/4” (197 mm) 36” (914 mm) typical cooktop platform 1” (25 mm) min. Thickness installation req...
6 cabinet/countertop dimensions (cont.) installation requirements cutout tolerances +1/16” -0 (+1.6 mm, 0) unless otherwise noted. Non-combustible rear wall, rear of mounting platform 10” (254 mm) min. To combustible wall above countertop, both sides cabinet face below countertop overhang increase c...
7 installation requirements note: gas and electrical connections may only be routed through the bottom of the cooktop when installed with a raised vent. Non combustible rear wall recommended 10” (254 mm) min. To combustible wall above countertop, both sides cabinet face below countertop overhang 3/8...
8 installation instructions unpack the cooktop warning if the gas and electric service provided does not • meet the product specifications, do not proceed with the installation. Call the dealer, the gas supplier or a licensed electrician. The cooktop is heavy. A minimum of two people are • required ...
9 installation instructions gas line connection warning verify that the gas supply meets specifications before • connection. See page 3. The maximum gas supply pressure to the regulator • must never exceed ½ pounds per square inch (psi) or 3.5 kpa. Do not install or use the cooktop without the inclu...
10 verifying proper operation warning make sure that power to the electrical outlet is turned • off at the circuit breaker or fuse box and that the gas is turned off at the gas supply valve before proceeding. The cooktop must be properly grounded at all times • when electrical power is applied. Prio...
11 installation instructions installation checklist warning to ensure a safe and proper installation, the follow- • ing checklist should be completed by the installer to ensure that no part of the installation has been over- looked. Proper installation is the responsibility of the hom- • eowner. The...
12 wiring diagram.
Dacor ● phone: (800) 793-0093 ● fax: (626) 403-3130 ● www.Dacor.Com.
