- DL manuals
- Echo
- Trimmer
- SRM-22GES
- Operator's Manual
Echo SRM-22GES Operator's Manual
Summary of SRM-22GES
Page 1
Warning read instructions carefully and follow rules for safe operation. Failure to do so could result in serious injury. Operator’s manual grass trimmer/ brushcutter srm-22ges.
Page 2: Introduction
2 srm-22ges introduction echo grass trimmers/brushcutters are lightweight, high- performance, petrol engined units designed for weed control, grass trimming and light brush cutting in areas difficult to control by any other means. Do not use this unit for any purpose other than aforementioned. This ...
Page 3: Decals and Symbols
3 srm-22ges decals and symbols carefully read the operator’s manual wear eyes, ears and head protection carburettor adjustment - low speed mixture purge bulb (primer) petrol and oil mixture warning, side thrust the maximum speed of the cutting attachment shaft in r/min carburettor adjustment - high ...
Page 4: Rules For Safe Operation
4 srm-22ges operator’s manual do not permit operation without proper training and protective equipment. Wear eye protection protective clothing choose trousers, shirts and jackets that fit trimly and have no strings, frills or dangling straps which could catch on the unit or the underbrush. Do not w...
Page 5
5 srm-22ges warning in addition to head, eye and ear protec- tion wear protective clothes, safety gloves and shoes to protect your feet and body from thrown objects, and improve your footing on slippery surfaces. Do not wear ties, jewellery, or loose, dangling clothing which could be caught in the u...
Page 6
6 srm-22ges warning • improper fit will result fly off the cutting attachment. • never start the engine if the power transmission shaft is not in place to prevent the engine from over speeding or the clutch from flying apart. Lay the unit down on a clear area and set the controls for starting. Be su...
Page 7
7 srm-22ges do not raise the cutting attachment above knee height. If raised higher, the cutting attachment will be more directly in line with your face. Thrown objects may hit your face and eyes. Wear the recommended protective gear. Never operate the unit without the proper guards and other protec...
Page 8
8 srm-22ges vibration and cold it is believed that a condition called raynaud’s phenom- enon which affects the fingers of certain individuals may be brought about by exposure to vibration and cold. Exposure to vibration and cold may cause tingling and burning, followed by loss of colour and numbness...
Page 9
9 srm-22ges trimming angle to wall move the line head slowly until the grass is cut right up to the barrier, but do not jam (overfeed) the line into the barrier. If trimming up to wire mesh or chain link fencing, be careful to feed only up to the wire. If you go too far, the line will snap off aroun...
Page 10
10 srm-22ges use correct cutting attachment warning • serious injury may result from the improper use of cutting attachment. Read and comply with all safety instructions listed in this manual. • use only cutting attachments recommended by kioritz corporation. Warning do not trim in any area where th...
Page 11: Description
11 srm-22ges description 1 operator’s manual included with unit. Read before operation and keep for future reference to learn proper, safe operating techniques. 2 angle transmission having two gears to change the angle of rotating axis. 3 cutting attachment nylon line head for cutting grass and weed...
Page 12: Assembling
12 srm-22ges assembling front (loop) handle installation • position handle in comfortable operating position and tighten screws (m5 × 35). Front (loop) handle screw m5 × 35 warning cut off knife on debris shield has sharp edges. Avoid contact when installing or removing line head. Plastic shield ins...
Page 13
13 srm-22ges adjusting nylon line • make sure there is no bystander within 15 m radius and pay enough attention to objects in the surroundings before starting operation. • do not rotate the cutting head at more than 10,000 r/mim. • do not hit the cutting head against hard foreign matters such as roc...
Page 14
14 srm-22ges 2 3 4 5 (4) (5) 6 replacing nylon line spool 1. Intermediate separator 2. Bent portion 3. Notch nylon line 4. Winding direction for the line 5. If wound unfirmly, the line loosens. 6. Wind firmly into respective groove. Danger shut down trimmer engine without fail and make sure cutting ...
Page 15: Fuel
15 srm-22ges fuel fuel • fuel is a mixture of regular grade petrol and an air-cooled 2-stroke engine oil of reputable brand name. Minimum 89 octane unleaded petrol is recommended. Do not use fuel containing methyl alcohol or more than 10 % of ethyl alcohol. • recommended mixture ratio; 50 : 1 ( 2 % ...
Page 16: Operation
16 srm-22ges warning • when engine starts, the cutting attachment may rotate, even with throttle trigger in low-speed posi- tion. • when engine is started, confirm if there is not any abnormal vibration or sound. If there is abnormal vibration or sound, ask your dealer to repair. Operation ignition ...
Page 17: Maintenance and Care
17 srm-22ges idle speed adjustment turn idle speed adjuster clockwise until cutting attachment begins to turn, then turn screw out anticlockwise until cutting attachment stops turning. Turn screw out, anticlockwise, and additional 1 turn. Carburettor adjustment every unit is test run at the factory ...
Page 18
18 srm-22ges cooling system maintenance important to maintain proper engine operating temperature, cooling air must pass freely through the cylinder fin area. This flow of air carries combustion heat away from the engine. Overheating and engine seizure can occur when: • air intakes are blocked, prev...
Page 19
19 srm-22ges checking the nylon line head (1)make sure each periphery of the 2 retaining pawls of housing spreads almost fully up to the outer periphery of the respective cover window. (2)check mount of cutting head on trimmer and tighten if it is loose. (3)check the cutter head for deflection or ab...
Page 20: Trouble Shooting
20 srm-22ges trouble engine - hard to start - does not start engine fuel at no fuel • fuel filter clogged • clean or replace cranks carburettor at carburettor • fuel line clogged • clean • carburettor • ask your echo dealer fuel at no fuel at • carburettor • ask your echo dealer cylinder cylinder si...
Page 21: Storage
21 srm-22ges storage long term storage (over 30 days) do not store your unit for a prolonged period of time (30 days or longer) without performing protective storage maintenance which includes the following: 1. Store unit in a dry, dust free place, out of the reach of children and other unauthorized...
Page 22: Specifications
22 srm-22ges srm-22ges mass : unit without cutting attachment, empty tank kg 4.63 unit with specified cutting attachment, empty tank kg 4.84 unit with specified cutting attachment, full tank kg 5.17 volume : fuel tank l 0.44 cutting attachment : nylon line head g138 line diameter mm 3.0 line length ...
Page 23: Memorandum
23 srm-22ges memorandum.
Page 24
7-2 suehirocho 1-chome, ohme, tokyo 198-8711, japan phone: 81-428-32-6118. Fax: 81-428-32-6145. X771-000 72 1 x771 227-700 1 © 2006.