1. DL manuals
  2. EcoWater
  3. Water Dispenser
  4. ECR 3000R20
  5. Owner's Manual

EcoWater ECR 3000R20 Owner's Manual

Manual is about: EcoWater Systems Series 3000 and 3002 digital demand water conditioner

Summary of ECR 3000R20

  • Page 1

    Series 3000 & 3002 r p/n: 7283586 cut al ong dot te d lin e to rem ove tor n out er cover.

  • Page 2: Owners Manual

    Printed in usa part no. 7283586 (rev. D 11/27/06) ecowater systems po box 64420, st. Paul mn 55164--0420 owners manual how to maintain and operate your ecowater systems digital demand water conditioner ecowater systems conditioner with remote (ecr) ecowater systems refiner with remote (err) series 3...

  • Page 3

    2 ecowater s y s t e m s unpacking, table of contents unpacking ecowater systems conditioner models r70 and r50s are shipped from the factory in two cartons. These contain resin tank/controller assembly in one carton and the brine tank, cover, skin pack of small parts needed to assemble and install ...

  • Page 4: Guarantee

    3 ecowater s y s t e m s warranty limited warranty ecowater systems llc advantage warranty series ecr & err 3000 water system congratulations! You have just purchased the highest quality water conditioning product on the market. To register your warranty, complete the enclosed warranty registration ...

  • Page 5

    4 ecowater s y s t e m s water conditioning water conditioning water conditioning is the treatment of several condi- tions occuring in household water. The conditions treated by the unit you have purchased are: (1) hardness, (2) iron, (3) sediments, (4) barium and (5) radium 226 and 228. These are d...

  • Page 6

    5 ecowater s y s t e m s planning installation figure 1 -- typical installation drawings floor drain floor drain note: faceplate and support not shown for clarity of drawing. Tie or wire valve drain hose in place, to keep over floor drain. Valve drain valve drain hose brine tank overflow hose brine ...

  • Page 7

    6 ecowater s y s t e m s installation 1. Install bypass valve and/or copper tubes a. If installing an ecowater systems by- pass valve, put lubricated o--ring seals onto both bypass valve ports (figure 3b). Carefully slide the bypass valve into the softener valve and install the “c” clips. B. Slide a...

  • Page 8

    7 ecowater s y s t e m s installation 5. Connect inlet and outlet plumbing a. Soldered copper (1) thoroughly clean and flux all joints. (2) pull the plastic ‘‘c’’ clips and remove the inlet and outlet tubes from the valve. Remove o--rings from the tubes. Do not solder with tubes in the valve. Solder...

  • Page 9

    8 ecowater s y s t e m s installation 8. Install brine tank overflow hose a. Connect a length of 1/2” i. D. Hose to the brine tank overflow elbow and secure in place with a hose clamp. B. Run the hose to the floor drain, or other suitable drain point no higher than the drain fitting on the tank. If ...

  • Page 10

    9 ecowater s y s t e m s programming the digital demand faceplate controller display ↑ keypad ↓ keypad recharge keypad salt level keypad select/exit keypad tank light keypad the following steps are for first time set up only. When the transformer is plugged in, a ‘‘beep’’ will sound, followed by the...

  • Page 11

    10 ecowater s y s t e m s programming the digital demand faceplate controller 4. Set recharge (regeneration) time: the controller is factory set to 2:00 am. At this set- ting, the ecowater systems conditioner begins re- charge, or regeneration, ending no later than 5:30 am. This is a good time in mo...

  • Page 12

    11 ecowater s y s t e m s faceplate controller, features/options features and options normal screen views the display will scroll through as many as 5 screens at an interval of 4 sec- onds each. F soft water available will show a percent of available soft water and a bar graph at the bottom of the d...

  • Page 13

    12 ecowater s y s t e m s faceplate controller, features/options initiating extra recharges recharge now: press the recharge keypad to go to the recharge menu. Move square cursor down to start recharge now. Press select/exit keypad and a recharge begins immediately. To assure an adequate supply of c...

  • Page 14

    13 ecowater s y s t e m s faceplate controller, features/options primary menu, continued water flow rate: enter primary menu. Press the (↑) or (↓) keypads until cursor is next to water flow rate. Press the select/exit (↵ ) keypad. When selected, this screen will show the water flow rate in gallons p...

  • Page 15

    14 ecowater s y s t e m s faceplate controller, features/options primary menu, continued remote status: enter primary menu. Press the (↑) or (↓) keypads until cur- sor is next to remote status. Press the select/exit ( ↵ ) keypad. The current remote status is displayed. Send e.A.S.E. Message: enter p...

  • Page 16

    15 ecowater s y s t e m s faceplate controller, features/options advanced/service menu, continued set model: the controller is factory set to the model code, which provides the shortest recharge times and greatest water savings. For operation at higher salt efficiency levels, the alternate model cod...

  • Page 17

    16 ecowater s y s t e m s remote monitor, features/options this ecowater systems conditioner comes with a remote monitor which can conveniently be placed in your home for viewing of your conditioners’ status. During normal operation, the green led will flash at intervals of 5 seconds. If the unit re...

  • Page 18

    17 ecowater s y s t e m s service information refilling with salt remove the brine tank cover and check the salt stor- age level frequently. If the conditioner uses all the salt before you add more, you will get hard water. Be sure the brinewell cover is on when adding salt. Note: in humid areas, it...

  • Page 19

    18 ecowater s y s t e m s service information 3 -- valve bypass outlet valve inlet valve bypass valve water flow to conditioner from conditioner d for service: -- open the inlet and outlet valves. -- close the bypass valve. D for bypass: -- close the inlet and outlet valves. -- open the bypass valve...

  • Page 20

    19 ecowater s y s t e m s service information automatic electronic diagnostics the faceplate computer has a self--diagnostic func- tion for the electrical system (except input power and water meter). The computer monitors electronic components and circuits for correct operation. If a malfunction occ...

  • Page 21

    20 ecowater s y s t e m s service information continued from page 19 use the recharge keypad to manually advance the valve into each cycle and check correct switch op- eration, and observe the valve position indicator. Note: the position switch is closed when the plunger is depressed, open when exte...

  • Page 22

    21 ecowater s y s t e m s service information other service hard water bypass (hard water ‘‘bleeds’’ into conditioned water supply). 1. Defective inlet disc, seal, or wave washer (see pages 26 and 27). 2. Missing or defective o--ring(s) at resin tank to valve con- nection. Water leaks from drain hos...

  • Page 23

    22 ecowater s y s t e m s dimensions/specifications in out 3--13/16” 32--1/2” 45--1/8” a in -- out in -- out 14” 20” 14” 14” c b 16” 16” 36--9/16” 32” model nominal resin tank size a b c ecr 3000r20 8” dia. X 35” 39.5” -- -- ecr 3000r30, ecr 3002r30, err 3000r20 10” dia. X 35” 39.5” 39.5” 44.8” ecr ...

  • Page 24

    23 ecowater s y s t e m s dimensions/specifications ecr 3000r20 err 3000r20 ecr 3000r30 ecr 3002r30 err 3002r30 ecr 3002r40 ecr 3002r50s ecr 3002r70 rated softening capacity (grains@ lbs salt dose) 5,700 @ 1.1 16,800 @ 4.3 20,400 @ 7.5 6,700 @ 1.4 19,300 @ 5.2 23,600 @ 8.9 8,300 @ 1.6 25,000 @ 6.4 3...

  • Page 25

    8 7 9 10 31 32 33 34 35 36 37 11 12 13 14 15 16 19 20 28 24 22 23 22 23 30 21 18 19 20 29 38 40 41 42 14 45 43 1 2 3 4 6 46 39 5 26 27 44 25 17 18 21 24 ecowater s y s t e m s repair parts ecowater systems conditioner assembly.

  • Page 26

    25 ecowater s y s t e m s repair parts ecowater systems conditioner assembly key no. Part number part description 1 7275907 transformer, 24v---10va 2 7288489 remote indicator (batteries not in- cluded) 3 7218662 top cover (cabinet) 4 7210410 faceplate (order one of following decals) --- 7274359 face...

  • Page 27

    26 ecowater s y s t e m s repair parts valve assembly 1 2 3 4 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 16 21 22 23 24 25 26 27 28 29 30 31 33 32 34 35 36 37 38 39 13 40 14 41 42 43 44 45 46 47 48 49 50 51 11 5.

  • Page 28

    27 ecowater s y s t e m s repair parts valve assembly key no. Part no. Part description 1 7101548 turbine asm. (all models except below) --- 7123061 turbine asm. (err 3002r30, ecr 3002r40, ecr 3002r50s, ecr 3002r70) 2 7094898 turb. Mnt. Asm. (all models except below) --- 7119177 turb. Mnt. Asm. (err...

  • Page 29

    Ecowater s y s t e m s 3 r ecowater systems po box 64420, st. Paul mn 55164--9888 1--800--86water.