1. DL manuals
  2. EcoWater
  3. Water Filtration Systems
  4. ETF AIV-10
  5. Owner's Manual

EcoWater ETF AIV-10 Owner's Manual

Other manuals for ETF AIV-10: Owner's Manual
Manual is about: EcoWater Systems Air Aspirated Iron Filter

Summary of ETF AIV-10

  • Page 1

    Owner’s manual how to install, operate and maintain your ecowater systems air aspirated iron filter models etf aiv-10 etf aiv-12 etf eiv-10 etf eiv-12 7344502 (rev. E 8/24/15) ecowater systems llc p.O. Box 64420, st. Paul, mn 55164-0420 www.Ecowater.Com designed, engineered & assembled in the u.S.A..

  • Page 2

    2 ecowater s y s t e m s table of contents, inspect shipment & safety guides table of contents page specifications & dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 before starting installation . . . ....

  • Page 3

    3 ecowater s y s t e m s specifications & dimensions side view front view top view 14" 14" in out 3-3/4" in - out 39-1/4" 44-3/4" etf aiv-10 etf eiv-10 etf aiv-12 etf eiv-12 nominal mineral tank size 10” dia. X 47” tall 12” dia. X 54” tall a 57” 62-1/2” b 50” 55-3/4” fig. 1 3-3/4” 14” 14” front view...

  • Page 4

    4 ecowater s y s t e m s before starting installation where to install the filter = place the filter as close as possible to the pressure tank (well system) or water meter (city water). = place the filter as close as possible to a floor drain, or other acceptable drain point (laundry tub, sump, stan...

  • Page 5

    5 ecowater s y s t e m s media loading (models etf eiv-10 & etf eiv-12) media loading models etf eiv-10 & etf eiv-12, as manufactured, have no media other than quartz gravel at the bottom of the tank (see table on page 3 for amounts). Before plumbing these units, load media: 1. Move the filter into ...

  • Page 6

    Ecowater s y s t e m s typical installation illustrations 6 fig. 7 drain fitting valve drain hose valve drain hose 1-1/2” air gap 1-1/2” air gap 1-1/2”” air gap 1-1/2” air gap laundry tub sump stand pipe floor drain to standpipe, sump, laundry tub or other suitable drain. 5/8” i.D. (minimum) copper ...

  • Page 7

    7 1. Turn off water supply a. Close the main water supply valve near the well pump or water meter. B. Shut off the electric or fuel supply to the water heater. C. Open high and low faucets to drain all water from the house pipes. 2. Install bypass valve and/or plastic adaptor / copper tube: a. If in...

  • Page 8

    8 ecowater s y s t e m s installation a. Fully open two filtered water faucets, one cold and one hot, nearby the filter. B. Place bypass valve(s) into “bypass” position. On a single valve, slide the stem inward to bypass (see fig. 7 on page 6). On a 3 valve system, close the inlet and outlet valves,...

  • Page 9

    9 ecowater s y s t e m s description of operation & sanitizing service water enters the filter and passes through air captured at the top of the mineral tank. Dissolved iron is oxidized and then removed by the media in the tank. When the system recharges, it first backwash- es the contaminants to th...

  • Page 10

    10 ecowater s y s t e m s programming the electronic controller fig. 15 up button down button display recharge button select button controller settings required upon installation, and after an extended power outage. When the power supply is plugged into the electrical outlet, a model code (haaif) an...

  • Page 11

    11 ecowater s y s t e m s programming (continued) & controller features / options c. Set recharge start time 1. If you completed the previous step, the words “recharge time" should show in the display (see figure 19). Otherwise, press the select button several times until they do. 2. The filter’s de...

  • Page 12

    12 ecowater s y s t e m s controller features / options (continued) recharge cycle time adjustments the default setting for backwash and aspirate times of the recharge cycle are factory set for maximum performance of the filter. Use the following proce- dures to check for correct cycle times, or to ...

  • Page 13

    13 ecowater s y s t e m s features / options (continued) & routine maintenance fig. 26 fig. 27 4. Chemical feeder trip volume: if you have set the auxiliary output control to cf (chemical feeder), you will need to set the volume of water which must flow past the turbine before the auxil- iary output...

  • Page 14

    14 manually initiated electronic diagnostics use the following procedures to advance the filter through the recharge cycles to check operation. Remove the top cover faceplate assembly by unlock- ing the tabs and lifting, to observe cam and switch operation during valve rotation (see figure 31). 1. P...

  • Page 15

    15 ecowater s y s t e m s troubleshooting (continued) resetting to factory defaults to reset the electronic controller to its factory default for all settings (time, days between recharges, etc.): 1. Press the select button and hold it until the dis- play changes twice to show “code” and the flash- ...

  • Page 16

    16 ecowater s y s t e m s troubleshooting guide & wiring schematic wiring schematic troubleshooting guide problem cause correction iron bleed 1. Riser tube o-ring. 1. Reseat or replace riser o-ring. 2. Over-running filter bed. 2. Increase recharge frequency and backwash time. 3. Time clock set incor...

  • Page 17

    17 ecowater s y s t e m s repair parts key no. Part no. Description 1 7210478 top cover 2 7337482 power supply, 28v dc 3 7259927 wire harness 4 7336363 repl. Electronic controller (pwa) 5 7210509 faceplate (order decal below) ¢ 7308970 decal, faceplate 6 7291212 support, faceplate 7 7274286 rim 8 72...

  • Page 18

    18 ecowater s y s t e m s repair parts 50 93 92 91 90 89 78 79 77 75 76 wear strip seal cross-section view 63 66 67 62 61 60 59 58 57 56 55 54 70 72 71 72 74 94 51 52 53 64 68 69 65 82 assembled view flow plug assembly 70 80 81 88 87 86 85 84 83 valve exploded view 73.

  • Page 19

    19 ecowater s y s t e m s repair parts key no. Part no. Description 50 7224087 screw, #8-32 x 1” (2 req.) 51 7286039 motor (incl. 2 ea. Of key no. 50) 52 7231393 motor plate 53 0900857 screw, #6-20 x 3/8” (3 req.) 54 7171250 bearing 55 7335024 cam & gear 56 7169180 clip, drain 57 7172793 drain hose ...

  • Page 20

    20 ecowater s y s t e m s warranty limited warranty ecowater systems llc advantage warranty series etf aiv / eiv water system congratulations! You have just purchased the highest quality water conditioning product on the market. To whom is this warranty extended? Ecowater systems llc warrants its pr...