1. DL manuals
  2. EcoWater
  3. Water Filtration Systems
  4. ETF2100 PF
  5. Owner's Manual

EcoWater ETF2100 PF Owner's Manual

Other manuals for ETF2100 PF: Owner's Manual
Manual is about: multi-purpose

Summary of ETF2100 PF

  • Page 1

    Owners manual how to maintain and operate your ecowater multi--purpose filter series etf2100 pf ecowater systems llc p.O. Box 64420, st. Paul, mn 55164--0420 www.Ecowater.Com part no. 7283536 (rev. L 7/9/15) designed, engineered & assembled in the u.S.A. Etf2100pf10 and etf2100pf12 are tested and ce...

  • Page 2

    3 2 unpacking, safety guides ecowater s y s t e m s table of contents page specifications / dimensions 3 assembly instructions 4 planning installation 5 -- 6 installation steps 7 -- 9 wiring schematic 9 programming face plate timer 10 -- 13 filter operation 14 -- 15 general 14 service / backwash / f...

  • Page 3

    14” 14” a b 3 3 specifications / dimensions ecowater s y s t e m s etf2100pf10 10” dia x 47” resin tank etf2100pf12 12” dia x 54” resin tank filter type, mineral ¡ sediment removal filter aggregate limits factory recommendation based on water analysis acid neutralizer neutralite water supply ph limi...

  • Page 4

    3 4 assembly instructions ecowater s y s t e m s fill the mineral tank 1. Remove the tank clamps, figure 1, valve assem- bly, o--ring seals (3), and the top distributor. 2. Using a funnel, add the specified amount of filter sand, then the mineral. Note:the filter is factory filled with the correct a...

  • Page 5

    3 5 planning installation ecowater s y s t e m s typical installation drawings inlet -- outlet options 1” copper tube (2 supplied) 1” x 1” sweat 1” x 3/4” sweat 1” sweat x 1” or 3/4” pipe thread floor drain floor drain note: faceplate and support not shown for clarity of drawing. Tie or wire valve d...

  • Page 6

    3 6 planning installation ecowater s y s t e m s tools you may need d common screwdriver d pliers d cross--point screwdriver d tape measure soldered copper threaded cpvc plastic d tubing cutter d hacksaw or pipe cutter d hacksaw d propane torch d threading tool d adjustable wrench d lead--free solde...

  • Page 7

    3 7 installation ecowater s y s t e m s 1. Install inlet and outlet fittings note: all fittings are in the small parts bags. A. Insert the turbine support, into the valve outlet port, up to the shoulder. Note: if installing the ecowater bypass valve, see separate instructions included with it. B. Sl...

  • Page 8

    3 8 installation ecowater s y s t e m s 6. Cold water pipe grounding the house cold water pipe (metal only) is often used as a ground for the house electrical system. The 3--valve bypass type if installation, shown in figure 2, will maintain ground continuity. If you use the plas- tic bypass valve a...

  • Page 9

    3 9 installation ecowater s y s t e m s note: in addition to a floor drain, you can use a laundry tub or stand pipe as a good drain point for this hose. Avoid long drain hose runs, or elevating the hose. 9. Pressure testing for leaks to prevent excessive air pressure in the filter and plumbing syste...

  • Page 10

    3 10 programming face plate timer ecowater s y s t e m s figure 9 down keypad up keypad display select keypad recharge keypad vacation now (hold) when the power supply is plugged in, the model code hpf shows in the face plate display for the first few seconds. The model code is followed by a test nu...

  • Page 11

    3 11 programming face plate timer ecowater s y s t e m s number of people iron (parts per million) 1 -- 2 3 -- 4 5 -- 7 8 -- 20 1 4 days 3 days 2 days 1 day 2 4 days 3 days 2 days 1 day 3 4 days 3 days 1 day 1 day 4 3 days 2 days 1 day 1 day 5 3 days 2 days 1 day 1 day 6 2 days 1 day 1 day 1 day 7 2...

  • Page 12

    3 12 programming face plate timer ecowater s y s t e m s the default settings for fill (0 minutes), brine draw (0 minutes), backwash (25 minutes) and fast rinse (5 minutes) cycles of regeneration are factory set for maximum performance of the filter. Use the following procedures to check for correct...

  • Page 13

    3 13 programming face plate timer ecowater s y s t e m s auxiliary output control -- the electronic controller’s auxiliary output may be used to operate various types of external equipment, such as a chlorine generator or chemical feeder. It provides a 28v dc, up to 300 ma, current from terminal j4 ...

  • Page 14

    3 14 filter operation ecowater s y s t e m s general information ...Sediment filters -- a sediment filter removes, sand, clay, silt, or fine organic matter from water. You can see sediment in water by holding a sample, in a clear glass, up to a light. The particles are either suspended or settled to...

  • Page 15

    3 15 filter operation ecowater s y s t e m s service, backwash and fast rinse service (figure 10): unfiltered water enters the valve inlet port. Internal valve porting routes the wa- ter down and out the top distributor, into the mineral tank. The water is filtered as it passes through the mineral b...

  • Page 16

    3 16 service information ecowater s y s t e m s neutralizing filter -- checking the min- eral level in the tank: as explained on page 14, the mineral dissolves in the water to neutralize the acid. How fast is dissolves depends on how much water you household uses and the ph of the water. Every few m...

  • Page 17

    3 17 service information ecowater s y s t e m s troubleshooting always make these initial checks first 1. Does the time display show the correct time of day? ...If display is blank, check power source to the filter. ...If time is flashing, power was off for over two days. The filter resumes normal o...

  • Page 18

    3 18 service information ecowater s y s t e m s manual advance diagnostic use the following procedures to advance the filter valve through the regeneration cycles to check op- eration. Remove the top cover to observe cam and switch operation during valve rotation. Display must show time and day 1. P...

  • Page 19

    3 19 notes ecowater s y s t e m s.

  • Page 20

    3 20 notes ecowater s y s t e m s.

  • Page 21

    3 21 repair parts ecowater s y s t e m s 17 18 3 1 2 8 7 9 10 12 11 13 14 15 16 5 6 4 key no. Part no. Description 1 7337482 power supply, 28v dc 2 7259927 wire harness 3 7218670 top cover 4 7336363 rep’l pwa 5 7210509 face plate (order following decal) -- 7308970 decal 6 7291212 face plate support ...

  • Page 22

    3 22 repair parts ecowater s y s t e m s 1 2 3 4 5 6 7 8 9 10 11 12 17 18 13 14 15 19 20 21 22 23 25 26 16 29 30 31 32 33 cross--section view seal wear--strip flow plug assembly assembled view 28 27 24 35 34 21 23.

  • Page 23

    3 23 repair parts ecowater s y s t e m s key no. Part no. Description 1 7224087 screw, #8-32 x 1” (2 req.) 2 7286039 motor (incl. 2 ea. Of key no. 1) 3 7231393 motor plate 4 0900857 screw, #6-20 x 3/8” (3 req.) 5 7171250 bearing 6 7283489 cam and gear 7 7169180 clip (drain) 8 7172793 drain hose adap...

  • Page 24

    3 24 warranty ecowater s y s t e m s ecowater systems llc advantage warranty series etf 2100 water system congratulations! You have just purchased the highest quality water conditioning product on the market. To whom is this warranty extended? Ecowater systems llc warrants its products to the origin...