1. DL manuals
  2. F.u.n.k.e.
  3. Marine Radio
  4. TRT800H-OLED
  5. Operation And Installation

F.u.n.k.e. TRT800H-OLED Operation And Installation

Summary of TRT800H-OLED

  • Page 1

    F f.U.N.K.E. F.U.N.K.E. Means – fabrication · utilities · network · know-how · engineering operation and installation (dokument-nr. 03.2124.010.71e) p/n 800atc-h-(2xx)-(2xx) trt800h-oled mode-s transponder.

  • Page 3

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 2 document-no: 03.2124.010.71e / revision: 2.10 change history revision date description of change 1.00 18.11.2011 first release 1.01 01.11.2012 extended functions remote control interface and altitude compensation starting from software ...

  • Page 4: Table Of Contents

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 3 document-no: 03.2124.010.71e / revision: 2.10 table of contents 1 general ......................................................................................... 5 1.1 symbols .............................................................

  • Page 5

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 4 document-no: 03.2124.010.71e / revision: 2.10 3.8 antenna................................................................................. 25 3.8.1 antenna selection ...................................................... 25 3.8.2 instal...

  • Page 6: 1  General

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 5 document-no: 03.2124.010.71e / revision: 2.10 1 general this manual contains information about the physical, mechanical and electrical characteristics and about installation and operation of the mode s transponder trt800h. The condition...

  • Page 7: 1.2  Abbreviations

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 6 document-no: 03.2124.010.71e / revision: 2.10 1.2 abbreviations abb. Meaning explanation fid flight id flight plan number or if not assigned registration number of aircraft spi special position identification activation on request by co...

  • Page 8: 1.4  Features

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 7 document-no: 03.2124.010.71e / revision: 2.10 1.4 features in order to operate the mode s transponder it is necessary to request an icao 24-bit aircraft address at the responsible national aviation authorities. The received code is assi...

  • Page 9

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 8 document-no: 03.2124.010.71e / revision: 2.10 1.5 deviations and important notes the following deviations have been granted by the faa: the device is certified to faa tso-c112c in lieu of faa tso-c112d. Environmental qualification testi...

  • Page 10: 2  Operation

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 9 document-no: 03.2124.010.71e / revision: 2.10 2 operation 2.1 controls on / off „squawk ident“ activate/ deactivate vfr change active  standby squawk select operation mode cursor adjustment rotary knob for adjusting values at the curso...

  • Page 11

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 10 document-no: 03.2124.010.71e / revision: 2.10 i/o on/off ► ► switch on press button for approx. 0,5 s switch offpress button for approx. 3 s vfr vfr ► ► activate/deactivate vfr squawk (press shortly) store active squawk as vfr/vfrw-squ...

  • Page 12: 2.2  Switch On/off

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 11 document-no: 03.2124.010.71e / revision: 2.10 2.2 switch on/off switch on: press i/o for 0.5 s switch off: press i/o for 3 s 2.2.1 display information after power up after turning-on the display appears as follows (example): if more th...

  • Page 13

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 12 document-no: 03.2124.010.71e / revision: 2.10 2.3 display - indications value meaning remarks 7000 active squawk 2000 standby squawk could be changed with active squawk by pressing ▲▼ fl 030 flerr flight level invalid altitude measurin...

  • Page 14: 2.4  Display-Brightness

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 13 document-no: 03.2124.010.71e / revision: 2.10 value meaning remarks error indicators pll pll error internal error trx transmit failure check antenna and wiring dc low internal voltage internal error fpg fpga-failure internal error bat ...

  • Page 15

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 14 document-no: 03.2124.010.71e / revision: 2.10 2.5.2 configure flight-id press mode (repeatedly) until „stby“ appears press and hold id while a counter is shown beside the active squawk. Release id wh en “change fid” is displayed enter ...

  • Page 16: 2.7  Squawk-Setting

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 15 document-no: 03.2124.010.71e / revision: 2.10 if no 24-bit address (aa) was defined or entered as “000000“ the transponder operates as a mode a/c transponder, in that case the following modes are possible apart from standby: a c –  „m...

  • Page 17: 2.9  Id

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 16 document-no: 03.2124.010.71e / revision: 2.10 display standby squawk: press vfr or ▼▲ or use the rotary knob (the vfr- squawk remains active!) example: vfr vfr now the standby squawk can be adjusted by using the rotary knob and activat...

  • Page 18: 3  Installation

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 17 document-no: 03.2124.010.71e / revision: 2.10 3 installation 3.1 notes the following suggestions should be considered before installing. The assigned installation company will supply wiring. For diagrams refer to 3.7 wiring. Transponde...

  • Page 19: 3.5  Mounting

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 18 document-no: 03.2124.010.71e / revision: 2.10 3.4 unpacking and inspecting of the equipment carefully unpack the equipment and inspect for transport damages. If a damage claim has to be filed, save the shipping container and all packin...

  • Page 20

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 19 document-no: 03.2124.010.71e / revision: 2.10 3.6 equipment connections 3.6.1 electrical connections one 15 pin d-sub miniature connector includes all electrical connections, except for the antenna. Use only an external memory adapter ...

  • Page 21: 3.7  Wiring

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 20 document-no: 03.2124.010.71e / revision: 2.10 3.6.1.3 auto-on the auto-on input allows to define how the transponder will behave when power is supplied to it. If the aircraft is equipped with a dedicated avionics master switch that swi...

  • Page 22

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 21 document-no: 03.2124.010.71e / revision: 2.10 3.7.2 pin assignment the transponder may only be operated together with an external memory address adaptor trt800emxx pin signal remarks adaptor typ (4) trt800 em adaptor typ (4) trt800 ems...

  • Page 23

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 22 document-no: 03.2124.010.71e / revision: 2.10 3.7.3 cable plan external memory em800 3.7.3.1 cable plan trt800emrs (older version with interface remote) to s/n 90932013 dsub 15pol trt800h /trt800a * txd rxd fly_gnd supp_i/o gnd open ca...

  • Page 24

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 23 document-no: 03.2124.010.71e / revision: 2.10 3.7.3.2 cable plan trt800emrs (newer version with interface remote) from s/n 90932114 dsub 15pol trt800h /trt800a * txd rxd fly_gnd supp_i/o gnd open cable ends remote binder connector fema...

  • Page 25

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 24 document-no: 03.2124.010.71e / revision: 2.10 3.7.3.3 cable plan trt800emss (newer version without interface remote) from s/n 91032115 the external – memory – address - adapter trt800emxx contains electronic parts and must not be opene...

  • Page 26: 3.8  Antenna

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 25 document-no: 03.2124.010.71e / revision: 2.10 3.8 antenna 3.8.1 antenna selection recommended antennas: see section 3.11 accessories choose an antenna type compatible with the vehicle and the mounting location. Specified features depen...

  • Page 27

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 26 document-no: 03.2124.010.71e / revision: 2.10 3.9 post-installation check all steering and control functions of the aircraft are to be examined, in order to exclude disturbances by the wiring. The most important factor in the transpond...

  • Page 28: 3.10

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 27 document-no: 03.2124.010.71e / revision: 2.10 3.10 starting up turn the transponder on with i/o. After start-up the following screens appear: 3.11 accessories part number description trkabel1 antenna cable 1,0 m (3.2 ft) tnc  bnc trka...

  • Page 29: 3.12

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 28 document-no: 03.2124.010.71e / revision: 2.10 3.12 drawings 3.12.1 dimensions 20mm 15 mm 170 mm trt800 trt800h 65 mm 6 5 m m Ø 57 mm static air antenna power/rs232 3.12.2 mounting advices connections area 8 0 m m panel cut-out 47,0 mm ...

  • Page 30: 4  Transponder Settings

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 29 document-no: 03.2124.010.71e / revision: 2.10 4 transponder settings 4.1 overview the trt800h is capable of storing the following information: icao 24-bit aircraft-address (aa) aircraft category (ac), flight identification (fid) ground...

  • Page 31

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 30 document-no: 03.2124.010.71e / revision: 2.10 page 1 aircraft address aircraft category flight identification mode page 2 speed category ground switch option remote header option mode page 3 rs-232 settings: protocol, baud rate, positi...

  • Page 32: 4.3  General Settings

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 31 document-no: 03.2124.010.71e / revision: 2.10 gps receiver is connected and transmits data (if not: “pos. :no data” is displayed) a valid position is transmitted (if not: “pos. :wrong data” is displayed). While configuration summary pa...

  • Page 33

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 32 document-no: 03.2124.010.71e / revision: 2.10 4.3.3 flight-id (fid) per icao regulation mode-s data must contain a valid flight identification (fid), to ensure that the correlation between flight plan and radar data will work automatic...

  • Page 34: 4.4  Optional Settings

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 33 document-no: 03.2124.010.71e / revision: 2.10 4.3.4 reply information - speed category (ri) besides aa, ac and fid another important part of the mode-s data is the speed category of the respective aircraft. This speed category shall be...

  • Page 35

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 34 document-no: 03.2124.010.71e / revision: 2.10 4.4.2 option remote header the transponder provides a trt800rt remote control interface. If a remote header trt800rt is connected transponder can be remote controlled via this interface. Re...

  • Page 36

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 35 document-no: 03.2124.010.71e / revision: 2.10 option description baud rate favisia glass cockpit support favisia data format to be processed in favisia avionics suite. - favisia+gps data format to be processed in favisia avionics suite...

  • Page 37: 4.5  Setup Procedure

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 36 document-no: 03.2124.010.71e / revision: 2.10 the check for correspondence between the primary altimeter and the trt800h is usually performed every 24 months as part of the aircraft's altimeter checks. Altitude correction is based on s...

  • Page 38

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 37 document-no: 03.2124.010.71e / revision: 2.10 4.5.2 transponder configuration/record structure aircraft related parts of transponder configuration are stored in one out of eight possible records (record=presetting). Each record contain...

  • Page 39

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 38 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 1. Start-up transponder 2. Ensure, the transponder-mode is „stby“. If necessary change the mode by pressing mode 3. Press id a counter is shown at the upper-right cor...

  • Page 40

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 39 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 7. At this stage the respective speed category shall be selected by using the rotary knob. Mode 8. At this stage a gps receiver for ads-b out can be selected (selecta...

  • Page 41

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 40 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 11. You have now left the configuration mode and are back in normal operation. 12. Switch off the transponder 13. Switch on the transponder. Your icao 24-bit aircraft...

  • Page 42

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 41 document-no: 03.2124.010.71e / revision: 2.10 4.5.5 altitude correction setup altitude correction setup shall be executed by qualified personnel only! Pilot and owner are responsible for correctly set altitude offset values. The use/se...

  • Page 43

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 42 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 4. After release of id the first altitude level + corresponding offset value is displayed. 5. Change offset value with rotary knob mode 6. (..9) repeat last step for ...

  • Page 44: 5  Appendix

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 43 document-no: 03.2124.010.71e / revision: 2.10 5 appendix 5.1 technical data compliance cs-etso-2c112a easa.21o.269 faa tso-c112c applicable documents cs-etso-2c112a faa tso-c112c eurocae ed-73c class 1 level 2es rtca do-181d class 1 le...

  • Page 45

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 44 document-no: 03.2124.010.71e / revision: 2.10 fuse external 2a-slow-blow fuse mounting panel cut-out d=57,5 mm weight 0,6 kg (1.32 lbs.) receiver characteristics: sensitivity rf input power level resulting in a 90 % reply rate: a. Mtl ...

  • Page 46

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 45 document-no: 03.2124.010.71e / revision: 2.10 5.2 environmental conditions characteristic do –160d section cat. Condition temperature / altitude 4.0 c1 low ground survival temperature 4.5.1 – 55°c low operating temperature 4.5.1 – 20°c...

  • Page 47

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 46 document-no: 03.2124.010.71e / revision: 2.10 characteristic do –160d section cat. Condition induced signal susceptibility 19.0 a radio frequency susceptibility 20.0 tt emission of rf energy 21.0 m lightning induced transient susceptib...

  • Page 48

    Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 47 document-no: 03.2124.010.71e / revision: 2.10 notes:.

  • Page 50: F.U.N.K.E. Avionics Gmbh

    F f.U.N.K.E. F.U.N.K.E. Means – fabrication · utilities · network · know-how · engineering f.U.N.K.E. Avionics gmbh heinz-strachowitz-str. 4 de-86807 buchloe germany phone.: +49-8241 80066 0 fax.: +49-8241 80066 99 e-mail: service@funkeavionics.De www.Funkeavionics.De.