F f.U.N.K.E. F.U.N.K.E. Means – fabrication · utilities · network · know-how · engineering operation and installation (dokument-nr. 03.2124.010.71e) p/n 800atc-h-(2xx)-(2xx) trt800h-oled mode-s transponder.
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 2 document-no: 03.2124.010.71e / revision: 2.10 change history revision date description of change 1.00 18.11.2011 first release 1.01 01.11.2012 extended functions remote control interface and altitude compensation starting from software ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 3 document-no: 03.2124.010.71e / revision: 2.10 table of contents 1 general ......................................................................................... 5 1.1 symbols .............................................................
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 4 document-no: 03.2124.010.71e / revision: 2.10 3.8 antenna................................................................................. 25 3.8.1 antenna selection ...................................................... 25 3.8.2 instal...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 5 document-no: 03.2124.010.71e / revision: 2.10 1 general this manual contains information about the physical, mechanical and electrical characteristics and about installation and operation of the mode s transponder trt800h. The condition...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 6 document-no: 03.2124.010.71e / revision: 2.10 1.2 abbreviations abb. Meaning explanation fid flight id flight plan number or if not assigned registration number of aircraft spi special position identification activation on request by co...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 7 document-no: 03.2124.010.71e / revision: 2.10 1.4 features in order to operate the mode s transponder it is necessary to request an icao 24-bit aircraft address at the responsible national aviation authorities. The received code is assi...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 8 document-no: 03.2124.010.71e / revision: 2.10 1.5 deviations and important notes the following deviations have been granted by the faa: the device is certified to faa tso-c112c in lieu of faa tso-c112d. Environmental qualification testi...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 9 document-no: 03.2124.010.71e / revision: 2.10 2 operation 2.1 controls on / off „squawk ident“ activate/ deactivate vfr change active standby squawk select operation mode cursor adjustment rotary knob for adjusting values at the curso...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 10 document-no: 03.2124.010.71e / revision: 2.10 i/o on/off ► ► switch on press button for approx. 0,5 s switch offpress button for approx. 3 s vfr vfr ► ► activate/deactivate vfr squawk (press shortly) store active squawk as vfr/vfrw-squ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 11 document-no: 03.2124.010.71e / revision: 2.10 2.2 switch on/off switch on: press i/o for 0.5 s switch off: press i/o for 3 s 2.2.1 display information after power up after turning-on the display appears as follows (example): if more th...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 12 document-no: 03.2124.010.71e / revision: 2.10 2.3 display - indications value meaning remarks 7000 active squawk 2000 standby squawk could be changed with active squawk by pressing ▲▼ fl 030 flerr flight level invalid altitude measurin...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 13 document-no: 03.2124.010.71e / revision: 2.10 value meaning remarks error indicators pll pll error internal error trx transmit failure check antenna and wiring dc low internal voltage internal error fpg fpga-failure internal error bat ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 14 document-no: 03.2124.010.71e / revision: 2.10 2.5.2 configure flight-id press mode (repeatedly) until „stby“ appears press and hold id while a counter is shown beside the active squawk. Release id wh en “change fid” is displayed enter ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 15 document-no: 03.2124.010.71e / revision: 2.10 if no 24-bit address (aa) was defined or entered as “000000“ the transponder operates as a mode a/c transponder, in that case the following modes are possible apart from standby: a c – „m...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 16 document-no: 03.2124.010.71e / revision: 2.10 display standby squawk: press vfr or ▼▲ or use the rotary knob (the vfr- squawk remains active!) example: vfr vfr now the standby squawk can be adjusted by using the rotary knob and activat...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 17 document-no: 03.2124.010.71e / revision: 2.10 3 installation 3.1 notes the following suggestions should be considered before installing. The assigned installation company will supply wiring. For diagrams refer to 3.7 wiring. Transponde...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 18 document-no: 03.2124.010.71e / revision: 2.10 3.4 unpacking and inspecting of the equipment carefully unpack the equipment and inspect for transport damages. If a damage claim has to be filed, save the shipping container and all packin...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 19 document-no: 03.2124.010.71e / revision: 2.10 3.6 equipment connections 3.6.1 electrical connections one 15 pin d-sub miniature connector includes all electrical connections, except for the antenna. Use only an external memory adapter ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 20 document-no: 03.2124.010.71e / revision: 2.10 3.6.1.3 auto-on the auto-on input allows to define how the transponder will behave when power is supplied to it. If the aircraft is equipped with a dedicated avionics master switch that swi...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 21 document-no: 03.2124.010.71e / revision: 2.10 3.7.2 pin assignment the transponder may only be operated together with an external memory address adaptor trt800emxx pin signal remarks adaptor typ (4) trt800 em adaptor typ (4) trt800 ems...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 22 document-no: 03.2124.010.71e / revision: 2.10 3.7.3 cable plan external memory em800 3.7.3.1 cable plan trt800emrs (older version with interface remote) to s/n 90932013 dsub 15pol trt800h /trt800a * txd rxd fly_gnd supp_i/o gnd open ca...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 23 document-no: 03.2124.010.71e / revision: 2.10 3.7.3.2 cable plan trt800emrs (newer version with interface remote) from s/n 90932114 dsub 15pol trt800h /trt800a * txd rxd fly_gnd supp_i/o gnd open cable ends remote binder connector fema...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 24 document-no: 03.2124.010.71e / revision: 2.10 3.7.3.3 cable plan trt800emss (newer version without interface remote) from s/n 91032115 the external – memory – address - adapter trt800emxx contains electronic parts and must not be opene...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 25 document-no: 03.2124.010.71e / revision: 2.10 3.8 antenna 3.8.1 antenna selection recommended antennas: see section 3.11 accessories choose an antenna type compatible with the vehicle and the mounting location. Specified features depen...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 26 document-no: 03.2124.010.71e / revision: 2.10 3.9 post-installation check all steering and control functions of the aircraft are to be examined, in order to exclude disturbances by the wiring. The most important factor in the transpond...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 27 document-no: 03.2124.010.71e / revision: 2.10 3.10 starting up turn the transponder on with i/o. After start-up the following screens appear: 3.11 accessories part number description trkabel1 antenna cable 1,0 m (3.2 ft) tnc bnc trka...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 28 document-no: 03.2124.010.71e / revision: 2.10 3.12 drawings 3.12.1 dimensions 20mm 15 mm 170 mm trt800 trt800h 65 mm 6 5 m m Ø 57 mm static air antenna power/rs232 3.12.2 mounting advices connections area 8 0 m m panel cut-out 47,0 mm ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 29 document-no: 03.2124.010.71e / revision: 2.10 4 transponder settings 4.1 overview the trt800h is capable of storing the following information: icao 24-bit aircraft-address (aa) aircraft category (ac), flight identification (fid) ground...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 30 document-no: 03.2124.010.71e / revision: 2.10 page 1 aircraft address aircraft category flight identification mode page 2 speed category ground switch option remote header option mode page 3 rs-232 settings: protocol, baud rate, positi...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 31 document-no: 03.2124.010.71e / revision: 2.10 gps receiver is connected and transmits data (if not: “pos. :no data” is displayed) a valid position is transmitted (if not: “pos. :wrong data” is displayed). While configuration summary pa...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 32 document-no: 03.2124.010.71e / revision: 2.10 4.3.3 flight-id (fid) per icao regulation mode-s data must contain a valid flight identification (fid), to ensure that the correlation between flight plan and radar data will work automatic...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 33 document-no: 03.2124.010.71e / revision: 2.10 4.3.4 reply information - speed category (ri) besides aa, ac and fid another important part of the mode-s data is the speed category of the respective aircraft. This speed category shall be...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 34 document-no: 03.2124.010.71e / revision: 2.10 4.4.2 option remote header the transponder provides a trt800rt remote control interface. If a remote header trt800rt is connected transponder can be remote controlled via this interface. Re...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 35 document-no: 03.2124.010.71e / revision: 2.10 option description baud rate favisia glass cockpit support favisia data format to be processed in favisia avionics suite. - favisia+gps data format to be processed in favisia avionics suite...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 36 document-no: 03.2124.010.71e / revision: 2.10 the check for correspondence between the primary altimeter and the trt800h is usually performed every 24 months as part of the aircraft's altimeter checks. Altitude correction is based on s...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 37 document-no: 03.2124.010.71e / revision: 2.10 4.5.2 transponder configuration/record structure aircraft related parts of transponder configuration are stored in one out of eight possible records (record=presetting). Each record contain...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 38 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 1. Start-up transponder 2. Ensure, the transponder-mode is „stby“. If necessary change the mode by pressing mode 3. Press id a counter is shown at the upper-right cor...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 39 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 7. At this stage the respective speed category shall be selected by using the rotary knob. Mode 8. At this stage a gps receiver for ads-b out can be selected (selecta...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 40 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 11. You have now left the configuration mode and are back in normal operation. 12. Switch off the transponder 13. Switch on the transponder. Your icao 24-bit aircraft...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 41 document-no: 03.2124.010.71e / revision: 2.10 4.5.5 altitude correction setup altitude correction setup shall be executed by qualified personnel only! Pilot and owner are responsible for correctly set altitude offset values. The use/se...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 42 document-no: 03.2124.010.71e / revision: 2.10 step display (example) 4. After release of id the first altitude level + corresponding offset value is displayed. 5. Change offset value with rotary knob mode 6. (..9) repeat last step for ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 43 document-no: 03.2124.010.71e / revision: 2.10 5 appendix 5.1 technical data compliance cs-etso-2c112a easa.21o.269 faa tso-c112c applicable documents cs-etso-2c112a faa tso-c112c eurocae ed-73c class 1 level 2es rtca do-181d class 1 le...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 44 document-no: 03.2124.010.71e / revision: 2.10 fuse external 2a-slow-blow fuse mounting panel cut-out d=57,5 mm weight 0,6 kg (1.32 lbs.) receiver characteristics: sensitivity rf input power level resulting in a 90 % reply rate: a. Mtl ...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 45 document-no: 03.2124.010.71e / revision: 2.10 5.2 environmental conditions characteristic do –160d section cat. Condition temperature / altitude 4.0 c1 low ground survival temperature 4.5.1 – 55°c low operating temperature 4.5.1 – 20°c...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 46 document-no: 03.2124.010.71e / revision: 2.10 characteristic do –160d section cat. Condition induced signal susceptibility 19.0 a radio frequency susceptibility 20.0 tt emission of rf energy 21.0 m lightning induced transient susceptib...
Trt800h / p/n 800atc-h-(2xx)-(2xx) operation and installation 47 document-no: 03.2124.010.71e / revision: 2.10 notes:.
F f.U.N.K.E. F.U.N.K.E. Means – fabrication · utilities · network · know-how · engineering f.U.N.K.E. Avionics gmbh heinz-strachowitz-str. 4 de-86807 buchloe germany phone.: +49-8241 80066 0 fax.: +49-8241 80066 99 e-mail: service@funkeavionics.De www.Funkeavionics.De.