- DL manuals
- Fagor
- Refrigerator
- QF-1
- Installation, Use And Maintenance Manual
Fagor QF-1 Installation, Use And Maintenance Manual
Summary of QF-1
Page 1
Refrigerators and freezers manual for installation, use, and maintenance.
Page 2
Www.Fagorcommercial.Com page 2 reach-ins operational service manual / rev.Jun. 2015 contents 1 receiving and inspecting the equipment .................................................................................... 3 2 specifications .................................................................
Page 3
Www.Fagorcommercial.Com page 3 reach-ins operational service manual / rev.Jun. 2015 1 receiving and inspecting the equipment up on receiving your new fagor refrigerator, check the package and the machine for any damages that may have occurred during transportation. Visually inspect the exterior of t...
Page 4
Www.Fagorcommercial.Com page 4 reach-ins operational service manual / rev.Jun. 2015 2 specifications reach in refrigerators and freezers, general specs model capac. (cu.Ft.) # of shvls btu's/hr charge onz. Ref. Ship weight qr-1 23 3 1666 11.3 r-134a 295 qr-2 49 6 2104 13.4 r-134a 475 qf-1 23 3 2493 ...
Page 5
Www.Fagorcommercial.Com page 5 reach-ins operational service manual / rev.Jun. 2015 reach in refrigerators and freezers, electrical specs model max. Amps hp voltage nema plug breaker size* wire gauge recommended for 2% voltage drop in supply circuits ** 40 ft *** 60 ft 80 ft 100 ft 120 ft 140 ft qr-...
Page 6
Www.Fagorcommercial.Com page 6 reach-ins operational service manual / rev.Jun. 2015 3 installation 3.1 un crating remove the outer packaging. Cut the 4 clamps that hold the refrigerator to the skid. Lift the unit off the skid. If machine was laid down during this operation, remember to leave the cab...
Page 7
Www.Fagorcommercial.Com page 7 reach-ins operational service manual / rev.Jun. 2015 outside cabinet: be sure that the unit has access to ample air to breathe. Avoid hot corners and locations near stoves and ovens. It is recommended the unit be installed no closer than 3” from any wall. The place whe...
Page 8
Www.Fagorcommercial.Com page 8 reach-ins operational service manual / rev.Jun. 2015 slide out unit until castor holes are exposed. Castors with brakes must be installed in the front of the unit carefully, lift the unit high enough to install the casters. Repeat the same operation to install the rema...
Page 9
Www.Fagorcommercial.Com page 9 reach-ins operational service manual / rev.Jun. 2015 3.5 leveling set unit in its final location. A level cabinet looks better and will perform better. Effective condensate removal and door operation will be effected by leveling. Machine must be leveled front to back a...
Page 10
Www.Fagorcommercial.Com page 10 reach-ins operational service manual / rev.Jun. 2015 installation. 3.7 shelving installation hook shelf rails onto shelf pilasters position all shelf rails equal in distance from the floor for level shelves wire shelves are oriented so that cross support bars are faci...
Page 11
Www.Fagorcommercial.Com page 11 reach-ins operational service manual / rev.Jun. 2015.
Page 12
Www.Fagorcommercial.Com page 12 reach-ins operational service manual / rev.Jun. 2015 description of buttons on the controller to increase set point of temperature to turn t h e u n i t on/off without unplugging the equipment (press and hold 3 seconds) to change the set point to access programming mo...
Page 13
Www.Fagorcommercial.Com page 13 reach-ins operational service manual / rev.Jun. 2015 2. Press the up and down arrows to increase or decrease the set temperature. Then press the set button to save the new set point. Note: the maximum value you can set in the controller is: for refrigerators: 5°c (40°...
Page 14: Caution!
Www.Fagorcommercial.Com page 14 reach-ins operational service manual / rev.Jun. 2015 freezer equipment can be used like a refrigerator by selecting the value of the parameter “ezy” according to the chart above. Refrigerators must never be used like a freezer. After you chose the value for the “ezy” ...
Page 15
Www.Fagorcommercial.Com page 15 reach-ins operational service manual / rev.Jun. 2015 carel control (ir33+) the operating parameters can be modified using the front keypad. Access differs depending on the type: set point, frequently-used parameters (f) and configuration parameters (c). The type of pa...
Page 16
Www.Fagorcommercial.Com page 16 reach-ins operational service manual / rev.Jun. 2015 setting type c parameters type c parameters include the type f parameters plus all the other control parameters. Procedure: 1. Press prg/mute one or more times to return to the standard display; 2. Press prg/mute fo...
Page 17
Www.Fagorcommercial.Com page 17 reach-ins operational service manual / rev.Jun. 2015 5 maintenance 5.1 stainless steel care and cleaning proper cleaning of stainless steel requires soft cloths or plastic scouring pads. Never use steel pads, wire brushes, or scrapers! Cleaning solutions need to be al...
Page 18
Www.Fagorcommercial.Com page 18 reach-ins operational service manual / rev.Jun. 2015 never use high pressure water for cleaning the condenser coil. Water can damage the electrical components located near or at the condenser coil. Do not place filter material in front of condenser coil. This material...
Page 19
Www.Fagorcommercial.Com page 19 reach-ins operational service manual / rev.Jun. 2015 5.5 drain each unit comes equipped with a drain pan located outside the unit. The drain pan catches the condensation produced inside the evaporator coil. If the drain hose become loose or disconnected from moving or...
Page 20
Www.Fagorcommercial.Com page 20 reach-ins operational service manual / rev.Jun. 2015 6 trouble shooting follow the next steps before requesting warranty service. Failure to do so, may result in service charges for you and may void your warranty: 1) refrigerator doesn’t work: a. Check that the machin...
Page 21
Www.Fagorcommercial.Com page 21 reach-ins operational service manual / rev.Jun. 2015 7 wiring diagrams qr 1 – qvr 1.
Page 22
Www.Fagorcommercial.Com page 22 reach-ins operational service manual / rev.Jun. 2015 qf1 – qvf 1.
Page 23
Www.Fagorcommercial.Com page 23 reach-ins operational service manual / rev.Jun. 2015 qr2 – qvr 2.
Page 24
Www.Fagorcommercial.Com page 24 reach-ins operational service manual / rev.Jun. 2015 qr 1g – qvr 1g.
Page 25
Www.Fagorcommercial.Com page 25 reach-ins operational service manual / rev.Jun. 2015 8 warranty as of april 1, 2014 three years parts & labor warranty: fagor commercial, inc. (“fagor”) warrants to the fist-end-user purchaser (the “user”) that the fagor brand equipment sold hereunder, except for part...
Page 26
Www.Fagorcommercial.Com page 26 reach-ins operational service manual / rev.Jun. 2015 proper maintenance and operation: the equipment must be properly maintained and operated in accordance with fagor’s maintenance and operating procedures. All service, labor and parts must be acquired from fagor or i...
Page 27
Www.Fagorcommercial.Com page 27 reach-ins operational service manual / rev.Jun. 2015 terms & conditions prices & specifications: fagor reserves the right to change the prices and specifications of the equipment and/or material without notice. Prices are fob fagor warehouses. All orders are subject t...
Page 28
Www.Fagorcommercial.Com page 28 reach-ins operational service manual / rev.Jun. 2015 fagor commercial, inc. 13105nw 47thave miami, fl. 33054 tel:(305) 7790170 fax:(305)7790173 1-866-go-fagor www.Fagorcommercial.Com.