Galaxy PH40V Instruction Manual - page 27
25
(
Fault
Cause
Remedy
Intermittent(and(
irregular(feed(
1.(Feed(bracket(set(too(narrow(
2.(Gap(between(feed(and(
pressure(roller(too(narrow(
3.(Infeed(roller(pressure(
insufficient(or(roller(worn(out(
4.(Feeder(Shaft(drive(belt(worn(
1.(Loosen(the(bracket(by(a(little(
2.(Increase(gap(with(setting(knob((
(
3.(Increase(feed(on(the(feeder(or(
replace(infeed(roller(
4.(Replace(belt(
Very(lightDweight(
paper(grade(
becomes(creased(
1.(Infeed(roller(pressure(too(
strong(
2.(Gap(between(feed(and(
pressure(roller(too(narrow(
3.(Speed(too(high(
4.(Paper(runs(at(an(angle(
5.(Pressure(of(first(pair(of((fold(
rollers(too(strong(our(uneven(
1.(Reduce(feed(pressure(with(
knurled(nut(
2.(Increase(gap(with(setting(knob((
(
3.(Reduce(speed(
4.(Correct(with(feed(brackets(
5.(Have(pressure(and(parallel(fold(
roller(alignment(set(by(our(
service(engineer(((fold(roller(
arrangement(is(suitable(for(all(
paper(grades(in(general(use,(but(
for(some(very(thin(papers,(fold(
roller(pressure(can(be(altered()(
Two(or(more(sheets(
drawn(in(together(
The(folding(machine(
has(stopped(
1.(Gap(between(feed(and(
pressure(roller(too(wide(
2.(Paper(jam,(the(blocking(
prevention(has(switched(off(
the(folder(
1.(Narrow(gap(with(setting(knob(
(
2.(Clear(paper(jam.(To(restart(the(
machine,(it(has(to(be(switched(off
and(then(switched(on(again.(
Folded(sheets(slide(
one(inside(the(other(
Gap(between(ejector(roller(and(
holdDdown(rollers(too(wide(or(
too(short(
Correct(the(holdDdown(wheel(
distance(
Sheets(jam(between(
ejector(roller(and(
holdDdown(rollers(
1.(Gap(between(ejector(spindles(
and(holdDdown(rollers(too(
short(
2.(Ejector(rollers(not(evenly(
spaced(over(sheet(width(
(
3.(Ejector(rollers(worn(
1.(Correct(the(holdDdown(wheel(
distance(
(
2.(Reposition(the(rollers,(together(
with(the(scoring(wheels,(so(that(
they(will(guide(the(paper(evenly(
3.(Replace(rollers(
Sheets(not(evenly(
fanned(on(delivery(
1.(Paper(feed(irregular(
(
2.(Ejector(rollers(worn(or(not(
evenly(set(
3.(Delivery(belt(is(slack(
(
4.(Drive(belt(of(delivery(belt(worn(
1.(Correct(setting(((see(section(on(
“paper(feed”()(
2.(Replace(or(reposition(rollers(
(
3.(Tension(belt(or(replace(it,(if(
necessary(
4.(Fit(new(drive(belt(