1. DL manuals
  2. Garmin
  3. GPS
  4. GPS 165
  5. Installation Manual

Garmin GPS 165 Installation Manual

Other manuals for GPS 165: Pilot's Manual Addendum
Manual is about: Garmin GPS Navigator Installation manual

Summary of GPS 165

  • Page 1

    Av. Kit install. Manual 190-00066-02 rev. J page 1 gps 165 installation manual garmin international, inc. Part number: 190-00066-02 1200 e. 151st street revision j, 27 march 1998 olathe, kansas 66062-3426.

  • Page 2

    Av. Kit install. Manual 190-00066-02 rev. J page 2 © copyright 1994-1998 garmin corporation all rights reserved this publication is the proprietary property of garmin international, inc. It may not be reproduced or transmitted in any form whether printed or electronic, without the expressed written ...

  • Page 3

    Av. Kit install. Manual 190-00066-02 rev. J page 3 table of contents section 1 general description 1.1 introduction 1.2 technical characteristics 1.2.1 physical characteristics 1.2.2 operational characteristics 1.2.3 interfaces 1.2.3.1 37 pin connector (j101) 1.2.3.2 26 pin connector (j102) section ...

  • Page 4

    Av. Kit install. Manual 190-00066-02 rev. J page 4 4.3.5 external switch test 4.3.6 altitude input test 4.3.7 power test 4.3.8 signal acquisition test 4.3.9 vhf comm interference check section 5 certification section 6 continued airworthiness appendix a certification documents appendix b connector c...

  • Page 5

    Av. Kit install. Manual 190-00066-02 rev. J page 5 list of illustrations figure 1-1 pinout definition, 37 pin dsub 1-2 pinout definition, 26 pin hd-dsub 1-3 interconnect schematic 2-1 antenna installation considerations 2-2 gps installation considerations 3-1 remote battery pack assembly 3-2 ga 56 a...

  • Page 6

    Av. Kit install. Manual 190-00066-02 rev. J page 6 section 1 general description 1.1 introduction this manual describes the physical, mechanical, and electrical characteristics and the installation requirements for the gps 165 aviation kit. After installation of the gps 165 system, faa form 337 must...

  • Page 7

    Av. Kit install. Manual 190-00066-02 rev. J page 7 c depicts the interconnect between the rack and other instruments using discrete switch annunciators. The following interfaces are provided. 1.2.3.1 37 pin connector (j101) cdi: capable of driving up to three 1000 ohm parallel (pins 1 and 5) cdi loa...

  • Page 8

    Av. Kit install. Manual 190-00066-02 rev. J page 8 rs422 input: input capable of receiving serial obs data from (pins 11 and 27) collins pro line 2 efis dsp unit. Gps approach select switch: input, when grounded, arms approach mode. (pin 9) gps obs: capable of interfacing with a standard obs (pins 1...

  • Page 9

    Av. Kit install. Manual 190-00066-02 rev. J page 9 2.1.3 electrical bonding no special precautions need to be taken to provide a bonding path between the antenna and the aircraft structure. 2.1.4 vhf comm interference on many panel-mounted aircraft the vhf comm radiates strong harmonics from the uni...

  • Page 10

    Av. Kit install. Manual 190-00066-02 rev. J page 10 2.5 external altitude input pressure altitude input from an external source may be derived from a rs-232 compatible serial altitude input or parallel greycode/gillham altitude as described in section 4 of this manual. Gillham altitude is not requir...

  • Page 11

    Av. Kit install. Manual 190-00066-02 rev. J page 11 section 3 installation procedure 3.1 installation accessories the following installation accessories are available. Antenna options 010-10040-01 ga 56 low profile antenna kit, w/o cable includes: 011-00134-00 low profile antenna subassembly 1 115-0...

  • Page 12

    Av. Kit install. Manual 190-00066-02 rev. J page 12 c. Seal the antenna and gasket to the fuselage using a good quality electrical grade sealant. Use caution to insure that the antenna connector is not contaminated with sealant. Insure that the mounting screws are fully tightened and that the antenn...

  • Page 13

    Av. Kit install. Manual 190-00066-02 rev. J page 13 3.4 gps 165 unit installation and removal prepare a 2.25 inch high opening in the aircraft's dzusrail avionics stack. Prepare a wiring harness according to figure 1-3 interconnect schematic. Give provision for a 12" minimum service loop in all gps ...

  • Page 14

    Av. Kit install. Manual 190-00066-02 rev. J page 14 4.2 installation configuration 4.2.1 selected course calibration select the test page displaying the selected course input. Using an extremely accurate input source, input 150° to the gps 165. The input course will indicate close to 150° and a “cal...

  • Page 15

    Av. Kit install. Manual 190-00066-02 rev. J page 15 electronics international, fp-5l, fuel flow computer (non- tso'd) garmin, gps 195 garmin, gps iii 4.2.3 rs-422 channel select the rs-422 channel test page. Change the selectable input and output to match that of the installed equipment. The availab...

  • Page 16

    Av. Kit install. Manual 190-00066-02 rev. J page 16 navigation/position data label (octal) description 100 selected course 114 desired track 115 bearing to waypoint 116 cross track error 121 horizontal command (to autopilot) 251 distance to go 252 time to go 310 present position latitude 311 present...

  • Page 17

    Av. Kit install. Manual 190-00066-02 rev. J page 17 *these labels are formatted per the general aviation manufacturers association (gama) definition. Note that the use of a 429 device w/o gama will cause the loss of the above asterisked labels. Some may be required for a1 certification. For example,...

  • Page 18

    Av. Kit install. Manual 190-00066-02 rev. J page 18 input: field description off no available selections output: field description off no units connected to channel 2 input plotting serial position, velocity, navigation and satellite data to: nmea 0183 version 2.0 compatible mapping device or garmin...

  • Page 19

    Av. Kit install. Manual 190-00066-02 rev. J page 19 cdi flag in view ensure cdi flag is in view out of view ensure cdi flag is out of view superflag in view ensure superflag in view out of view ensure superflag out of view 4.3.2 obi test select the obi test page by removing the cursor from the cdi t...

  • Page 20

    Av. Kit install. Manual 190-00066-02 rev. J page 20 msg annunciator off ensure the message annunciator is off on ensure the message annunciator is on arrival annunciator off ensure the arrival annunciator is off on ensure the arrival annunciator is on approach annunciator off ensure the approach ann...

  • Page 21

    Av. Kit install. Manual 190-00066-02 rev. J page 21 and is functioning properly (see chapter 5 of the gps 165 pilot's guide for more information on the direct function). 4.3.9 vhf comm interference check a) go to the satellite status page, verify that 7 to 8 satellites have been acquired b) see that...

  • Page 22

    Av. Kit install. Manual 190-00066-02 rev. J page 22 figure 1-1 pinout definition, 37 pin dsub.

  • Page 23

    Av. Kit install. Manual 190-00066-02 rev. J page 23 figure 1-2 pinout definition, 26 pin hd-dsub.

  • Page 24

    Av. Kit install. Manual 190-00066-02 rev. J page 24 figure 1-3a interconnect schematic.

  • Page 25

    Av. Kit install. Manual 190-00066-02 rev. J page 25 figure 1-3b interconnect schematic.

  • Page 26

    Av. Kit install. Manual 190-00066-02 rev. J page 26 figure 1-3c interconnect schematic.

  • Page 27

    Av. Kit install. Manual 190-00066-02 rev. J page 27 fig 2-1 antenna installation considerations antenna masked by vertical fin, t tail, or dorsal fin antenna must be on top of aircraft. Ok maintain 6"(16 cm) compass safe distance fig 2-2 gps installation considerations.

  • Page 28

    Av. Kit install. Manual 190-00066-02 rev. J page 28 figure 3-1 remote battery pack assembly.

  • Page 29

    Av. Kit install. Manual 190-00066-02 rev. J page 29 figure 3-2 ga 56 antenna installation.

  • Page 30

    Av. Kit install. Manual 190-00066-02 rev. J page 30 figure 3-3 flange mount ga 56 antenna installation.

  • Page 31

    Av. Kit install. Manual 190-00066-02 rev. J page 31 figure 3-4 coax cable installation.

  • Page 32

    Av. Kit install. Manual 190-00066-02 rev. J page 32 figure 3-5 gps 165 face dimensions.

  • Page 33

    Av. Kit install. Manual 190-00066-02 rev. J page 33 figure 3-6 aviation rack installation.

  • Page 34

    $33(1',;$&(57,),&$7,21'2&80(176 $y.Lw,qvwdoo0dqxdo 5hy- 3djh (19,5210(17$/48$/,),&$7,21)250 120(1&/$785( *36*36$,5%251(51$96 7 762180%(5& &/$66$ 0$18)$&785(5663(&,),&$7,21$1'2527+(5$33/,&$%/(63(&,),&$7,21 0$18)$&785(5 *$50,1,17(51$7,21$/,1& $''5(66 (vw675((72/$7+(.6 &rqglwlrqv 6hfwlrq 'hvfulswlrqri&...

  • Page 35

    $y.Lw,qvwdoo0dqxdo 5hy- 3djh &rqglwlrqv 6hfwlrq 'hvfulswlrqri&rqgxfwhg7hvwv 6dqgdqg'xvw (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg )xqjxv (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg 6dow6sud\ (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg 0djqhwlf(iihfw (txlsphqwwhvwhglv&odvv= 3rzhu,qsxw (txlsphqww...

  • Page 36

    $y.Lw,qvwdoo0dqxdo 5hy- 3djh (19,5210(17$/48$/,),&$7,21)250 120(1&/$785( *$*36$9,$7,21$17(11$ 7 762180%(5& &/$66$ 0$18)$&785(5663(&,),&$7,21$1'2527+(5$33/,&$%/(63(&,),&$7,21 0$18)$&785(5 *$50,1,17(51$7,21$/,1& $''5(66 (vw675((72/$7+(.6 &rqglwlrqv 6hfwlrq 'hvfulswlrqri&rqgxfwhg7hvwv 7hpshudwxuhdqg$ow...

  • Page 37

    $y.Lw,qvwdoo0dqxdo 5hy- 3djh &rqglwlrqv 6hfwlrq 'hvfulswlrqri&rqgxfwhg7hvwv 6dqgdqg'xvw (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg )xqjxv (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg 6dow6sud\ (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg 0djqhwlf(iihfw (txlsphqwlghqwlilhgdv&dwhjru\;qrwhvwuhtxluhg ...

  • Page 38

    $y.Lw,qvwdoo0dqxdo 5hy- 3djh appendix b connector changes stamped contact connector usage garmin panel mount gps radios have previously been shipped with stamped crimp type contacts. All products are now being shipped with machined mil-spec contacts with color-coded barrels. The following figures ca...

  • Page 39

    Figure c-1 interconnect schematic appendix c reference discrete switch/annunciator installation av. Kit install. Manual 190-00066-02 rev. J page 39.

  • Page 40

    Figure c-2 interconnect schematic av. Kit install. Manual 190-00066-02 rev. J page 40

  • Page 41

    Figure c-3 switch/annunciator layout av. Kit install. Manual 190-00066-02 rev. J page 41.

  • Page 42

    Av. Kit install. Manual 190-00066-02 rev. J page 42 appendix d stc permission consistent with n8110.69 or order 8110.4, aviation authority approved installers are hereby granted permission to use stc# sa00155wi data to modify aircraft..

  • Page 43

    Av. Kit install. Manual 190-00066-02 rev. J page 43.