H.E.R.O. H2K 3819 Owner's Manual - Important
Owner’s Manual
HK3819 / HK5523
Page 3
IMPORTANT
AS WITH ALL MECHANICAL EQUIPMENT, PROPER OPERATING AND MAINTENANCE
PROCEDURES ARE REQUIRED TO KEEP YOUR H.E.R.O. AIRLESS PUMP PERFORMING TO
YOUR SATISFACTION. THE FOLLOWING SAFETY, OPERATING AND MAINTENANCE
INSTRUCTIONS ARE IMPORTANT.
Read and understand this manual completely, especially with regard to all safety precautions. Read and follow
instructions on all warning labels on your equipment. Keep these warning labels clean and readable at all times.
Order new labels from your local distributor or from H.E.R.O. if needed.
This system is capable of producing 3000 psi (spray pressure). To avoid rupture and injury DO NOT operate this
pump with components rated less than 3000 psi working pressure (including but not limited to spray guns, hose
and connections).
Before servicing, cleaning or removal of any part, shut off power and relieve pressure.
WARNING
Prior to the use of the sprayer, ensure that the grounded continuity between the gun and the sprayer is
maintained. The hose shall be at least 50 feet in length. All hoses, guns, and accessories shall be suitable for
the maximum pressure ( 3000 PSI ). The gun shall be provided with a “Safety” which locks the trigger in the
“OFF” position. DO NOT point the gun at another person or spray at operator’s exposed skin. If there are any
special or unique conditions for this appliance, they shall be further noted and addressed and must be followed.
The manufacturer shall not be responsible for any loss, damages, or injury of any kind or nature whatsoever
resulting from the use of equipment other than in strict compliance with the instructions, cautions and warnings
contained in this operating and instruction manual and as displayed on the face of the equipment.
N
ever
place fingers near spray tip of gun. Never point gun toward any part of the body, or that of any other
person. Material issuing from the spray tip is at high pressure. If fingers, or any part of the body are placed near
the tip of the spray gun, it is possible that the spray could break the skin and inject some of the material. If injury
does occur, seek the immediate medical attention. Be prepared to inform the doctor what fluid was injected,
if the injury is of an injection nature. Never treat the situation as a simple matter. Equipment and chemicals,
when used improperly can be dangerous.
IMPORTANT SAFETY PRECAUTIONS
IMPORTANT SAFETY PRECAUTIONS
NEVER place any part of the body in front of the spray tip or aim the gun toward any part of the body.
NEVER point the gun toward any individual.
NEVER treat any injury as a simple cut. If injury does occur, seek immediate medical attention. Be pre-
pared to inform the doctor what fluid was injected.
NEVER allow another person to use the sprayer unless they are thoroughly instructed on its operation
and have read all safety precautions in this manual and all safety warning labels attached to unit.
NEVER use around children.
NEVER attempt to perform any maintenance or service on any part of the unit spray system without first;
1. Shutting the motor ON/OFF switch to OFF.
2. Relieving all pressure in the pump by triggering the gun.
3. Locking gun trigger in "LOCKED" position, with gun locked closed.
4. Open prime valve to drain.
NEVER operate the sprayer without the tip guard complete and in place.
NEVER spray any material in the vicinity of open flame, pilot lights, electrical outlets or any other source of
ignition.
NEVER spray volatile materials with flash points lower than 140 F (60 C).