Certified for canada and u.S.A outdoor gas barbeque owner’s manual this manual is for use with 700, 700bi and 850bi series grills warning: please read and understand the contents of this manual fully before operating. Failure to do so may result in fire or explosion. Homeowners should retain these i...
Table of contents: safety. 3 lp gas cylinder replacement. 4-5 opd equipped cylinder. 6 hose and regulator. 6 leak testing. 7 installation. 8 clearances. 9 assembly. 10-13 getting to know your grill 14 lighting instructions. 15 gas conversion. 16-18 maintenance. 19 grilling tips and techniques. 20 tr...
Safety: your new jackson grill barbeque is a safe, convenient appliance when used and maintained properly. As with all gas-fired appliances, certain safety precautions must be observed. Failure to follow these precautions may result in damage or injury. If you have any questions or concerns regardin...
Lp gas cylinder placement: cylinders must be installed according to assembly instructions. Install the gas cylinder into the tank hole inside of the jackson pedestal. Lp gas cylinder: qcc-1 quick closing coupling your grill is designed to be used with an lp gas cylinder equipped with the new qcc-1 q...
Handling: 1. Government regulations prohibit shipping full lp gas cylinders. You must take your new cylinder to an lp gas dealer for filling. 2. A filled lp gas cylinder is under very high pressure. Always handle with care and transport in the upright position. Protect the valve from accidental dama...
Opd equipped cylinder: effective january 1, 1998, the standard for outdoor gas appliances, ansi z21.58/can cga-1.6, requires that appliances are to be used with cylinders equipped with an overfill prevention device (opd). The opd is designed to reduce the potential for the overfilling of propane cyl...
4. Leak test the connection. See “leak test”. 5. Refer to lighting instructions. To avoid activating the flow limiting device when lighting, open the cylinder valve slowly with the appliance valves off. If the flow limiting device is accidentally activated, turn off cylinder valve and appliance valv...
Installation: in canada, this appliance must be installed in accordance with the local code and relevant cga standards: can/cga-b149.1 lp gas/propane installation code and latest codes where applicable. In the usa, this appliance must be installed in accordance with the local code and relevant natio...
Installing 700bi / 50bi into a non combustible island. 8 n s are in inches: bi all dime sion 700 850 bi a .25 .25 32 39 b 5” 9.25” 9.2 c 7” 17” 1 d 5” 25” 10.2 10. E ” 3” 3 f 17.25” 17.25” g 24.25” 24.25” h 24” min. 24” min. I 18.25” 18.25” j 5.5” min 5.5” min note: all measurements are finished cut...
Assembly: please ensure the proper tools are used for ease of installation. Some assemb e required if this unit is installed in a pedestal. Please remove onents from the packaging and inspect all components to ensure there is no damage to any components in the packa damage is present please contact ...
After the side shelves ossible. Secure the condiment bins to the display panel using the screws from the securing plates. Have been installed, ensure the grill head is pushed back in the pedestal as far as through the side of the condiment bins and p with the screws removed from the securing straps,...
Rotisserie kit completed installation rotisserie rod bushing placed on the cut out provided on the inner hood upper flavor shield, cooking grid installation. At all protective plastic has remove the upper flavor shields form the packaging. Please ensure th been moved from these parts. Hese upper fla...
Main gas line connections for propane gas and natural gas. The main fuel supply gas line is connected to a manifold tee securely mounted inside the pedestal located on the left hand side of the pedestal. Remove the propane hose and regulator assembly from the packaging. Please ensure that there is n...
Getting to know your grill. 1 outer hood handle 11 pull out grease tray 2 hood thermometer 12 main control knobs / display panel 3 outer hood 13 electronic ignition 4 cooking grids 14 side burner side shelf 5 side shelf 15 warming rack 6 condiment bins x 2 16 infrared rear burner 7 pedestal 8 pedest...
Main burner lighting to light the main burners start with any burner. Turn the control knob to the left and it will spark the igniter a you turn the control knob. Once this burner has lit, simply repeat this step for the remaining burners. Th s e rocess is the same . . If the burner does not immedia...
Main burner use wh los en sear is recommended by opera all main sition with the lid c ed for utes. C king will ensure a more even temper tha and cook more e ly. F d tha ger than 30 minutes, such oasts ctly (with the burner lit o osite ement). W co as chicken breasts or lean por the grids can be oile...
Main burner orifices 2 phillips screw driver remove the y remove the grease pan. Using a 13 mm wrench undo all of the main burner ices included in the natural gas conversion kit. Ces supplied. 5 before reinstalling the main burner tubes, using a # 2 phillips screwdriver, loosen the screw at ce of 1/...
Side burner open the side id and the grate above the ead. Burner l remove 1 open the side burner lid and remove the grate over the burner head. 2 undo the 2 phillips head screws that hold the flame away from the burner head. 3 undo the 3 screws that hold the burner head onto in orifices and place aw...
Gas line remove the 3/8” flare fitting that attaches th manifold blo of the pedestal and plac natural ga part # ngh remembe fittings all co fit bu , saf pe maint e propane hose from the ck inside re e with an approved 10’ s hose neoprene hose. Ose r to leak check all and orifices after of the conver...
Food safety tips and techniques we want to ps for basic barbecue hygiene: bac re oist foods. Marinate meat in th and take it o epared meat at room temperatu a marinade r day. If you want to use this marinade to serve with your meat please brin ma pro iona o seal in the juices. Most foods will be coo...
Trouble shooting problem possible causes solution low heat or low flame when valve turned to high. For pro propane – improper lighting cedure. Ensure lighting procedure is followed carefully. All gas grill valves must be in the off position when the tank valve is turned on. Turn tank on for all pres...
- parts list part number part description quantity 1 07-400 outer hood 1 2 04-3403 warming rack bracket 2 3 07-402 hood handle 1 4 07-4505 thermometer 1 5 07-403 inner hood 1 6 07-404 rear burner mount 1 7 07-4508 inner hood back cover 1 8 07-405 warming rack 1 9 04-34510 collector box 1 10 07-4506 ...
Exploded view 1 3 6 8 12 14 18 26 2 5 4 7 2 28 50 9 13 10 11 32 33 34 35 38 40 43 44 45 47 48 41 42 36 37 39 42 41 46 49 16 24 30 30 25 23.
Jackson grills limited lifetime warranty the follo s and workma jackson grills inc. Warrants win material g nship to be free of defects for as long as you own the grill. This covers the following ts eel outer h d, componen : main stainless st oo stainless steel cooking grills, stainless steel outer ...
A special message to our customers r choosing the jackson grill for your new gas grill. This appliance is design nts and we are confident that it will provide you with years of excellent operation. The whole manual and familiarize yourself with all of the features of the jackso contains important sa...