Jacobsen 70528 Parts & Maintenance Manual - Warning

MAINTENANCE    4

19

4.7

AIR FILTER _______________________________________________________________  

Check the service indicator daily. Replace air cleaner

element immediately when red band becomes visible 

(A)

Do not remove the element for inspection or

cleaning.

 Unnecessary removal of the filter increases

the risk of injecting dust and other impurities into the

engine.

When service is required, first clean the outside of the

filter housing; then remove the old element as gently as

possible and discard.

1. Carefully clean the inside of the filter housing without

allowing dust into the air intake.

2. Inspect the new element. Do not use a damaged

element and never use an incorrect element.

3. Assemble the new element and make sure it seats

properly. Reset the indicator by depressing button

(B)

.

4. Reassemble cap making sure it seals completely

around the filter housing. Dust evacuator 

(C)

 must

be facing down.

5. Check all hoses and air ducts. Tighten hose clamps.

Figure 4E

4.8

FUEL ____________________________________________________________________

Handle fuel with care - it is highly flammable.

 Use an

approved container, the spout must fit inside the fuel filler

neck. Avoid using cans and funnels to transfer fuel.

• Fill the fuel tank to within 1 in. (25 mm) below the filler

neck.

• Use clean, fresh, #2 Diesel fuel. Minimum Cetane

Rating 45. Refer to Engine Manual for additional

information.

• Replace fuel lines and clamps at the first sign of

damage.

• Store fuel according to local, state or federal

ordinances and recommendations from your fuel

supplier.

• Never overfill or allow the tank to become empty. 

Read Engine Owner’s Manual for additional fueling

information.

A

C

B

HR009

WARNING

Never remove the fuel cap from the fuel tank, or add

fuel, when the engine is running or while the engine is

hot.

Do not smoke when handling fuel. Never fill or drain

the fuel tank indoors.

Use4 care to avoid spilling fuel. If fuel is spilled, clean

it up immediately.

Never handle or store fuel containers near an open

flame or any device that may create sparks and ignite

the fuel or fuel vapors.

Be sure to reinstall and tighten fuel cap securely.

!