1. DL manuals
  2. Jacobsen
  3. Lawn Mower
  4. R-311T
  5. Maintenance Manual

Jacobsen R-311T Maintenance Manual

Manual is about: Rotary Mower with folding ROPS

Summary of R-311T

  • Page 1

    Parts & maintenance manual when performance matters. ™ warning if incorrectly used, this machine can cause severe injury. Those who use and maintain this machine should be trained in its proper use, warned of its dangers, and should read the entire manual before attempting to set up, operate, adjust...

  • Page 2

    This manual contains adjustment, maintenance, troubleshooting instructions, and parts list for your new jacobsen machine. This manual should be stored with the equipment for reference during operation. Before you operate your machine, you and each operator you employ should read the manual carefully...

  • Page 3

    3 table of contents 1 safety 1.1 operating safety .................................................. 4 1.2 important safety notes .........................................5 2 specifications 2.1 product identification............................................ 6 2.2 engine .............................

  • Page 4: 1    Safety

    1 safety 4 1 safety 1.1 operating safety ______________________________________________________ 1. Safety is dependent upon the awareness, concern, and prudence of those who operate or service the equipment. Never allow minors to operate any equipment. 2. It is your responsibility to read this manua...

  • Page 5: Safety    1

    Safety 1 5 1.2 important safety notes ________________________________________________ this safety alert symbol is used to alert you to potential hazards. Danger - indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Warning - indicates a potenti...

  • Page 6: 2    Specifications

    2 specifications 6 2 specifications 2.1 product identification _________________________________________________ 69171 .............................. R-311t with folding rops. Serial number ................ An identification plate, like the one shown, listing the serial number, is attached to the fr...

  • Page 7: Specifications    2

    Specifications 2 7 2.4 cutting units ___________________________________________________________ type ................................ Three fully floating decks width: front deck................. 64 in. (1625 mm) wing decks ............... 42 in. (1067 mm) cutting width: front and both wings 134 in...

  • Page 8: 2    Specifications

    2 specifications 8 2.7 declaration of conformity ____________________________________________ declaration of conformity ▪ ДЕКЛАРАЦИЯ ЗА СЪОТВЕТСТВИЕ ▪ prohlÁŠenÍ o shodĚ ▪ overensstemmelseserklÆring ▪ conformiteitsverklaring ▪ vastavusdeklaratsioon ▪ vaatimustenmukaisuusvakuutus ▪ declaration de con...

  • Page 9: Specifications    2

    Specifications 2 9 harmonised standards used ▪ Използвани хармонизирани стандарти ▪ použité harmonizované normy ▪ brugte harmoniserede standarder ▪ gebruikte geharmoniseerde standaards ▪ kasutatud ühtlustatud standardid ▪ käytetyt yhdenmukaistetut standardit ▪ normes harmonisées utilisées ▪ angewand...

  • Page 10: 3    Adjustments

    3 adjustments 10 3 adjustments 3.1 general ________________________________________________________________ 1. Adjustments and maintenance should always be performed by a qualified technician. If proper adjustment cannot be made, contact an authorized jacobsen dealer. 2. Replace, do not adjust, worn...

  • Page 11: Adjustments    3

    Adjustments 3 11 3.4 brake pedal ____________________________________________________________ adjust brakes after replacing or servicing brake assembly, or if pedal travel becomes excessive. 1. When installing new brake pads, burnish pads by driving mower at mowing speed while applying a slight pres...

  • Page 12: 3    Adjustments

    3 adjustments 12 3.6 cruise control switch _________________________________________________ if the cruise control does not disengage when brake pedal is depressed, cruise control switch must be adjusted. 1. Loosen hardware (f). 2. Adjust switch (g) so contacts are closed with the brake disengaged a...

  • Page 13: Adjustments    3

    Adjustments 3 13 3.9 neutral switch_________________________________________________________ 1. Loosen switch hardware (a). 2. With traction pedal in neutral, adjust switch (b) so pedal linkage screw (c) is centered over switch target. 3. Secure switch adjustment and test operation. 4. If adjustment...

  • Page 14: 3    Adjustments

    3 adjustments 14 3.11 steering toe in _________________________________________________________ “toe in” should be adjusted from x + 1/16 in. (1.5 mm). 1. Turn wheels to straight ahead position. 2. Loosen tie rod jam nuts (u). 3. Adjust tie rod and retighten jam nuts. 4. After adjusting “toe in” it ...

  • Page 15: Adjustments    3

    Adjustments 3 15 3.14 cutting height _________________________________________________________ level the front mower before setting the cutting height for the first time. Do not remove the cutting units from the mower to change cutting height. Cutting height for decks can be adjusted from 1 to 5-1/2...

  • Page 16: 3    Adjustments

    3 adjustments 16 3.15 leveling front mower _________________________________________________ 1. Before leveling the front deck, the mower tires, and caster wheels must be properly inflated. The cutting height is directly related to the radius of the tire. 2. Set the cutting height of the front mower...

  • Page 17: Adjustments    3

    Adjustments 3 17 3.17 servicing front deck___________________________________________________ the front deck can be raised and tilted up to improve access to the cutting unit and blades for service and cleaning. Be sure to disengage all drives, engage parking brake, stop engine and remove ignition k...

  • Page 18: 3    Adjustments

    3 adjustments 18 3.18 torque specification___________________________________________________ jacobsen uses grade 5 plated bolts as standard unless otherwise noted. For tightening plated bolts use the value given for lubricated. 3.19 specific torque __________________________________________________...

  • Page 19: Maintenance    4

    Maintenance 4 19 4 maintenance 4.1 general ________________________________________________________________ 1. Adjustment and maintenance should always be performed by a qualified technician. If proper adjustments cannot be made, contact an authorized jacobsen dealer. 2. Inspect the equipment on a r...

  • Page 20: 4    Maintenance

    4 maintenance 20 4.3 sharpening blades_____________________________________________________ 1. Place a wooden block between the blade and mower housing to stop the blade from moving. To remove blade, turn screw holding blade counterclockwise . 2. When dressing or sharpening the blade, do not follow ...

  • Page 21: Maintenance    4

    Maintenance 4 21 4.4 engine _________________________________________________________________ important: a separate engine manual, prepared by the engine manufacturer, is supplied with this mower. Read the engine manual carefully until you are familiar with the operation and maintenance of the engin...

  • Page 22: 4    Maintenance

    4 maintenance 22 4.6 air filter_______________________________________________________________ do not remove the element for inspection or cleaning. Unnecessary removal of the filter increases the risk of injecting dust and other impurities into the engine. Air cleaner servicing is required when air...

  • Page 23: Maintenance    4

    Maintenance 4 23 4.9 battery ________________________________________________________________ make absolutely certain the ignition switch is off and the key has been removed before servicing the battery. Tighten cables securely to battery terminals and apply a light coat of silicone dielectric greas...

  • Page 24: 4    Maintenance

    4 maintenance 24 4.12 hydraulic hoses _______________________________________________________ 1. Always lower implements to ground, disengage all drives, engage parking brake, stop engine, and remove key before inspecting or disconnecting hydraulic lines or hoses. 2. Check visible hoses and tubes da...

  • Page 25: Maintenance    4

    Maintenance 4 25 4.14 hydraulic oil filters ___________________________________________________ the hydraulic system is protected by two 10 micron filters. To replace hydraulic oil filter: 1. Remove the old filter. 2. Fill new filter with oil then install new filter. Hand tighten only. 3. Operate en...

  • Page 26: 4    Maintenance

    4 maintenance 26 4.18 wheel mounting procedure ____________________________________________ 1. Remove dirt, grease, and oil from stud thread. Do not lubricate threads. 2. Position wheel on hub and inspect to insure full contact between mounting surface of wheel and hub. 3. Finger tighten all hardwar...

  • Page 27: Maintenance    4

    Maintenance 4 27 4.21 radiator and oil cooler _______________________________________________ 1. Check coolant level daily. Radiator should be full and recovery bottle should be up to the cold mark. 2. Drain and refill annually. Remove the radiator cap, open the engine block drain and the radiator d...

  • Page 28: 4    Maintenance

    4 maintenance 28 4.22 storage________________________________________________________________ general 1. Wash the mower thoroughly and lubricate. Repair and paint damaged or exposed metal. 2. Inspect the mower, tighten all hardware, replace worn or damaged components. 3. Drain and refill radiator. 4...

  • Page 29: Troubleshooting    5

    Troubleshooting 5 29 5 troubleshooting 5.1 general ________________________________________________________________ the troubleshooting chart below lists basic problems that may occur during start-up and operation. For more detailed information regarding the hydraulic and electrical systems contact ...

  • Page 30: Warning

    6 maintenance & lubrication charts 30 6 maintenance & lubrication charts 6.1 general ________________________________________________________________ 1. Always clean the grease fitting before and after lubricating. 2. Lubricate with grease that meets or exceeds nlgi grade 2 lb specifications. Apply ...

  • Page 31

    Maintenance & lubrication charts 6 31 6.3 maintenance charts ___________________________________________________ a - add or adjust c - clean i - inspect l- lubricate r - replace ar - as required * indicates initial service for new machines. ** or every two years whichever comes first. *** inspect vi...

  • Page 32: 7    Parts List

    7 parts list 32 7 parts list 7.1 how to use the parts catalog _________________________________________ abbreviations n/s - not serviced seperately, can only be obtained by ordering main component or kit. Ar -variable quantity or measurement is required to obtain correct adjustment. Symbols such as ...

  • Page 33: Parts List    7

    Parts list 7 33 7.3 table of contents______________________________________________________ 1.1 ......... Decals ................................................................ 34 2.1 ......... Hood and front cowling .................................. 36 3.1 ......... Hood ............................

  • Page 34: R-311T

    34 push to latch wing arms. Pull to release this radiator contains anti-freeze protected to -26 f (-32 c) mix equal parts of clean water and a premium quality ethylene glycol based anti-freeze to maintain the boil over, rust and corrosion protection. Drain and discard coolant yearly. Read manual for...

  • Page 35: R-311T

    35 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4181864 1 decal, battery 2 4117468 1 decal, 105 db noise located on right frame rail 3 4194260 2 decal, rops deployment located on rops folding section 4 ref 1 serial plate located on right frame rail 5 4...

  • Page 36: R-311T

    36 1 2 2 3 3 4 5 5 5 5 6 6 7 7 7 7 8 10 10 10 10 10 10 11 39 39 12 13 14 15 16 16 17 17 18 19 19 20 20 21 22 22 23 23 24 24 25 25 26 26 27 28 33 / 34 38 28 29 29 9 31 32 32 29 12 9 28 29 37 30 35 36 36 r-311t 2.1 hood and front cowling serial no. All.

  • Page 37: R-311T

    37 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4266310 1 hood, r-311 see 3.1 2 4212423 2 latch, overcenter 3 ns 2 • keeper 4 400408 2 screw, 1/2-13 x 1-1/2” hex head 5 450152 8 screw, m5-0.8 x 20 mm hex head 6 403912 8 screw, #10-24 x 5/8” truss head ...

  • Page 38: R-311T

    38 r- 311t 1 2 2 3 3 4 4 5 5 6 6 7 / 8 9 10 11 12 13 ® r-311t 3.1 hood serial no. All.

  • Page 39: R-311T

    39 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4266310 1 hood assembly 2 340795 2 • handle, hood 3 402230 4 • screw, 1/4-20 x 1” slotted 4 453023 4 • flat washer, 1/4 5 446130 4 • lockwasher, 1/4 heavy 6 443102 4 • nut, 1/4-20 hex 7 4187680 1 • decal,...

  • Page 40: R-311T

    40 1 2 3 4 5 5 34 5 5 6 6 7 8 9 10 11 12 13 13 13 14 14 14 15 16 17 18 19 20 22 13 16 23 21 24 29 26 25 36 31 21 23 24 21 25 24 32 27 28 23 23 32 21 24 30 33 24 21 23 25 35 r-311t 4.1 floorboard platform serial no. All.

  • Page 41: R-311T

    41 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4185961 1 right side fender 2 4208122 1 left side fender 3 4185981 1 pad, right side step 4 4185980 1 pad, left side step 5 441614 11 carriage bolt, 5/16-18 x 1” 6 445781 7 nut, 5/16-18 whizlock flange 7 ...

  • Page 42: R-311T

    42 1 2 3 4 5 6 7 8 9 10 11 12 13 30 14 29 15 15 15 15 16 17 18 18 18 18 19 19 19 19 20 20 20 20 21 21 22 23 23 24 25 26 27 27 28 r-311t 5.1 utility box serial no. All.

  • Page 43: R-311T

    43 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4208120 1 utility box 2 4208121 1 • plate, support 3 400188 4 • screw, 5/16-18 x 1” hex head 4 453009 4 • flat washer, 5/16 5 473211 8 • washer, neoprene 6 446134 4 • lockwasher, 5/16 7 443106 4 • nut, 5/...

  • Page 44: R-311T

    44 a 1 8 9 9 10 19 20 21 7 7 8 7 8 14 16 18 12 17 15 13 13 15 14 22 23 13 15 11 10 9 8 8 7 a 2 3 4 5 5 6 6 6 21 24 25 26 r-311t 6.1 console support serial no. All.

  • Page 45: R-311T

    45 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4168044 1 support, console 2 4227180 1 console wall 3 ref 1 seat and seat base see 7.1 4 4185864 1 rod, seat pivot 5 821164 2 hair pin, 1/16 x 1-1/4 x 1/4” 6 452007 4 flat washer, 3/8 7 400264 7 screw, 3/...

  • Page 46: R-311T

    46 1 1 1 1 1 1 1 1 2 2 2 2 23 23 23 23 3 3 3 3 4 22 22 22 22 4 5 5 5 5 5 5 5 5 6 6 6 6 7 8 9 10 10 11 11 12 13 14 15 16 17 18 19 20 21 4181865 4239123 24 25 25 26 27 28 29 r-311t 7.1 seat and seat base serial no. All.

  • Page 47: R-311T

    47 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 450453 4 locknut, m8-1.25 center 2 452388 4 screw, m8-1.25 x 20 mm hex head 3 4185860 4 seat riser 4 400186 4 screw, 5/16-18 x 7/8” hex head 5 4198581 3 spacer 6 445795 4 nut, 5/16-18 spiralock flange 7 4...

  • Page 48: R-311T

    48 j-t xxxxxx -xx j-t xx xx xx- xx 10 10 10 30 30 10 x x w y y z z 9 10 8 part of 8 11 37 38 part of 11 control panel decal 12 13 15 14 w 19 part of 19 20 21 23 22 36 part of 34 34 35 33 27 25 42 43 44 40 16 17 18 18 1 7 39 6 5 31 4 2 3 29 30 28 32 26 24 41 j-t xxxxxx -x x j-t x x x x x x- x x 10 10...

  • Page 49: R-311T

    49 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4193340 1 control panel 4170760 1 • decal, control panel 2 338601 1 circuit breaker, 10 amp reference cb1, see 56.1 3 338601 1 circuit breaker, 10 amp reference cb2, see 56.1 4 338601 1 circuit breaker, 1...

  • Page 50: R-311T

    50 > change from previous revision 6 6 3 12 4 6 2 5 1 13 12 7 7 7 8 9 10 11 r-311t 9.1 lift valve serial no. All item part no. Qty. Description serial numbers/notes 1 1001802 1 lift valve see 48.1 2 366150 1 weather strip 3 132473 1 right wing lift lever 4 132472 1 center lift lever 5 132471 1 left ...

  • Page 51: R-311T

    51 > change from previous revision 11 9 8 7 7 12 1 2 4 5 13 10 3 6 r-311t item part no. Qty. Description serial numbers/notes 1 4172944 1 throttle handle 2 326731 1 knob, throttle 3 4177920 1 cable, throttle see 22.1 for engine connection 4 445800 1 palnut, 3/16 5 440116 1 carriage bolt, 3/8-16 x 7/...

  • Page 52: R-311T

    52 1 2 3 4 5 6 7 8 9 10 11 11 12 13 14 25 15 16 17 18 19 20 24 21 22 23 23 23 22 23 26 27 28 29 30 r-311t 11.1 traction pedal linkage serial no. All.

  • Page 53: R-311T

    53 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4116048 1 pedal, hydro 2 3007230 1 stop, mow speed 3 3003474 1 grip, reverse pedal 4 3003475 1 grip, forward pedal 5 400188 1 screw, 5/16-18 x 1” hex head 6 3002695 1 flat washer, 5/16 7 444718 1 locknut,...

  • Page 54: R-311T

    54 12 15 14 10 20 11 38 37 8 40 30 2 4 6 1 36 7 5 31 32 31 32 8 19 8 13 13 34 16 15 5 8 27 12 9 12 21 23 20 24 21 26 39 12 12 22 35 8 3 18 19 17 25 28 29 19 19 7 9 8 13 33 r-311t 12.1 traction linkage serial no. All.

  • Page 55: R-311T

    55 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 2500257 1 tube, traction return 2 3007095 1 stop, rear pivot 3 3000593 1 spacer, traction control 4 358795 1 screw, 3/8-24 x 5-1/2” special 5 358794 4 washer 6 364970 1 spring, compression 7 443812 4 nut,...

  • Page 56: R-311T

    56 1 2 2 3 4 4 5 5 6 7 8 8 9 10 11 12 26 26 39 13 14 33 15 16 16 17 17 18 18 19 20 36 21 22 22 23 23 24 32 32 24 25 25 25 39 34 26 26 26 26 27 38 37 27 28 29 29 29 30 31 31 35 r-311t 13.1 brake pedal serial no. All.

  • Page 57: R-311T

    57 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4183261 1 brake pedal 2 352726 2 • bushing 3 3006327 1 shaft, brake pedal 4 4100460 2 arm, brake 5 403770 2 screw, 5/16-18 x 3/4” hex flange 6 4251410 1 lever, parking brake 7 400190 1 screw, 5/16-18 x 1-...

  • Page 58: R-311T

    58 4 4 4 4 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 5 12 12 12 12 12 8 9 10 10 11 11 11 11 11 11 11 11 11 12 12 13 14 15 22 23 24 25 26 27 28 28 1 2 3 3 5 5 6 6 7 7 16 16 17 18 19 20 21 r-311t 14.1 brake caliper serial no. All.

  • Page 59: R-311T

    59 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 446142 2 lockwasher, 3/8 heavy 2 443110 2 nut, 3/8-16 hex 3 4215701 2 plate, caliper mounting 4 400411 4 screw, 1/2-13 x 1-3/4” hex head grade 8 5 4212780 28 hardened washer, 1/2” 6 446154 4 lockwasher, 1...

  • Page 60: R-311T

    60 1 2 2 3 3 4 4 5 5 6 6 7 7 37 37 12 12 14 14 15 15 17 17 16 9 / 10 11 13 17 18 19 19 29 20 21 21 22 22 22 22 22 22 22 22 22 23 23 23 23 23 24 24 24 24 24 25 8 38 8 38 25 26 26 27 28 28 32 33 34 35 36 31 22 23 24 30 r-311t 15.1 frame and front axle serial no. All.

  • Page 61: R-311T

    61 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4223140 1 front axle 2 4207700 2 key 3 4213320 2 hub, wheel 4 4212741 2 disc, brake 5 442423 16 screw, 1/4-20 x 5/8” torx flat head 6 557624 2 nut 7 460093 2 cotter pin, 1/8 x 2-1/2” 8 453030 2 flat washe...

  • Page 62: R-311T

    62 b c a b c a 1 2 2 3 3 3 3 4 4 5 5 6 6 6 7 7 7 7 7 8 8 9 9 10 10 11 12 13 13 14 14 15 15 15 15 15 15 16 17 18 19 19 20 20 21 21 22 22 23 23 24 24 25 25 26 26 27 27 28 28 29 29 30 30 30 30 31 32 32 33 33 34 34 34 34 34 34 35 36 36 37 37 38 38 39 40 41 r-311t 16.1 steering axle serial no. All.

  • Page 63: R-311T

    63 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 2720313 1 steering axle 2 2720298 2 • bushing, axle pivot 3 3010489 4 • bushing, mount pivot 4 4121827 2 screw, 1/2-20 x 1-3/4” socket head 5 443820 2 nut, 1/2-20 hex jam 6 471221 3 grease fitting, 90° 7 ...

  • Page 64: R-311T

    64 a a 1 2 2 3 43 3 4 4 5 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 23 24 25 26 27 27 28 28 29 30 31 32 33 34 35 36 37 38 39 40 40 41 42 ® 4192000 r-311t 17.1 steering tower serial no. 69171 - 1651 ~ 2197.

  • Page 65: R-311T

    65 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4185325 1 steering tower 2 4211760 1 bracket, steering pump 3 4205980 2 shoulder bolt, 3/4-10 4 400258 2 screw, 3/8-16 x 3/4” hex head 5 446142 2 lockwasher, 3/8-16 heavy 6 444849 2 locknut, 3/4-10 center...

  • Page 66: R-311T

    66 a a 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 18 19 20 20 21 21 22 22 23 23 24 25 25 25 25 26 27 28 29 31 31 32 30 4192000 ® 33 34 35 36 37 38 r-311t 17.2 steering tower serial no. 69171 - 2198 and up.

  • Page 67: R-311T

    67 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4253510 1 steering tower 2 4256510 1 bracket, steering pump 3 4197880 1 steering valve 4197940 1 • seal kit 4 4224460 4 screw, m8-1.25 x 125 mm hex head 5 450411 4 lockwasher, m8 6 4211400 4 spacer, steer...

  • Page 68: R-311T

    68 5 5 6 6 12 12 13 13 13 14 14 16 18 19 19 20 20 21 22 23 24 24 27 28 29 35 4 17 15 41 25 25 26 26 34 34 32 32 4199140 4205183 1 2 3 7 7 8 9 10 30 31 33 37 36 38 39 39 40 11 r-311t 18.1 air cleaner serial no. All.

  • Page 69: R-311T

    69 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4227441 1 air cleaner includes decal 4133818 1 • cover, air cleaner 4133820 1 • filter, primary air cleaner 4133821 1 • filter, safety air cleaner 5003373 1 • vactuator valve 2 4128084 1 clamp, air cleane...

  • Page 70: R-311T

    70 8 8 6 7 2 2 1 20 27 26 9 9 27 25 27 24 23 28 29 30 31 32 33 21 18 19 13 22 22 14 15 16 16 17 this radiator contains anti-freeze protected to -26 f (-32 c) mix equal parts of clean water and a premium quality ethylene glycol based anti-freeze to maintain the boil over, rust and corrosion protectio...

  • Page 71: R-311T

    71 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4227440 1 radiator shroud 2 4164381 1 • decal, danger 3 400264 6 screw, 3/8-16 x 1-1/4” hex head 4 452006 18 flat washer, 5/16 5 446142 12 lockwasher, 3/8 heavy 6 4227420 1 radiator and hydraulic oil cool...

  • Page 72: R-311T

    72 2 3 5 6 7 7 29 28 8 9 10 12 11 13 14 14 16 18 19 20 21 4 17 15 1 22 23 24 25 26 27 r-311t 20.1 engine serial no. All.

  • Page 73: R-311T

    73 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4196741 1 engine, kubota v2403-m-t-e3b for complete listing of engine service parts, see engine parts manual 4113986 1 • engine oil filter 557619 1 • cartridge, fuel filter 5000938 1 • alternator referenc...

  • Page 74: R-311T

    74 20 20 3 5 5 5 5 6 6 6 14 14 6 7 7 2 2 8 9 10 12 12 11 11 13 13 16 16 18 18 4 17 19 15 15 1 1 r-311t 21.1 engine mounts serial no. All.

  • Page 75: R-311T

    75 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4207484 2 mount, rear engine 2 358794 4 washer 3 4207482 1 mount, left front engine 4 4207483 1 mount, right front engine 5 365979 7 screw, m12-1.25 x 25 mm metric grade 8.8 6 446154 7 lockwasher, 1/2 hea...

  • Page 76: R-311T

    76 > change from previous revision 1 2 3 4 r-311t 22.1 engine fuel control serial no. All item part no. Qty. Description serial numbers/notes 1 4177920 1 throttle cable see 10.1 2 400108 1 screw, 1/4-20 x 3/4” hex head 3 453023 1 flat washer, 1/4 4 444708 1 locknut, 1/4-20 center.

  • Page 77: R-311T

    77 > change from previous revision 7 9 5 12 12 12 14 15 16 6 7 9 7 1 10 8 11 7 4 13 3 2 r-311t item part no. Qty. Description serial numbers/notes 1 4196900 1 muffler 2 4263130 1 exhaust pipe 3 553020 1 gasket, exhaust included with engine 4 363586 4 screw, m8-1.25 x 20 mm hex head 5 1000050 2 muffl...

  • Page 78: R-311T

    78 im p o rt an t d ie se l f ue l o nl y 21 17 4 3 20 18 19 10 5 5 14 26 27 6 11 7 16 16 21 12 21 2 1 22 21 21 23 21 28 5 21 5 9 8 13 part of hood to engine return to engine 25 24 21 15 21 25 r-311t 24.1 fuel tank serial no. All.

  • Page 79: R-311T

    79 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 163987 1 fuel cap 2 163986 1 fuel sender reference u8, see 56.1 3 148081 1 • gasket 4 403910 5 screw, #10-24 x 1/2” truss head 5 361117 4 bushing, fuel 6 452006 2 flat washer, 5/16 7 400188 2 screw, 5/16-...

  • Page 80: R-311T

    80 17 5 19 20 21 24 18 14 1 13 15 29 14 16 1 11 13 14 13 12 27 25 30 22 23 26 20 28 2 6 5 7 7 5 5 8 8 8 9 8 3 10 6 5 10 31 9 9 5 5 6 6 4 r-311t 25.1 hydraulic tank support serial no. All.

  • Page 81: R-311T

    81 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4175121 2 support, rear tank 2 132432 1 support, left side tank 3 132431 1 support, right side tank 4 400286 2 screw, 3/8-16 x 2-3/4” 5 446142 12 lockwasher, 3/8 heavy 6 445806 6 nut, 3/8-16 hex nylock 7 ...

  • Page 82: R-311T

    82 11 12 10 5 6 7 8 9 1 2 3 18 4 15 10 16 13 14 17 r-311t 26.1 hydraulic tank serial no. All.

  • Page 83: R-311T

    83 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4227460 1 hydraulic oil tank includes decals 2 4211081 1 valve, oil drain 3 3002397 1 plug, magnetic 4 367551 1 switch, hydraulic oil temperature reference sw13, see 56.1 ★ 5 163915 1 breather, tank impor...

  • Page 84: R-311T

    84 33 17 15 24 8 37 6 14 29 32 14 15 16 28 15 19 18 19 39 18 16 36 5 14 15 35 31 14 30 9 18 19 7 8 11 10 4 14 13 21 12 20 17 34 3 2 1 17 24 8 16 15 14 25 22 23 38 23 27 24 8 26 4wd d l t p ld st s d a l1 l2 ad bd p t p t p t r-311t 27.1 pumps and control valve serial no. 69151 - 1651 ~ 2060

  • Page 85: R-311T

    85 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4153880 1 pump, traction see 51.1 2 557447 1 • o-ring 3 338938 1 • pump coupler 4 4138342 1 pump, 4 section gear 4138341 1 • seal kit 5 557417 1 • pump adapter 6 557418 1 • gasket 7 400412 2 screw, 1/2-13...

  • Page 86: R-311T

    86 33 17 15 24 8 37 6 14 29 32 14 15 16 28 15 19 18 19 39 18 16 36 5 14 15 35 31 14 30 9 18 19 7 8 11 10 4 14 13 21 12 20 17 34 3 2 1 17 24 8 16 15 14 25 22 23 38 23 27 24 8 26 4wd d l t p ld st s d a l1 l2 ad bd p t p t p t r-311t 27.2 pumps and control valve serial no. 69171 - 2061 and up.

  • Page 87: R-311T

    87 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4153880 1 pump, traction see 51.1 2 557447 1 • o-ring 3 338938 1 • pump coupler 4 4260990 1 pump, 4 section gear 4138341 1 • seal kit 5 4260890 1 flange, adapter 6 557447 1 o-ring 7 400412 2 screw, 1/2-13...

  • Page 88: R-311T

    88 1 2 2 3 3 4 4 5 6 7 8 9 10 11 11 12 12 13 13 14 14 14 14 14 14 14 15 16 17 18 19 19 20 a l1 l2 ad bd r-311t 28.1 traction hydraulics serial no. All.

  • Page 89: R-311T

    89 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4153880 1 traction pump see 27.1 or 27.2 2 340269 2 tee, 10-12-12 straight run 339911 1 • o-ring, -10 orfs 339912 1 • o-ring, -12 orfs 339900 1 • o-ring, -12 orb 3 132417 2 hose, traction pump to axle mot...

  • Page 90: R-311T

    90 1 2 3 4 5 6 7 7 8 8 9 10 11 11 11 12 13 14 15 16 17 18 18 18 18 19 19 19 20 20 20 21 21 22 22 22 22 23 24 25 26 27 28 29 r-311t 29.1 motor drain hydraulics serial no. All.

  • Page 91: R-311T

    91 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4170780 1 front axle motor see 27.1 or 27.2 2 351109 1 fitting, -6 37° flare x -6 orb straight 339897 1 • o-ring, -6 orb 3 4173220 1 hose, axle motor to traction pump 4 4173200 1 tee, -6 37° flare x -8 or...

  • Page 92: R-311T

    92 1 2 3 4 4 4 4 4 4 5 6 7 7 8 9 9 10 11 11 11 11 12 13 13 13 14 15 16 17 17 18 19 19 19 19 20 20 20 20 21 21 21 21 21 21 22 22 23 4wd d l t p ld st s d p t p t p t a l1 l2 ad bd r-311t 30.1 gear pump hydraulics serial no. All.

  • Page 93: R-311T

    93 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4227460 1 hydraulic oil tank see 26.1 2 365959 1 strainer, 100 mesh screen 2812075 1 • o-ring 3 338946 1 fitting, -24 orb x 1-1/2” hose 90° 339903 1 • o-ring 4 326112 6 clamp, hose 5 4148898 1 hose, pump ...

  • Page 94: R-311T

    94 4wd d l t p ld st s d p t p t p t 1 1 1 2 3 4 5 6 6 7 8 9 10 11 12 13 14 14 15 16 17 18 19 20 21 22 23 r-311t 31.1 return hydraulics serial no. All.

  • Page 95: R-311T

    95 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4135582 3 valve, deck control see 27.1 or 27.2 2 340070 1 fitting, -10 orfs x -10 orb 90° 339911 1 • o-ring, -10 orfs 339899 1 • o-ring, -10 orb 3 4192440 1 hose, front to left wing deck valve 4 2720559 1...

  • Page 96: R-311T

    96 4wd d l t p ld st s d 1 2 2 3 4 5 6 6 7 7 8 9 10 11 12 12 13 13 14 15 16 17 18 19 20 21 22 to control valve (hose item 3) to charge filter (hose item 11) to steering cylinder (hose item 5) to steering cylinder (hose item 6) r l p t r-311t 32.1 steering and charge hydraulics serial no. All.

  • Page 97: R-311T

    97 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4174300 1 valve, main control see 27.1 or 27.2 2 339984 2 fitting, -8 orfs x -8 orb straight 339910 1 • o-ring, -8 orfs 339898 1 • o-ring, -8 orb 3 4185401 1 hose, control valve to steering steering valve...

  • Page 98: R-311T

    98 4wd d l t p ld st s d 1 2 2 3 4 5 6 7 7 8 8 9 9 10 11 12 12 13 14 15 15 16 16 17 17 17 18 19 19 20 21 22 23 24 24 25 part of frame 25 26 27 28 29 29 30 30 31 32 33 r-311t 33.1 lift hydraulics serial no. All.

  • Page 99: R-311T

    99 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4174300 1 valve, main control see 27.1 or 27.2 2 340066 2 fitting, -8 orfs x -8 orb 90° 339910 1 • o-ring, -8 orfs 339898 1 • o-ring, -8 orb 3 123222 1 tube, control valve to lift valve lift valve port in...

  • Page 100: R-311T

    100 4wd d l t p ld st s d 1 2 2 3 4 5 6 7 7 8 8 9 9 10 11 12 12 13 14 15 15 16 16 17 17 17 18 19 19 20 21 22 23 24 24 25 part of frame 25 26 27 28 29 29 30 30 31 32 33 r-311t 33.1 lift hydraulics (continued).

  • Page 101: R-311T

    101 > change from previous revision r-311t 25 339961 2 nut, 11/16-16 bulkhead hex 26 4193300 1 hose, tee to tee 27 366437 1 bracket, bulkhead see 39.1 28 132583 1 hose, tee to tank 29 351127 2 fitting, -8 37° flare x 3/8 npt straight 30 4188043 1 hose, lift to backpressure valve 31 351108 1 fitting,...

  • Page 102: R-311T

    102 p t p t p t 1 2 2 2 3 3 3 4 4 4 5 6 6 6 6 6 6 6 7 7 7 8 8 8 8 8 8 8 8 8 8 9 9 10 10 10 10 11 12 13 14 15 16 17 18 18 r-311t 34.1 deck hydraulics serial no. All.

  • Page 103: R-311T

    103 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4135582 1 valve, front deck control see 27.1 or 27.2 2 4202340 3 adapter, 10-8 reducer union 339899 1 • o-ring, -10 orb 339898 1 • o-ring, -8 orb 3 4202120 3 check valve 4201921 1 • body, check valve 420...

  • Page 104: R-311T

    104 front axle motor hoses 10 12 14 15 13 10 18 20 21 steering cylinder hoses 19 13 13 10 17 4 16 5 5 6 7 7 part of floorboard 8 9 11 4 1 2 3 5 r-311t 35.1 hydraulic clamping serial no. All.

  • Page 105: R-311T

    105 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 366607 2 spacer, hose 2 359860 2 clamp, 2 hose 3 400204 2 screw, 5/16-18 x 3-1/2” 4 446136 2 lockwasher, 5/16 heavy 5 443106 4 nut, 5/16-18 hex 6 3008793 2 clamp, hose front deck motor hoses 7 3008792 2 ...

  • Page 106: R-311T

    106 k2 k7 k3 k6 k5 k9 k8 k21 k20 k18 k19 k17 9 9 5 5 6 6 part of right wing limit switch harness part of console harness 8 13 14 17 7 12 2 20 20 20 20 20 14 14 4 4 4 4 16 28 11 10 10 13 part of left wing limit switch harness relay identification 1 18 18 to starter post glow plug solenoid wiring to g...

  • Page 107: R-311T

    107 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4210661 1 wire, solenoid to glow plug 2 4210660 1 wire, circuit breaker to solenoid 3 4210662 2 wire, starter to circuit breaker 4 443102 6 nut, 1/4-20 hex 5 4193880 6 relay spdt reference k5, k17, k18, ...

  • Page 108: R-311T

    108 9 7 5 6 15 12 12 11 8 12 14 10 2 14 14 14 13 14 1 4 3 engine harness 16 tractor harness r-311t 37.1 electrical routing serial no. All.

  • Page 109: R-311T

    109 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4167640 3 cable tie, fir tree 2 4211620 1 positive remote terminal cable remote terminal to starter. See 4.1 for terminal 3 365980 1 screw, m12-1.25 x 20 mm 4 446154 1 lockwasher, 1/2 heavy 5 446130 1 lo...

  • Page 110: R-311T

    110 circuit break ers hour meter v olt meter fuel gauge t achometer switches rela ys cab connector p anel lights hor n/t est switch diodes ignition switch t emper ature gauge glo w plug switch hor n ground ground fuel sender p a rking br ak e seat switch control v alv e re v erse switch headlights b...

  • Page 111: R-311T

    111 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4218120 1 wire harness, console 554492 2 • lockwasher, size 24 554493 2 • panel nut, size 24 555845 10 • light bulb 555846 10 • diode 555847 1 • light strip 2 4211640 1 wire harness, engine 3 4201161 1 w...

  • Page 112: R-311T

    112 26 1 3 13 12 13 14 14 23 24 16 17 18 11 4 14 19 27 2 10 2 14 22 21 5 5 9 25 4 6 7 8 8 7 6 30 31 15 20 28 29 7 32 r-311t 39.1 front lift arms serial no. All.

  • Page 113: R-311T

    113 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 2720206 1 right front lift arm 2 342033 2 • bushing 3 2720207 1 left front lift arm 4 342033 2 • bushing 5 4184641 2 shaft, lift arm pivot 6 346091 4 pin, retaining 7 446136 5 lockwasher, 5/16 heavy 8 40...

  • Page 114: R-311T

    114 23 7 24 31 9 2 / 4 29 9 32 14 11 28 27 27 2 / 4 38 10 14 13 12 5 1 / 3 16 6 30 37 18 15 17 33 34 16 19 20 20 35 21 36 27 22 31 7 8 25 26 8 7 r-311t 40.1 wing lift arms right wing shown serial no. All.

  • Page 115: R-311T

    115 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4222365 1 right wing arm 2 2720298 2 • bushing 3 4222366 1 left wing arm (not shown) 4 2720298 2 • bushing 5 2248004 2 shaft, pivot arm 6 64251-001 4 flat washer, m5 7 446136 5 lockwasher, 5/16 heavy 8 4...

  • Page 116: R-311T

    116 10 3 5 27 13 33 5 4 3 4 15 18 / 19 32 8 9 7 11 14 16 17 22 20 21 2 1 29 30 23 28 24 12 25 31 4 26 5 5 3 4 3 6 6 23 13 33 32 r-311t 41.1 wing deck latch serial no. All.

  • Page 117: R-311T

    117 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 446136 2 lockwasher, 5/16 heavy 2 443106 2 nut, 5/16-18 hex 3 453011 12 flat washer, 3/8 4 446142 12 lockwasher, 3/8 heavy 5 445806 14 nut, 3/8-16 hex 6 400272 4 screw, 3/8-16 x 2-1/4” hex head 7 132601 ...

  • Page 118: R-311T

    118 25 23 1 16 17 21 11 19 12 13 10 18 4 24 20 3 5 6 2 1 21 7 15 8 9 14 8 22 r-311t 42.1 deck mounting serial no. All.

  • Page 119: R-311T

    119 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 64173-02 6 pin, snap ring 2 3000439 2 clevis pin, 1/2 x 3-3/4” 3 3000487 1 clevis pin, 5/8 x 3” 4 346913 2 spacer 5 460050 2 cotter pin, 3/16 x 1-1/4” 6 3006300 1 clevis pin, 5/8 x 3-5/16” 7 362464 12 wh...

  • Page 120: No Step

    120 no step 1.0 2.0 3.0 4.0 5.0 1.0 3.0 5.0 1.5 2.5 3.5 4.5 2.5 4.5 5.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 a b "x" "x" 0 1 2 3 4 0 1 2 3 4 a a a a a b b b b b 3 2 4 4 38 13 13 13 39 39 39 13 39 40 36 2 16 15 17 5 5 / 7 2 16 4 2 15 3 8 8 / 10 33 15 16 34 36 37 38 35 41 42 14 13 12 9 16 15 11 10 ...

  • Page 121: R-311T

    121 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4212580 1 front deck 2 4164381 3 • decal, blade contact danger 3 3002676 1 • decal, cutting height 4 366609 2 • decal, no step 5 2721180 2 motor, deck counter-clockwise rotation 6 557523 1 • key 7 418658...

  • Page 122: R-311T

    122 1.0 2.0 3.0 4.0 5.0 1.0 3.0 5.0 1.5 2.5 3.5 4.5 2.5 4.5 5.5 1.0 1.5 2.0 2.5 3.0 3.5 4.0 4.5 5.0 5.5 a b "x" "x" 0 1 2 3 4 0 1 2 3 4 a a a a a b b b b b 4 3 9 27 26 4 16 15 11 10 14 13 12 6 7 24 15 16 16 15 11 1 / 2 33 34 17 25 13 12 23 18 3 14 19 20 22 21 40 15 17 41 38 13 39 40 37 31 32 left wi...

  • Page 123: R-311T

    123 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4212600 1 left wing deck includes items 3 and 4 2 4212601 1 right wing deck (not shown) 3 4164381 2 • decal, blade contact danger 4 3002676 1 • decal, cutting height 5 2721180 2 motor, ccw rotation deck ...

  • Page 124: R-311T

    124 9 1 2 / 17 4 5 8 9 6 7 8 7 6 3 5 11 12 2 / 17 2 / 17 12 11 11 10 12 2 / 17 12 11 3 4 16 14 15 13 15 15 r-311t 45.1 caster wheels serial no. All.

  • Page 125: R-311T

    125 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 131717 8 yoke, caster wheel spindle 2 453022 ar flat washer, 3/4 x 1/8 thick 3 3003207 10 shaft, caster wheel 4 460056 10 cotter pin, 3/16 x 2” 5 403578 10 screw, #10-24 x 1” hex head 6 446118 10 lockwas...

  • Page 126: R-311T

    126 > change from previous revision 5 4 6 4 5 3 5 6 2 1 4 r-311t 46.1 deck bumper serial no. All item part no. Qty. Description serial numbers/notes 1 3003427 1 bracket, deck bumper 2 400262 2 screw, 3/8-16 x 1” hex head 3 453011 2 flat washer, 3/8 4 446142 4 lockwasher, 3/8 heavy 5 445806 4 nut, 3/...

  • Page 127: R-311T

    127 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 5002911 1 relief valve 5003579 1 • seal kit 2 5002912 1 relief valve 5003554 1 • seal kit 3 3010199 1 plug, sae #6 339897 1 • o-ring 4 5002913 1 solenoid valve 5003579 1 • seal kit 5 4134530 1 coil, 12 v...

  • Page 128: R-311T

    128 21 17 26 18 19 14 20 8 9 11 12 22 13 14 7 5 4 3 2 10 16 15 23 24 25 1 6 7 r-311t 48.1 lift valve part number 1001802 serial no. All.

  • Page 129: R-311T

    129 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 558005 1 plug 2 500745 3 plug 3 4113978 3 spring ● 4 n/s 3 poppet 5 500746 3 seat 6 5001599 1 plunger 7 5001603 2 plunger 8 558004 3 cap 9 558007 3 retaining ring 10 n/s 1 seat 11 558011 3 spacer 12 5001...

  • Page 130: R-311T

    130 > change from previous revision p ld st f cd sw l sd dl 4wd t viewed from top viewed from rear viewed from right viewed from front viewed from left 5 4 6 1 2 3 7 r-311t 49.1 control valve part number 4174300 serial no. All item part no. Qty. Description serial numbers/notes 1 5003510 1 relief va...

  • Page 131: R-311T

    131 > change from previous revision l1 l2 r1 r2 4wd a b c ad bd viewed from right viewed from left viewed from top viewed from bottom 3, 5 2 4 1 r-311t item part no. Qty. Description serial numbers/notes 1 556897 1 spool valve 5003581 1 • seal kit 2 558038 1 check valve 5003581 1 • seal kit 3 556847...

  • Page 132: R-311T

    132 2 0 - x x r - 0 6 3 0 7 b j 1 3 1 0 8 9 a 1 2 3 3 4 4 5 5 6 7 8 9 10 10 11 12 13 13 14 14 15 16 16 17 18 19 20 21 21 22 23 24 25 26 28 29 30 31 32 32 34 35 36 r-311t 51.1 traction pump part number 4153880 serial no. All.

  • Page 133: R-311T

    133 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 557454 2 dowel pin ● 2 n/s 1 retaining ring ● 3 n/s 2 retaining ring 4 4162501 6 screw, cap 5 557444 2 plug 6 557442 1 rotating kit 7 4162502 1 plate, control arm cover 8 4162503 1 • seal, control arm sh...

  • Page 134: R-311T

    134 > change from previous revision 4 3 2 2 10 11 2 5 9 6 1 7 8 r-311t 52.1 rear wheel motor part number 4178560 serial no. All serial no. All item part no. Qty. Description serial numbers/notes ● 1 n/s 1 seal exclusion ● 2 n/s 4 seal, 3” i.D. ▼ 3 n/s 1 back-up ring ▼ 4 n/s 1 shaft seal 5 5003384 1 ...

  • Page 135: R-311T

    135 > change from previous revision 1 2 3 4 5 5 6 6 7 7 7 7 8 8 8 8 9 9 10 10 11 11 12 12 13 13 13 13 14 14 15 15 15 15 15 15 16 16 16 16 16 16 17 17 17 17 17 17 r-311t item part no. Qty. Description serial numbers/notes 1 4179004 1 rops 2 n/s 1 • upper rops 3 n/s 1 • right lower rops 4 n/s 1 • left...

  • Page 136: R-311T

    136 1 2 3 4 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 r-311t 54.1 seat part number 4185878 serial no. All.

  • Page 137: R-311T

    137 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4200240 1 backrest cushion 2 4200241 1 seat cushion 3 4173562 1 lumbar handle kit 4 4173563 1 wear parts kit, backrest attatchment 5 4200244 1 cover, left side 6 4200245 1 cover, right side 7 4173566 1 o...

  • Page 138: R-311T

    138 1 2 3 4 4 4 4 4 5 6 7 8 9 10 11 12 13 14 15 16 17 17 18 18 19 19 20 21 22 23 24 24 25 25 26 26 27 27 28 28 29 29 30 30 31 32 33 31 r-311t 55.1 front axle part number 4223140 serial no. All item shim thickness 0.010 0.011 0.012 0.013 0.014 0.015 0.016 0.017 0.018 10 4213621-1 4213621-2 4213621-3 ...

  • Page 139: R-311T

    139 > change from previous revision r-311t item part no. Qty. Description serial numbers/notes 1 4201300 1 case assembly, differential (t/l) 2 4201320 1 gear and pinion assembly, hypoid 3 4201520 10 screw, gear drive 4 4220820 1 carrier sub assembly includes bearing caps and screws 5 4201580-1 ar sh...

  • Page 140: R-311T

    140 m1 b1 u11 b s cb7 cb6 cb4 cb3 cb1 cb8 cb2 cb5 30 85 86 87 k4 sw4 k3 k2 bk bk bk gn/wh gn/wh og/bk bk bk rd/bn rd/wh rd/wh bn ye wh wh/bn pu/ye pu/wh tn tn gn/wh gn/wh gn/wh gn/wh gn/wh pk/bu pk/bu pu/ye rd rd pk/bu pk/bu og/bu rd rd wh/rd rd wh/rd rd rd rd rd rd rd rd rd rd rd rd bn bn rd/wh rd/...

  • Page 141: R-311T

    141 30 85 86 87 87a pu/wh gn/wh gn gn/wh bn/rd bn/rd bn/rd pk/bu pk/bu ye ye sw5 sw18 b i x y s a off - none on - b+i+a; x+y start - b+i+s sw1 bk tn/rd og/bu og/bu og/bu tn/rd ye wh wh gy gy tn/rd l11 bk bk bk bk lb lg l10 l12 l13 og og og og og og og og og og og og og og l3 l4 l1 l5 l6 l7 l8 l9 1-l...

  • Page 142: R-311T

    142 r-311t item reference illustration part number description serial numbers/notes b1 see 4.1 n/s battery cb1 see 8.1 338601 10 amp circuit breaker (interlock) cb2 see 8.1 338601 10 amp circuit breaker (instruments) cb3 see 8.1 338601 10 amp circuit breaker (cruise, 4wd) cb4 see 8.1 338558 30 amp c...

  • Page 143: R-311T

    143 r-311t l8 not shown 555845 water temp warning light l9 not shown 555845 low engine oil pressure warning light l10 not shown 555845 left turn light l11 optional tail light l12 optional head light included in kit 69128 l13 optional head light included in kit 69128 m1 see 20.1 556988 starter motor ...

  • Page 144: R-311T

    144 m1 b1 u11 b s cb7 cb6 cb4 cb3 cb1 cb8 cb2 cb5 30 85 86 87 k4 sw4 k3 k2 bk bk bk gn/wh gn/wh og/bk bk bk rd/bn rd/wh rd/wh bn ye wh wh/bn pu/ye pu/wh tn tn gn/wh gn/wh gn/wh gn/wh gn/wh pk/bu pk/bu pu/ye rd rd pk/bu pk/bu og/bu rd rd wh/rd rd wh/rd rd rd rd rd rd rd rd rd rd rd rd bn bn rd/wh rd/...

  • Page 145: R-311T

    145 30 85 86 87 87a pu/wh gn/wh gn gn/wh bn/rd bn/rd bn/rd pk/bu pk/bu ye ye sw5 sw18 b i x y s a off - none on - b+i+a; x+y start - b+i+s sw1 bk tn/rd og/bu og/bu og/bu tn/rd ye wh wh gy gy tn/rd l11 bk bk bk bk lb lg l10 l12 l13 og og og og og og og og og og og og og og l3 l4 l1 l5 l6 l7 l8 l9 1-l...

  • Page 146: R-311T

    146 r-311t item reference illustration part number description serial numbers/notes b1 see 4.1 n/s battery cb1 see 8.1 338601 10 amp circuit breaker (interlock) cb2 see 8.1 338601 10 amp circuit breaker (instruments) cb3 see 8.1 338601 10 amp circuit breaker (cruise, 4wd) cb4 see 8.1 338558 30 amp c...

  • Page 147: R-311T

    147 r-311t l7 not shown 555845 low charge pressure warning light l8 not shown 555845 water temp warning light l9 not shown 555845 low engine oil pressure warning light l10 not shown 555845 left turn light l11 optional tail light l12 optional head light included in kit 69128 l13 optional head light i...

  • Page 148: R-311T

    148 3500 psi 3500 psi 1.04 1.04 1.04 0.77 in 3 2.48 in 3 in 3 in 3 in 3 630 psi 3000 psi b t a p d 630 psi 3000 psi b t a p d d 630 psi 3000 psi b t a p d .0669 1.04 in 3 .0669 1.04 in 3 .0669 1.04 in 3 .0669 1.04 in 3 .0669 1.04 in 3 .0669 1.04 in 3 .0669 1.04 in 3 5.04 in 3 25 psi switch 25 psi cr...

  • Page 149: R-311T

    149 c a ad ab b l2 r2 4wd l1 r1 11.9 in 3 11.9 in 3 200 psi sd st ld p l 4wd dl sw cd f t 1500 psi 6.1 in 3 p t l r in out a b c d e f 1500 psi 300 psi 300 psi 300 psi 50 psi 4wd valve control valve steering valve steering cylinder lift valve backpressure valve right wing cylinder front right cylind...

  • Page 150: R-311T

    150 x w w w x w x w w-x o-ring face seal size o-ring boss dash size w-x o-ring face seal size o-ring boss dash size w-x o-ring face seal size w-x o-ring face seal size o-ring face seal size w-x o-ring face seal size o-ring face seal size o-ring face seal size w-x o-ring face seal size o-ring face se...

  • Page 151: R-311T

    151 > change from previous revision r-311t adapter part number. Dash size adapter type (w) o-ring (x) o-ring (y) o-ring (z) o-ring 339979 6-6 straight adapter 339909 339897 339983 8-6 straight adapter 339910 339897 339984 8-8 straight adapter 339910 339898 339989 10-10 straight adapter 339911 339899...

  • Page 152: Fluids and Compounds

    Fluids and compounds * refer to the parts & maintenance manual for the correct hydraulic oil requirements for your machine. Jacobsen offers a high usage parts catalog illustrating commonly used parts through easy to read line drawings. See your local jacobsen dealer for a copy. Hydraulic fluid* 5001...

  • Page 153: Index

    153 index 1000050...................... 77 1000588...................... 49 1000649................ 53 , 57 1000700................ 89 , 91 1001311...................... 79 1001802................ 50 , 99 1001885............ 121 , 123 1001963.................... 111 1002475................ 85 , 87 1...

  • Page 154: Index

    154 index 345671 ..............107 , 109 346091 ..............113 , 115 346294 ......................119 346913 ......................119 350685 ........................81 351108 ......................101 351109 ........................91 351122 ......................129 351124 ........................

  • Page 155: Index

    155 index 4133821...................... 69 4134270...................... 73 4134320...................... 73 4134383...................... 73 4134530.................... 127 4134532............ 130 , 131 4134825...................... 59 4135555... 85 , 87 , 89 , 93 , 97 4135582... 85 , 87 , 93 , 95 ...

  • Page 156: Index

    156 index 4203610.....................139 4203611.....................139 4203612.....................139 4203613.....................139 4203614.....................139 4203615.....................139 4204160.......................61 4204220.......................97 4204221.......................97...

  • Page 157: Index

    157 index 113 , 117 , ... 121 , 123 , 126 446148 ....................... 73 446152 ..................... 135 446154 .... 59 , 63 , 75 , 85 , 87 , 109 , ..... 121 , 123 446160 ....................... 75 446166 ............. 115 , 135 447002 ....................... 49 447006 ....................... 49...

  • Page 158

    Jacobsen, a textron company 11108 quality drive, charlotte, nc 28273 www.Jacobsen.Com 800-848-1636 when performance matters. ™ equipment from jacobsen is built to exacting standards ensured by iso 9001 and iso 14001 registration at all of our manufacturing locations. A worldwide dealer network and f...