1. DL manuals
  2. JBL
  3. Speaker System
  4. DSC 500
  5. Service Manual

JBL DSC 500 Service Manual

Other manuals for DSC 500: Owner's Manual, Service Manual
Manual is about: Digital Simply Cinema

Summary of DSC 500

  • Page 1

    Specifications: source unit section • signal format system: ntsc/pal • video signal-to-noise ratio (dvd) : 60 db • audio frequency response dvd (pcm) : 20hz - 20 khz (±1 db) • audio frequency response cd : 20hz - 20 khz (±1 db) • signal-to-noise ratio: >80 db • total harmonic distortion: 0,0001 • dy...

  • Page 4

    5 2 1 3 4 25 6 7 8 27 26 9 11 10 12 24 23 22 20 13 14 16 15 17 18 21 19 logo badge logo badge door lens door lens window lens window lens volume knob volume knob front panel front panel top bracket top bracket control pcb control pcb rubber foot(front) rubber foot(front) plastic foot plastic foot ru...

  • Page 6

    Head unit - main board installation point description material no. Qty. Main pcb assy ape101700-0001 1 cn901 connector b12b-xh-a 12 pin ccn250000-0112 1 cn103 connector 20x2 pin plug base ccn254020-0440 1 cn101 cn201 connector 15 pin pitch=2.0mm ccn200000-0115 2 jk101 rca+din jk 4p din+2rca w/gnd cj...

  • Page 7

    C101 c102 c1020 c1021 c1022 chip cap 0.1 uf 50v 5% pyl456370-1040 66 c191 c192 chip cap 0.0056 uf 50v 5% pyl456370-5620 2 c1005 c1006 c1007 c1008 c1011 c4010 chip cap 0.1 uf 50v 10% pyl456470-1040 25 r111 r170 chip res. 0 ohm jump wire qcf015020-0000 2 r109 chip res. 10 ohm 1/10w 5% qcf015020-1000 1...

  • Page 8

    Fb103 fb104 fb105 fb106 fb107 fb201 fb202 fb203 fb204 fb205 fb206 fb207 fb208 chip bead 600 ohm at 100mhz scb008050-6010 13 c147 c148 c150 c151 chip cap 470 pf 50v 5% pyl410370-4710 8 c152 c153 c154 c149 r4006 r4016 r4026 r4056 r4066 r4046 chip res. 5.1k ohm 1/10w 5% qcf015020-5120 6 r4100 r470 r476...

  • Page 9

    Q204 xistr npn 2sc945p ran200945-0001 1 r225 resistor 1k ohm 1/6w 5% cf qaf065000-1020 1 d201 d202 d203 d204 d208 diode sw; 1n4148 rad114148-0010 5 r224 resistor 68k ohm 1/6w 5% cf qaf065000-6830 1 r207 r211 r212 r213 r226 resistor 100 ohm 1/6w 5% cf qaf065000-1010 5 r206 r208 resistor 100k ohm 1/6w...

  • Page 10

    C9 c17 c21 c29 c35 c37 c39 c42 c44 c46 c47 c19 c28 cond disc 0.1 uf 50v +80-20% prd249670-1040 13 c10 c12 c48 cond elect 1uf 50v 20% pre039570-1090 3 c6 cond elect 2.2 uf 50v 20% pre039570-2290 1 c24 cond elect 4.7 uf 50v 20% pre039570-4790 1 c51 c52 cond elect 10 uf 50v 20% pre039570-1000 2 c8 cond...

  • Page 11

    Wire 22 ga 80 mm red 14-14 mm vwr0333gg-0080 1 wire 22 ga 90mm red 4-4 vwr0333bb-0090 1 screw t3.0xl6xp1.06mm hsp140054-1060 4 c13 cond safty 0.01uf 250v 20% ply2705f0-1030 1 fu fuse 3.15a 250v slow(walter tsd) ksa020315-0120 1 fuse cover;id19.6xw11xh5.5mm ul dcr030001-0001 1 head unit - mechanics p...

  • Page 12

    C014 cond poly 560pf 50v 5% pvp026370-5610 1 vd001 vd002 diode tung am toshiba 1sv149b rhv100149-0001 2 l103 coil 39 mh 10% d6xh11xp5mm sil106003-3930 1 t102 am ift 455khz q=130 sif010001-0040 1 t105 fm ift 10.7mhz q=60 min sif020001-0050 1 t002 ant osc am 4-6:10t 1-3:86t sil013009-0011 1 t101 bias ...

  • Page 13

    C137 c138 chip cap 0.015 uf 50v 10% pyl456470-1530 2 c008 c129 c130 c141 c142 chip cap 0.0022uf 50v 10% pyl456470-2220 5 c131 c132 chip cap 0.0047 uf 50v 10% pyl456470-4720 2 r107 chip res. 10 ohm 1/10w 5% qcf015020-1000 1 r006 r138 chip res. 100 ohm 1/10w 5% qcf015020-1010 2 r004 r009 r116 r125 r15...

  • Page 14

    Led pcb assy ape200330-0001 1 cp2 con/wire 4p 140mm ul2468#26 blk a=2.0mm vfl41124b-1400 1 d211 d212 d213 d214 d215 d217 d218 chip led white smd0805 kcd900805-0010 7 r235 r236 r237 r238 r239 r240 r241 chip res. 75 ohm 1/10w 5% qcf015020-7500 7 screw steel screw m3xp0.5xl6mm flat head hsf143084-1060 ...

  • Page 15

    Spk front abs blk bpf405006-0101 1 logo plate l12xw10xt2mm bpl400003-0102 1 rubber foot od12.5xid6xt2.5mm brf400005-0001 1 rubber foot od12.5xid6.2xt6.8mm brf400006-0001 1 spk driver d22.4mm 30w tweeter fsa243010-1801 1 spk driver 70x70mm 8ohm 30w for center fsa213012-1801 2 spk grille l187xw74xh13....

  • Page 16

    Thiner flx union soltek t22 xtn000022-0001 1 rl1 rl2 rl5 inductor 0.4uh 1 ohm 2w 5% shn002501-4080 3 jp13 con/wire 6p 100/80/120 1533#28 vwa020011-0001 1 jp7 con/wire 2p 150mm 26awg vfl21131b-1500 1 jp8 con/wire 2p 500mm blk vfl21131b-5000 1 c153 c253 c553 cond disc 560 pf 50v 10% prd235470-5610 3 c...

  • Page 17

    R605 chip res. 8.2k ohm 1/10w 5% qcf015020-8220 1 da01 da02 chip diode ll4148 telefunken rcd104148-0010 2 ic1 ic2 ic3 ic4 ic5 ic6 ic 14 pin tl074cd rci000740-0001 6 ic101 ic201 ic301 ic401 ic501 ic601 ic7b ic 8 pin tl072cd rci000720-0001 7 ca05 chip cap 1000 pf 50v 5% pyl410370-1020 1 c103 c203 c303...

  • Page 18

    Installation point description material no. Qty. Jack pcb assy ape200053-0001 1 l501 l502 l503 l504 l505 rf coil 1 uh mdec t40818-08 sil001003-1090 5 jk501 terminal iack assy 5 slot abs blk cot080005-0001 1 jp16 to j93 flat cable 3p 100mm 2468#26 a=2.5mm vfl31131b-1000 1 cn401b d-sub jack 15p d-sub ...

  • Page 19

    F1 f2 f3 f4 f5 f6 fuse clip dia5xl20mm fuse cfc011000-1001 6 d1 d2 sleeving od3xid2.5xl10mm dsl001001-0100 2 c17 c18 cond elect 2200 uf 35v 20% pve039560-2220 2 c13 c14 cond elect 3300 uf 50v 20% pve039570-3320 2 c15 c16 cond elect 4700 uf 50v 20% pve039570-4720 2 con/wire 3p 300mm 2877#26 blk vfl31...

  • Page 20

    Bead ferit od25.0xid15xh12.0 sfb001001-0060 1 con/wire 4p 120mm 1617#18x2p vwa310013-0011 1 sponge l100xw30xt2mm ive000085-0001 1 gsb bkt r secc t=1.0mm gse200010-0001 1 pcb bkt l secc t=1.0mm gse200011-0001 1 ac conntor ac conntecor (hw-c3) (j3615) cot010002-0001 1 power transformer 230v ei-105 ttl...

  • Page 21

    Inlay 50 key pvc bni250001-0001 1 spring(+ -) dsp201002-0001 1 spring(+) dsp201003-0001 1 spring(-) dsp201001-0001 1 key pad 54 key rubber brk201054-0001 1 x'mitt pcb assy ape200150-0001 1 r3 chip res. 1 ohm 1/10w 5% qcf015020-1090 1 d3 chip diode ll4148 telefunken rcd104148-0010 1 r2 chip res. 4.7k...

  • Page 28

    1 2 3 4 a b c d 4 3 2 1 d c b a ess6018 wm8746 6ch audio d/a video filter memory flash 8m (29f080b) sdram 64m(4m*16sdram 9ns) atapi lcd rds: bu1923f pll: lc72131m la1837 fm am vol/treble/bass ctl m62446afp audio input select ac-3/dts decode earphone pt6583 tv encode wm8739 2ch audio a/d filter filte...

  • Page 29: Dsc500Sub  Block Diagram

    Balance receiver eq amplifier r- ic101 r ic1 r u2 r+ tl072 tl074 lm3886 c- ic201 c ic2 c u5 c+ tl072 tl074 lm3886 l- ic301 l ic3 l u1 l+ tl072 tl074 lm3886 sr- ic401 sr ic4 sr u4 sr+ tl072 tl074 lm3886 sl- ic501 sl ic5 sl u3 sl+ tl072 tl074 lm3886 sw- ic601 sw ic6 sw u6 sw+ tl072 tl074 lm3886 mute f...

  • Page 30

    1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 a b c d 16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1 d c b a la0 la1 la2 la3 la4 la5 la6 la7 la8 la9 la10 la11 la12 la13 la14 la15 la16 la17 la18 la19 la21 ld0 ld1 ld2 ld3 ld4 ld5 ld6 ld7 hrd# hwr# hiordy hrst# ha2 db0 db1 db2 db3 db4 db5 db6 db7 db8 db9 db10 db11 db...

  • Page 31

    1 2 3 4 5 6 7 8 a b c d 8 7 6 5 4 3 2 1 d c b a t i t l e num be r r evision s i z e a2 d a t e : 23-oct-2002 sheet of f i l e : e : \ c jh\ d s c 5 0 0 \ d s c 5 0 0 \ d sc 5 0 0 e . D d b d r a w n b y : c 2 1 1 10uf c 2 1 2 1 0 4 r 2 2 4 6 8 k t a 2 0 7 t a 2 0 2 d202 1 n 4 1 4 8 d203 1 n 4 1 4 8...

  • Page 32

    1 2 3 4 5 6 7 8 a b c d 8 7 6 5 4 3 2 1 d c b a title number revisio n size a3 date: 23-oct-2 0 0 2 sh eet o f file: e:\cjh\dsc500\dsc500\dsc500e.Dd b drawn by: fl+ fl- 10 11 13 16 14 12 15 18 16 9 8 7 3 1 17 tr ac90v-260v in 1 out 3 gnd 2 ic7 mc7812ct in 2 out 3 gnd 1 ic6 mc7912ct c3 1 330uf/25v 1 ...

  • Page 33

    1 2 3 4 a b c d 4 3 2 1 d c b a c003 223 c108 104 c111 30 c105 223 c110 200 d001 1n4148 g s d q001 sk192 tc001 (22p) ant 1 nc 2 agc 3 gnd 4 vt 5 b+ 6 if/o 7 osc 8 ef001 c001 33p 4 5 1 2 3 t003 shv2020-001 4 5 1 2 3 t002 ahv0491-101 vd001 sv1498 cf101 10.7m vco 15 fm dec 9 am sd 12 fmif 1 am mix 2 fm...

  • Page 34

    1 2 3 4 5 6 a b c d 6 5 4 3 2 1 d c b a title number revision size b date: 23-oct-2002 sheet of file: e:\cjh\dsc500\dsc500\dsc500e.Ddbdrawn by: r1 4.7k r2 4.7k ki2 1 ki3 2 ki4 3 ki5 4 ki6 5 ki7 6 rem 7 vdd 8 sel 9 osco 10 osci 11 vss 12 lmp 13 ki/o7 14 ki/o6 15 ki/o5 16 ki/o4 17 ki/o3 18 ki/o2 19 ki...

  • Page 35

    1 2 3 4 5 6 7 8 9 10 11 12 a b c d 12 11 10 9 8 7 6 5 4 3 2 1 d c b a + 3 - 2 o 1 v+ 4 v- 11 ic1a tl074 + 5 - 6 o 7 ic1b tl074 + 10 - 9 o 8 ic1c tl074 + 12 - 13 o 14 ic1d tl074 r103 10k r100 10k r101 27k r102 5.6k c103 220p c102 o ohm c101 1/50 r105 6k8 r104 12k r106 jp jp jp r110 n/c r108 n/c r109 ...