Jeep Cherokee 1993 Maintenance Information - page 8
Weatherstrip ......................... Silicone Spray Lubricant
(1) - DO NOT use Dexron-III ATF, Clutch chatter can result.
(2) - SAE 10W-30 SH/CD ECII is preferred.
(3) - DO NOT use heavier weight lubricant, as it will cause axle
engagement difficulties, use only SAE 80W-90 lube.
(4) - Add 4 ozs. (118 ml) of Limited-Slip differential lubricant
additive when changing fluid.
(5) - For vehicles operating under heavy-duty towing conditions,
use SAE 75W-140 Synthetic lube.
NOTE: Before using SAE 75W-140 Synthetic the old fluid must be
DRAINED and FLUSHED with clean mineral based (non-synthetic)
axle lubricant. Then refill with new synthetic lube.
(6) - Use low pressure grease gun to prevent seal damage.
(7) - Fill until lubricant squeezes out from the base of seals.
(8) - Fill ball joint until seal starts to swell.
FLUID CAPACITIES
FLUID CAPACITIES TABLE
Application Quantity (1)
A/C System R-12 Refrigerant Capacity
1989-90 .......................................... 36-40 Ozs.
1991-93
Cherokee 2-Door ................................... 32 Ozs.
Cherokee 4-Door ................................... 38 Ozs.
1994 (up to 12/93)
Cherokee 2-Door ................................... 32 Ozs.
Cherokee 4-Door ................................... 38 Ozs.
A/C System R-134a Refrigerant Capacity (2)
1994-96 (from 1/94) ................................. 32 Ozs.
Automatic Transmission (3)
30RH (3-Speed)
Fluid Change .............................. 4.0 Qts. (3.8L)
Overhaul (Dry Fill) ...................... 8.75 Qts. (8.2L)
AW4 (4-Speed)
Fluid Change .............................. 2.0 Qts. (1.7L)
Overhaul (Dry Fill) ....................... 8.5 Qts. (8.0L)
Cooling System
2.5L (4) ................................... 10.0 Qts. (9.5L)
4.0L (5) .................................. 12.0 Qts. (11.4L)
Engine Oil (6)
2.5L ........................................ 4.0 Qts. (3.8L)
4.0L ........................................ 6.0 Qts. (5.7L)
Fuel Tank ................................... 20.2 Gals. (76.4L)
Manual Transmission (7)
AX4 (4-Speed AISIN) ......................... 7.4 Pts. (3.5L)
T4 (4-Speed Borg-Warner) .................... 3.9 Pts. (1.8L)
AX5 (5-Speed AISIN)
2.5L (2WD) ................................ 7.0 Pts. (3.5L)
2.5L (4X4) ................................ 6.6 Pts. (3.2L)
T5 (5-Speed Borg-Warner) .................... 4.5 Pts. (2.1L)
AX15 (5-Speed AISIN)
4.0L (2WD) ................................ 6.4 Pts. (3.1L)
4.0L (4X4) ............................... 6.5 Pts. (3.15L)
Transfer Case
Command-Trac (NV 231) ....................... 2.2 Pts. (1.0L)
Selec-Trac (NV 242) ......................... 3.0 Pts. (1.4L)
Drive Axles (7)