Summary of G 2200
Page 1
English. . . . . 4 español . . . . 20 français. . . . 40 8.641-220.0 12/15 g 2200
Page 2: G 2200
G 2200
Page 4: Contents
4 english please read and comply with these original instructions prior to the initial operation of your appliance and store them for later use or subsequent owners. 1. Air filter 2. Engine switch 3. Detergent pipe 4. Pump outlet 5. Spray gun 6. Pressure hose 7. Nozzles 8. Fuel tank cap 9. Spark plu...
Page 5: Hazard Levels
English 5 indicates “an imminently hazardous situation which, if not avoided, will result in death or serious injury.” indicates “a potentially hazardous situation which, if not avoided, could result in death or injury.” indicates “a potentially hazardous situation which, if not avoided, may result ...
Page 6: Water Supply
6 english ▬ the trigger gun safety lock prevents the trigger from accidentally being engaged. This safety feature must be engaged when replacing nozzles or not in use. The engine exhaust from this product contains chemicals known to the state of california to cause cancer, birth defects or other rep...
Page 7: Assembly Instructions
English 7 ▬ always prevent debris from being drawn into the unit by using a clean water source. Use additional water filter. ▬ do not operate pressure washer without the water turned on. A - main frame b - handle c - gun hook & hose hook d - knobs & bolts e - pressure hose f - spray gun & wand g - w...
Page 8: Assembling
8 english parts not shown: 1 - manual 1 - nozzle cleaner 1 - spark plug wrench 1 - o-ring set (2 for pressure hose, 1 for spray gun) ► install the wheels to the main frame by pressing the spring loaded pin on wheel axle, then insert wheel axle into frame. Ensure that the spring pin is fixed in posit...
Page 9: Preparation
English 9 engine shipped without oil in crankcase. Before starting engine, fill with oil. Do not over-fill. Do not run the engine with a high or low oil level as this can cause engine damage. If you have further questions regarding the engine, please refer to the engine manual included with the unit...
Page 10: Air Filter
10 english then remove the fuel cap by turning it counter clockwise. ► when refueling, make sure the fuel filter is in place and keep in mind all safety precautions. ► use clean unleaded gasoline with a minimum of 87 octane. Do not use old gas. Do not mix oil with gasoline. Fuel tank capacity: .26 g...
Page 11: Using The Accessories
English 11 ► open water source. ► start the engine 1. Turn the engine switch to "on" position. 2. Pull trigger on spray gun to release pressure. 3. Locate recoil cord and pull slowly until resistance is felt. At this point, pull rapidly to start engine. Note: if unable to start the engine, repeat th...
Page 12: Working With Detergents
12 english 25° spray angle = green nozzle for dirt accumulation over a large surface. 40° spray angle = white nozzle for moderate dirt accumulation over a large surface. Soap = black nozzle for operating with detergents or cleaning with low pressure. High pressure in nozzle area. Risk of injury caus...
Page 13: Taking A Break
English 13 washer. The special formula won't clog the filter and will protect the internal parts of the pressure washer for a longer life. For kärcher detergents, check your retailer or visit our website: www.Karcherresidential.Com never use: ▬ bleach, chlorine products or other corrosive chemicals....
Page 14: Winterizing & Long-Term
14 english it is highly recommended to use kärcher pump guard (part number 9.558-998.0) before winter storage and during the cleaning season to protect the pump from freezing and premature wear. ► turn engine switch to the off position. ► disconnect all hoses. ► unscrew cap from pump guard bottle. ►...
Page 15: Cleaning Tips
English 15 with or without detergent pre-rinse deck and surrounding area with fresh water. If using kärcher deck wash, apply to surface at low pressure. For best results, limit your work area to smaller sections of approximately 25 square feet. Allow deck wash to remain on surface 1-3 minutes. Do no...
Page 16: Barbecue Grills, Outdoor
16 english remain on surface 1-3 minutes. Do not allow detergent to dry on surface. Rinse at high pressure in a sweeping motion keeping the spray nozzle approximately 3-6 inches from the cleaning surface. Always clean from top to bottom and from left to right. For removing extremely stubborn stains,...
Page 17: Troubleshooting
English 17 remove the spark plug cable to pre- vent accidental ignition of the engine before making any repair. Troubleshooting symptom cause solution engine will not start no gasoline. Fill gas tank. Choke is not in the correct position. Slide lever out to closed position. Ignition switch is not in...
Page 18
18 english output pressure varies between high and low pump is sucking air. Check that hoses and fittings are air tight. Turn off machine and purge pump by squeezing trigger gun until a steady flow of water emerges through the nozzle water inlet filter is clogged. Remove filter and rinse out in warm...
Page 19
English 19 if the symptom you are experiencing is not listed above, or if the provided solutions do not solve your issue, please visit our extensive online troubleshooting database at: www.Karcher-help.Com spray wand leaks spray wand not properly attached. Turn the swivel nut of the gun clockwise un...