1. DL manuals
  2. Karcher
  3. Lawn Sweeper
  4. KM 100/100 R LPG
  5. Instruction Manual

Karcher KM 100/100 R LPG Instruction Manual

Other manuals for KM 100/100 R LPG: Manual

Summary of KM 100/100 R LPG

  • Page 1

    Register and win! Www .Kaercher .Com 59637400 (08/12) km 100/100 r p km 100/100 r lpg.

  • Page 2

    2.

  • Page 3

    - 1 please read and comply with these original instructions prior to the initial operation of your appliance and store them for later use or subsequent own- ers. Before first start-up it is definitely neces- sary to read the safety indications nr. 5.956-250! Your sales outlet should be informed abou...

  • Page 4

    - 2 – gas must always be drawn only from one cylinder. Drawing gas from multi- ple cylinders simultaneously can cause liquid gas from one cylinder flowing into the other. This causes the over-filled cylinder to be subjected to an unpermit- ted excess pressure when the cylinder valve is closed later ...

  • Page 5

    - 3 use this sweeper only as directed in these operating instructions. The machine with working equipment must be checked to ensure that it is in proper working order and is operating safely prior to use. Otherwise, the appli- ance must not be used. – this sweeper has been designed to sweep dirt and...

  • Page 6

    - 4 1 dust filter 2 air filter insert 3 spark plug 4 oil dipstick 5 gas cylinder (only km 100/100 r lpg) 6 cover 7 waste container (both sides) 8 lever for seat adjustment 9 roller brush 10 pedal for raising/lowering bulk waste flap 11 side brushes 12 drive pedal 13 front panel 14 choke (cold start)...

  • Page 7

    - 5 danger risk of injury and damage! Do not use a forklift to unload the appliance. To unload the machine, proceed as follows: cut plastic packing belt and remove foil. Remove the elastic tape fasteners at the stop points. Four indicated floor boards of the pallet are fastened with screws. Unscrew ...

  • Page 8

    - 6 1 driving driving to the place of use. 2 sweeping with sweep roller roller brush is lowered. The roller brush and the side brush will rotate. 3 sweeping with side brushes roller brush and side brushes are low- ered. Note the machine is equipped with a seat con- tact mat. If the driver's seat is ...

  • Page 9

    - 7 note: during operation, the waste contain- er should be emptied at regular intervals. Note: during operation, the dust filter should be shaken off and cleaned at regu- lar intervals. Close wet/dry flap open wet/dry flap. Note: you can thus preven the filter system from getting blocked. Open wet/...

  • Page 10

    - 8 caution risk of damage! Do not clean the appliance with a water hose or high-pressure water jet (danger of short circuits or other dam- age). Danger risk of injury! Wear dust mask and protec- tive goggles. Open the hood, insert retaining rod. Clean machine with a cloth. Blow through machine with...

  • Page 11

    - 9 hose connection at the vacuum pressure socket of the side brush lowering system hose connections at the vacuum pressure sockets of the roller brush lowering system hose connections at vacuum pressure pump and vacuum pressure socket (accu- mulator) note: the vacuum pressure pump runs only while t...

  • Page 12

    - 10 the sweeping track should have an even rectangular shape which is between 50 and 70 mm wide. Note: the side brush floating mounting of the roller brush adjusts the sweeping track as the bristles wear down. The roller brush must be replaced if it becomes too worn. Park the sweeper on an even sur...

  • Page 13

    - 11 check tension of drive belt and v-belt of the suction blower, also check for wear or damage. Check tension, wear and damages on the v-belt of the sweep roller drive. Chek the cup seal at the suction blower regularly to see that it sits properly. Loosen screws on both sides of the panel. Replace...

  • Page 14

    - 12 danger switch off engine and remove ignition key prior to carrying out any maintenance work. Risk of injury! Allow the machine sufficient time to cool down before carrying out any maintenance and repair work. Troubleshooting fault remedy appliance cannot be started sit on the driver seat, the s...

  • Page 15

    - 13 technical specifications km 100/100 r p km 100/100 r lpg machine data length x width x height mm 2006 x 1005 x 1343 2006 x 1005 x 1343 unladen weight kg 300 300 transport weight kg 375 375 permissible overall weight kg 520 520 driving speed km/h 8 8 cleaning speed km/h 6 6 climbing capability (...

  • Page 16

    - 14 we hereby declare that the machine de- scribed below complies with the relevant basic safety and health requirements of the eu directives, both in its basic design and construction as well as in the version put into circulation by us. This declaration shall cease to be valid if the machine is m...

  • Page 18

    06/12 ae karcher fze, p.O. Box 17416, jebel ali free zone (south), dubai, united arab emirates, +971 4 886-1177, www.Kaercher.Com ar kärcher s.A., urugguay 2887 (1646) san fernando, pcia. De buenos aires +54-11 4506 3343, www.Karcher.Com.Ar at alfred kärcher ges.M.B.H., lichtblaustraße 7, 1220 wien,...