Kawasaki FJ180V - Owner's Manual

Other manuals for FJ180V -: Service Manual, Datasheet, Service Manual, Owner's Manual
Manual is about: 4-Stroke Air-Cooled Gasoline Engine

Summary of FJ180V -

  • Page 1

    Fj180v part no. 99920-2254-03 owner’s manual 4-stroke air-cooled v-twin gasoline engine.

  • Page 2

    1 dec. 2009 (5) (m) engine inclination oil filter change(if equipped) 2009 2 3 6 8 9 9 9 10 10 12 12 12 12 12 13 13 14 14 15 15 16 17 19 20 21 22 23.

  • Page 3

    2 for your safety, read this owner's manual and understand it thoroughly before operating this engine. Warning never allow children to operate the engine or equipment. Keep people and pets out of areas where you are using the engine or equipment. Never wear loose, torn, or bulky clothing. It may cat...

  • Page 4

    Engine greater than 80cc and less than 225cc 3.

  • Page 5

    4.

  • Page 6

    1. Exhaust emission related parts 2. Evaporative emission related parts 5.

  • Page 7

    Location of safety related labels engine serial number the engine serial number is your only means of identifying your particular engine from others of the same model type. This engine serial number shown on the label is needed by your dealer when ordering parts. A. Warning label a. Engine serial nu...

  • Page 8

    7 a. B. C. D. Fuel tube oil drain plug carburetor priming pump (if equipped) e. F. G. Control panel spark plug cap/spark plug air cleaner h. I . J. K. Fuel tank fuel tank cap oil gauge/filler cap recoil starter l. M. Recoil starter grip muffler 1.8 l (0.48 u.S.Gal).

  • Page 9

    Fuel use only clean, fresh, unleaded regular grade gasoline. Octane rating the octane rating of a gasoline is a measure of its resistance to "knocking". Use a minimum of 87 octane of the antiknock index is recommended. The antiknock index is posted on service station pumps. Note if "knocking or ping...

  • Page 10

    Fuel level the engine (equipment) before fueling. Remove the fuel tank cap. Slowly pour fuel into the fuel tank to bottom (b) of the filler (a). Fuel tank capacity 1.8 l (0.48 us.Gal) close the tank cap securely by turning it clockwise as far as it will go. Engine oil check the engine oil level dail...

  • Page 11

    Pull in the direction of arrow 10

  • Page 12

    11.

  • Page 13

    Engine inclination 12.

  • Page 14: Adjustment

    Engine speed adjustment adjustment do not tamper with the governor setting or the carburetor setting to increase the engine speed. Each carburetor is adjusted at the factory with either a cap or stop plate installed on the mixture screw. Any adjustments must be performed an authorized kawasaki deale...

  • Page 15

    Periodic maintenance chart maintenance maintenance, replacement or repair of the emission control devices and systems may be performed by any nonroad engine repair establishment or individual. ● ● ● ● ● ● ● ●first ● ● ● ● ● ● ● ● ● ● ● ● ★ ★ ★ ★ k k k interval maintenance first 8 hr. Every 25 hr. Ev...

  • Page 16

    Oil level check check oil level daily and before each time of operation. Be sure oil level is maintained. See preparation chapter. Oil change change oil after first 8 hours of operation. Thereafter change oil every 50 hours. Run the engine to warm oil. Be sure the engine (equipment) is level. Stop t...

  • Page 17

    16 oil filter change (if equipped) ● change the oil filter every 200 hours of operation. ● drain engine oil to suitable containers. ● rotate the oil filter (a) counter- clockwise to remove it. ● apply a thin film of clean engine oil on the seal of the new filter. ● install new filter rotating it clo...

  • Page 18

    Cooling system cleaning before each use, check that the recoil starter (a) is free from grass and debris and clean to prevent engine overheating. Air cleaner service a. Recoil starter caution to prevent excessive engine wear, do not run the engine with the air cleaner removed. Warning clean the elem...

  • Page 19

    Foam element (a) clean the foam element every 25 hours. Wash the element in detergent and water, and dry it thoroughly. Paper element (b) clean the paper element every 100 hours. Clean the element by tapping gently to remove dust. If very dirty, replace the element with a new one. Replace with a new...

  • Page 20

    Spark plug service clean or replace the spark plug and reset the gap (a) every 100 hours of operation. Disconnect the spark plug cap from spark plug and remove the spark plug. Clean the electrodes (b) by scraping or with a wire brush to remove carbon deposits. Inspect for cracked porcelain or other ...

  • Page 21

    Engine to be stored over 30 days should be completely drained of fuel (gasoline) to prevent gum deposits forming on essential carburetor parts and the fuel system. Remove the spark plug cap from spark plug to prevent accidental starting the engine. Empty the fuel from the fuel tank with a pump or si...

  • Page 22

    If the engine malfunctions, carefully examine the symptoms and the operating conditions, and use the table below as a guide to troubleshooting. K: service to be performed by an authorized kawasaki dealer. Symptom probable cause remedy engine won't start or output is low insufficient compression faul...

  • Page 23

    To protect our environment, properly discard used batteries, engine oil, gasoline, coolant, or other components that you might dispose of in the future. Consult your authorized kawasaki dealer or local environmental waste agency for their proper disposal procedure. Environmental protection 22.

  • Page 24

    Specifications are subject to change without notice type of engine air-cooled, 4-stroke ohv, single cylinder, gasoline engine bore x stroke 65 x 54 mm(2.6 x 2.1 in.) displacement 179 ml (10.9 cu.In) ignition system solid-state ignition starting system recoil starter dry weight 17.0 kg (37.49 lb) spe...

  • Page 25

    Warning: the engine exhaust from this product contains chemicals known to the state of california to cause cancer, birth defects or other reproductive harm. For repair/warranty assistance please contact your local kawasaki authorized dealer, email kawpower-website@kmc-usa.Com or call toll-free 1-877...