Land Pride Accu-Z Razor ZSR54 Operator's Manual - page 2
Z48, Z54, ZSR54 & ZSR60 Accu-Z Razor
®
Zero Turn Mowers 357-344M
11/05/10
Table of Contents
©
Copyright 2010 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land
Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves
the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Table of Contents
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Section 1: Assembly & Set-up . . . . . . . . . . . 10
Uncrating Instructions . . . . . . . . . . . . . . . . . . . . . . 10
Control Lever Assembly . . . . . . . . . . . . . . . . . . . . 10
Seat Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Discharge Chute Assembly . . . . . . . . . . . . . . . . . . 11
Seat Belt Assembly . . . . . . . . . . . . . . . . . . . . . . . . 11
Folding ROPS Assembly . . . . . . . . . . . . . . . . . . . . 11
Hitch Plate Assembly . . . . . . . . . . . . . . . . . . . . . . 12
Electrical Cable Connection . . . . . . . . . . . . . . . . . 12
Engine Preparations . . . . . . . . . . . . . . . . . . . . . . . 12
Remove Mower From Crate Floor . . . . . . . . . . . . . 12
Section 2: Operating Procedures . . . . . . . . 13
Mower Features . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Operating Check List . . . . . . . . . . . . . . . . . . . . . . . 14
Instrumentation . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Engine Oil Pressure Light . . . . . . . . . . . . . . . . . . 14
Hour Meter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Ignition Switch . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Throttle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Choke . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Blade Engagement Switch . . . . . . . . . . . . . . . . . 15
Left/Right Fuel Tank Valve . . . . . . . . . . . . . . . . . 15
Park Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Control Levers . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Deck Lift Pedal . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Engine Starting . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Engine Shut-Down Sequence . . . . . . . . . . . . . . . . 16
Safety Start Interlock System . . . . . . . . . . . . . . . . 17
Driving the Mower . . . . . . . . . . . . . . . . . . . . . . . . . 17
Accessing Area Beneath the Seat . . . . . . . . . . . . . 19
Moving Mower with Stalled Engine . . . . . . . . . . . . 19
Safe Operating Instructions . . . . . . . . . . . . . . . . . . 20
General Operating Information . . . . . . . . . . . . . . . 22
Section 3: Adjustments . . . . . . . . . . . . . . . . 23
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 23
Tire Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Front Floating Axle
(ZSR Models Only) . . . . . . . . . . . . . . . . . . . . . . . . 23
Steering Adjustments . . . . . . . . . . . . . . . . . . . . . . 24
Lower Control Lever . . . . . . . . . . . . . . . . . . . . . . 24
Upper Control Lever . . . . . . . . . . . . . . . . . . . . . . 25
Seat Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Ground Drive Belt Adjustment . . . . . . . . . . . . . . . . 26
Deck Drive Belt Adjustment . . . . . . . . . . . . . . . . . . 26
Deck Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . 27
Deck Cutting Height And Leveling . . . . . . . . . . . 27
Deck Lift Assist Springs . . . . . . . . . . . . . . . . . . . 28
Anti-Scalp Rollers . . . . . . . . . . . . . . . . . . . . . . . . 29
Cutting Height Settings . . . . . . . . . . . . . . . . . . . . . 29
Section 4: Options & Accessories . . . . . . . . 30
Folding Soft Top Canopy . . . . . . . . . . . . . . . . . . . . 30
Electric Deck Lift . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Mulching Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Light Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Inductive Tachometer . . . . . . . . . . . . . . . . . . . . . . 30
Section 5: Maintenance & Lubrication . . . . . 31
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Maintenance Safety . . . . . . . . . . . . . . . . . . . . . . . . 31
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 32
Maintenance Schedule . . . . . . . . . . . . . . . . . . . . . 33
Maintenance Locations . . . . . . . . . . . . . . . . . . . . . 34
Electrical System . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Hydrostatic Drive System . . . . . . . . . . . . . . . . . . . 37
Hydraulic Oil Level Check . . . . . . . . . . . . . . . . . . 37
Transaxle Oil and Filter Change . . . . . . . . . . . . . . 38
Transaxle Purging Procedures . . . . . . . . . . . . . . . 39
Fuel System . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
Fuel Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 40
Draining The Fuel Tank . . . . . . . . . . . . . . . . . . . . . 40
General Engine Maintenance . . . . . . . . . . . . . . . . 41
Engine Oil and Oil Filter . . . . . . . . . . . . . . . . . . . . . 41
Check Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . 41
Change Engine Oil . . . . . . . . . . . . . . . . . . . . . . . 41
Engine Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Internal Type Air Filters . . . . . . . . . . . . . . . . . . . 42
Canister Type Air Filters . . . . . . . . . . . . . . . . . . . 42
Air Filter Handling . . . . . . . . . . . . . . . . . . . . . . . . . 43
Belt Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Deck Drive Belt Removal & Installation . . . . . . . 44
Ground Drive Belt Removal & Installation . . . . . . 44
Mower Blade Maintenance . . . . . . . . . . . . . . . . . . 46
End of Season & Long Term Storage . . . . . . . . . . 48
New Season Preparation . . . . . . . . . . . . . . . . . . . . 48
Lubrication Points . . . . . . . . . . . . . . . . . . . . . . . . . 49
Section 6: Specifications & Capacities . . . . . 51
Section 7: Features and Benefits . . . . . . . . . 54
Section 8: Troubleshooting . . . . . . . . . . . . . . 56
Section 9: Torque & Tire Inflation Charts . . 58
Section 10: Warranty . . . . . . . . . . . . . . . . . . . 59