Land Pride FM3188 Operator's Manual - page 2
Table of Contents
©
Copyright 2011 All rights Reserved
Land Pride provides this publication “as is” without warranty of any kind, either expressed or implied. While every precaution has been taken in the preparation of this manual, Land
Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use of the information contained herein. Land Pride reserves
the right to revise and improve its products as it sees fit. This publication describes the state of this product at the time of its publication, and may not reflect the product in the future.
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Table of Contents
FM3188 & FM4188 Flail Mowers 309-523M
6/24/11
Important Safety Information . . . . . . . . . . .1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Introduction . . . . . . . . . . . . . . . . . . . . . . . .7
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 7
Serial Number Plate . . . . . . . . . . . . . . . . . . . . . . . 7
Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . 8
Section 1: Assembly & Set-up . . . . . . . . . .9
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . . 9
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . . 9
Hitch Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 10
Driveline Installation . . . . . . . . . . . . . . . . . . . . . . . 10
Check Driveline Collapsible Length . . . . . . . . . . 11
Shorten Driveline Length . . . . . . . . . . . . . . . . . . 11
Check Driveline Extended Length . . . . . . . . . . . 12
Check Driveline Interference . . . . . . . . . . . . . . . 12
Section 2: Operating Instructions . . . . . .13
Pre-Start Checklist . . . . . . . . . . . . . . . . . . . . . . . . 13
Tractor Shut Down Procedure . . . . . . . . . . . . . . . . 13
Transporting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 13
Mowing Instructions . . . . . . . . . . . . . . . . . . . . . . . . 14
Brush Rake Teeth . . . . . . . . . . . . . . . . . . . . . . . . . 14
Operating Instructions . . . . . . . . . . . . . . . . . . . . . . 14
General Operating Instructions . . . . . . . . . . . . . . . 15
Section 3: Adjustments . . . . . . . . . . . . . .16
Leveling the Mower . . . . . . . . . . . . . . . . . . . . . . . . 16
Cutting Height Adjustment . . . . . . . . . . . . . . . . . . . 16
Hitch Adjustments . . . . . . . . . . . . . . . . . . . . . . . . . 16
Belt Tension Adjustment . . . . . . . . . . . . . . . . . . . . 17
Brush Rake Teeth Adjustment . . . . . . . . . . . . . . . . 17
Section 4: Maintenance & Lubrication . .18
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Trash Removal & Rotor Knife Access . . . . . . . . . . 18
Rotor Knife Replacement . . . . . . . . . . . . . . . . . . . . 19
FM3188 Cutting Knife Replacement . . . . . . . . . . 19
FM4188 Hammer Knife Replacement . . . . . . . . . 19
V-Belt Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 19
Storage . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Lubrication . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Driveline Shaft U-Joints . . . . . . . . . . . . . . . . . . . 21
Driveline Profiles . . . . . . . . . . . . . . . . . . . . . . . . 21
Inner Tube Bearings . . . . . . . . . . . . . . . . . . . . . . 21
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
3-Point Hitch Slide . . . . . . . . . . . . . . . . . . . . . . . 22
Roller Bearing (Both Ends) . . . . . . . . . . . . . . . . . 22
Cutter Rotor Bearing (Both Ends) . . . . . . . . . . . . 22
Section 5: Specifications & Capacities . .23
Section 6: Features & Benefits . . . . . . . .24
Section 7: Troubleshooting . . . . . . . . . . .25
Section 8: Torque Values Chart . . . . . . . .26
Section 8: Warranty . . . . . . . . . . . . . . . . .27