LDC Racing Sailboats RS200 Owner's Manual - Sail Care Guide
20
Sail Care Guide
By Hyde Sails
Good racing sails today are expensive items, yet it is surprising how many
people are prepared to neglect or mistreat them. The rules for correct sail
care are easy and simple to implement.
1. The jib and mainsail should be stored dry, out of direct sunlight when not in
use (Ultra-Violet light damages sailcloth), and rolled:
* Ensure there are no folds in the cloth as you roll the sail.
* If you do have a fold or crease, unroll the sail and let the crease drop out.
DO NOT PULL IT OUT!! This action can tear sailcloth.
2. Asymmetric spinnakers should be stored dry and loose if possible, do not
leave them in the chute with the corners hanging out! Do not dry spinnakers
by allowing them to flap in the wind.
3. When using brand new sails for the first time, try to ensure that the
conditions are not too extreme because the high loads on new sailcloth can
diminish the racing life of the sail. This particularly applies to the Hard Dacron
jib which may get a lot of those 'Little white score marks'. Do not allow sails to
flap unnecessarily. Where possible, take sails down between races and as
soon as possible after sailing.
4. If your sail is stained in any way, try to remove it using normal detergent
and warm water. Do not attempt to launder the sail yourself.
6. Repairs should be temporarily fixed using sticky number cloth or sail repair
tape and then returned to a sailmaker for a professional repair.
7. Check the batten tension regularly, slack battens can work their way out of
the luff retaining caps and damage the sailcloth. The battens should be
tensioned enough in the pockets so that when the boat is sailing there are no
wrinkles in the batten pockets. Watch out for wear and tear, especially
around the batten pockets and bolt rope.
8. Make sure that all shackles, pins and sharp objects that the spinnaker
might travel over are well taped (preferably using PVC tape). Untaped
shackles or frayed wires are the most common cause of major tears in
spinnakers.