- DL manuals
- M Design
- Indoor Fireplace
- LUNA 550 DV Gold Gas
- Instructions For Installation And Use Manual
M Design LUNA 550 DV Gold Gas Instructions For Installation And Use Manual
Summary of LUNA 550 DV Gold Gas
Page 1
Luna 850 v / 550 v gold gas luna 850 dv / 550 dv gold gas instruction for installation and use passion for fire english 11-2012.
Page 2: M - D E S I G N
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 2 v e r y i m p o r ta n t i n s ta l l at i o n i n s t r u c t i o n s f o r t h e m - d e s i g n g a s f i r e p l a c e s t h e s u p p l i e r ta k e s n o r e s p o n s b i l i t y f o r a n y p o s s ...
Page 3
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 3 summary 1. General remarks .............................................................. 5 2. Connection .......................................................................... 5 3. Installing the firep...
Page 4
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 4 open closing key if some dust or waste is seen on the window ( inside and outside ), clean this before the first use of the fireplace. Open and close the door.
Page 5
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 5 1. General remarks this is a moulding of the closed combustion system, designed for the atmosphere and comfort of your living-room. It constitutes an efficient source of heat and gives the impression of a r...
Page 6
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 6 3. Installing the fireplace after having checked the appliance, you ready to install your appliance. This is done as follows 3.1.1 positioning the fireplace place the fireplace on a stable surface using the...
Page 7
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 7 4. Installing the chimney install the concentric flue duct as indicated by ontop - metaloterm. The only authorised pipes are ontop metaloterm™. Ontop-metaloterm tested our fireplace with their conduct and w...
Page 8
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 8 fig. 1 fig. 1 roof exit ( c31 ) tab. 2 this is recommanded with a roof exit tab. 1 this is recommanded with a roof exit > 3m Ø 150/100 appliance c (min) c (max) restrictiion hr+ (as from 4m) luna 850 v / 55...
Page 9
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 9 fig. 2 fig. 2 roof exit via existing chimney (c 31s ) tab. 1 tab. 2 it is obligatory to use the sanitation set ussan with placing. This ussan piece must be sealed at the roof. * * ou/of usdhc10 usdhc13 flex...
Page 10
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 10 Ø 150/100 with reduction usvk13 on the aplliance appliance a (min) b (min) b (max) restriction hr+ 850 v / 550 v 1,25m wall exit a+0,5m Ø 75 850 dv / 550 dv 1,25 wall exit a Ø 75 (a) Ø 200/130 in combinati...
Page 11
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 11 Ø 200/130 appliance a (min) b (min) restriction hr+ b (max) 850 v / 550 v 1 wall exit Ø 75 a+8m 850 dv / 550 dv 11 wall exit Ø 75 a+7m 3° important : be carefull every horizontal part does not have an nega...
Page 12
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 12 fig. 5 roof exit with 90° bends caution : if the vertical lenght is over 3 meter longer than the horizontal lenght, you will need to place a reduction ring of Ø 60. Appliance Ø 150/100 and Ø 200/130 850 v ...
Page 13
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 13 pic. 1 pic. 2 pic. 3 referential distances in regards to finishing the mantlepiece a very essential point when setting up the luna gold is that the distance has to be respected inbetween fireplace and the ...
Page 14
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 14 the enclosure of the furnace must be provided with ventilation grills or openings allowing for the elimination of heat by con- vection. It is possible to have a convection kit fitted with the furnace. This...
Page 15
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 15 out in out in or inlet inlet design grill ( outlet ) 2 dm² 4 dm².
Page 16
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 16 you have to connect at least two appertures situated at the top of the appliance. Ures. The stove may not be placed direct on the stove may not be placed direct on the floor, wthout the feets. This to allo...
Page 17
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 17 7. Mounting a 3-sided frame pic 1 3-sided frame 2,25cm 4 sided frame (lower piece) sideframe upper frame fireplace is delivered standard with 4sided frame 3,5cm, an upper and 2 sideframes ( see pic. 2 ) be...
Page 18
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 18 8. Putting in place the logs, diamond, sapphire and white stones • please check that the pilot light is switched off and that the furnace has cooled down. • move the window to the front by pulling it. The ...
Page 19
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 19 1 2 3 4 5 6 7 8 9 10 11 12 13 14 1 2 11 10 12 3 1 4 5 8 6 7 9 14 13 luna 850v / 850dvgas.
Page 20
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 20 luna 850v 850dv gas.
Page 21
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 21 luna 850 v gas / gaz only for 850v with two burners seulement pour appareil 850v avec deux brûleurs en escaliers.
Page 22
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 22 1 2 3 4 5 6 7 8 1 2 3 4 5 6 7 8 luna 550 v / 550 dv gas.
Page 23
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 23 1 2 3 4 5 6 7 8 luna 550 v / 550 dv gas.
Page 24
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 24 9. First-time use the masonry and plaster surrounding a recently installed furnace hold a great deal of moisture, which must first evaporate before commissioning the appliance. If not, the plaster may crac...
Page 25
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 25 11. Startpilot the m-design gas appliance are provided with “constant startpilot”. After the first use or when the winterperiod is coming and you use the fireplace daily, you must let the startpilot switch...
Page 26
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 26 13. Specification sheet type of gas natural gas butane-propane / lpg category i 2h i 2l i 2e+ i 2e i 3+ i 3b/p category g25 g20 g31 g30 type c 11 , c 31 , c 31s c 11 , c 31 , c 31s c 11 , c 31 , c 31s c 11...
Page 27
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 27 type of gas natural gas butane-propane / lpg category i 2h i 2l i 2e+ i 2e i 3+ i 3b/p category g25 g20 g31 g30 type /type c 11 , c 31 , c 91 c 11 , c 31 , c 91 c 11 , c 31 , c 91 c 11 , c 31 , c 91 entry ...
Page 28
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 28 luna 850 v gold gas * connection gas on the left side * * 850v with one burner ( saphir, diamon, white stones ) 850v with two burner ( woodset ).
Page 29
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 29 luna 850 dv gold gas * * connection gas on the left side.
Page 30
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 30 luna 550 v gold gas * * connection gas on the left side.
Page 31
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 31 luna 550 dv gold gas * connection gas on the left side *.
Page 32
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 32 min. Distance between appliance and maconery : 4cm x = inside measurement frame ( finished size ) y = measurment from underneath 4th side frame till upper side frame above window 3 mm = thickness frame 2 m...
Page 33
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 33 min. 4cm min. 5mm inlet convection: obliged ! Example how to mount without a 4-sided frame two flexible tubes can be connected to one design grid ( 2 connections ) connecting flex tubes 700h/1000h/1150h/13...
Page 34
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 34 x = 3,5 cm x = 7 cm x = 10,5 cm onderlat / baguette 35 70 105 z x detail z 4th -side frame type a 700h 623 1000h/dh 923 1150h/dh 1073 1300h/dh 1223 1600h/dh 1523 1900 h 1823 550v/dv 473 850v/dv 773 type a ...
Page 35
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 35 14. Spare parts x = 850v, 550v.
Page 36
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 36 14. Spare parts x = 850dv, 550dv.
Page 37
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 37 15. Guarantee this page is your warranty card. The guarantee is only valid for faults caused by construction defects or defects in the parts used to build the furnace. M-design offers a 12 month guarantee ...
Page 38
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 38 mn luna 550v gold serie n° 0461/2010 pn 0461bs0880 nl : raadpleeg eerst zorgvuldig het instructieboekje voordat u het toestel plaatst en in gebruik neemt.De installatie van dit toestel dient te geschieden ...
Page 39
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 39 mn luna 850v gold serie n° 0461/2010 pn 0461bs0880 nl : raadpleeg eerst zorgvuldig het instructieboekje voordat u het toestel plaatst en in gebruik neemt.De installatie van dit toestel dient te geschieden ...
Page 40
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 40 17. Ce certification.
Page 41
Instruction for installation and use - luna 550v - 550dv - 850v - 850dv gold - gas m-design 41.