L25-001 rev 1 (11/02) magikitch’n a maytag company 180 penn am drive quakertown, pennsylvania 18951-2435 usa telephone 800-441-1492 fax: (215) 538-3644 website: www.Magikitchn.Com pn 31-01-10374 © 2000– magikitch’n 600 series gas broiler installation – operation - maintenance magikitch’n p.O. Box 50...
L25-001 rev 1 (11/02) notice: the instructions to be followed in the event the odor of gas is detected are to be posted in a prominent location. These instructions shall be obtained from the local gas supplier. Keep area around appliances free and clear from combustibles. For installation in noncomb...
L25-001 rev 1 (11/02) table of contents 1. Installation 2. Gas hook up 3. Gas settings 4. Lighting instructions 5. Initial set up 6. Cleaning and maintenance 7. Important instructions recap 8. Parts illustration 9. Parts list 10. Warranty.
L25-001 rev 1 (11/02) 1. Installation units are to be installed in non-combustible locations only to utilize a 0” minimum clearance to non-combustible construction. Not approved for installations in combustible constructions. This installation must conform to local codes. In the absence of local cod...
L25-001 rev 1 (11/02) suggest a dow corning®, ge® or permatex® silicone ‘rtv’ adhesive sealant or equivalent. (see nsf basic criteria c-2 for details). 2. Gas hook up an adequate gas supply is imperative. Undersized lines or low-pressures will restrict the volume of gas required for satisfactory per...
L25-001 rev 1 (11/02) 3. Gas settings regulator pressure must be measured and adjusted before the unit goes into service, following installation and when operational performance is in question. A soft blue flame, just short of a yellow tip, gives the best results; combustion air can be adjusted by o...
L25-001 rev 1 (11/02) smb 600 series models without safety pilot a.) turn all burners to off. B.) remove the top grid(s). D.) turn the runner tube valve to on. E.) light the runner tube through the gap in the front of the coal support as shown. Note: if the runner tube does not light, wait a few sec...
L25-001 rev 1 (11/02) rmb 600 series -s models with safety pilot 1. Turn all burners to off. 2. Remove the top grid. 3. Remove a radiant. 4. Turn the shut off valve to on. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15–30 seconds. Light the runner tube. Do not release t...
L25-001 rev 1 (11/02) 5. Initial set-up all models proper set up of the broiler - after the installation of the broiler by a qualified technician, a thorough cleaning is necessary. After this cleaning, be sure the broiler is set up properly. Top grid - your top cooking grid has two positions, either...
L25-001 rev 1 (11/02) rmb 600 series models stainless steel radiant - it is very important that the stainless steel radiants are placed over the burners. This will provide radiant heat and protect the burners from dripping grease. Preheating - it is necessary to preheat a cold broiler each time befo...
L25-001 rev 1 (11/02) coals - use only magicoals supplied by magikitch'n. Do not use lava rock or other replacement coals. They do not perform as well or last as long as the magicoals that were designed for this application. Place the coals evenly across the surface of the coal support. Do not pile ...
L25-001 rev 1 (11/02) 6. Cleaning and maintenance daily cleaning and maintenance top grid - the top grid can be cleaned in numerous ways. The recommended procedure is to remove the grid and clean the frame, tubes and angles on front, sides and back with steel wool. The rods need only be scraped free...
L25-001 rev 1 (11/02) 8. Typical 600 series illustration ( model rmb 636 shown ) note: your unit may vary from this typical diagram..
L25-001 rev 1 (11/02) 8. Typical smb 600 series illustration (model smb 636 shown) note: your unit may vary from this typical diagram..
L25-001 rev 1 (11/02) 9. Accessory / parts list for rmb/smb 600 series models not all parts are illustrated, nor are all parts are listed. If you need a part that is not listed here, call magikitch'n for a quote. Always have your model and unit serial numbers available when phoning or ordering. Thes...
L25-001 rev 1 (11/02) 10. Warranty original equipment warranty (for u.S. And canada) magikich’n warrants to each original buyer that its electrically-heated or gas-fired charbroilers / outdoor grills will be free from defects in material and workmanship for the period specified below. Magikitch’n’s ...
L25-001 rev 1 (11/02) card is not returned, then the warranty period will be deemed to have commenced on the date of invoice for the particular oven to the dealer or other intermediate customer, which may have the effect of reducing substantially the duration of the warranty period. Magikitch’n p.O....
L25-001 rev 1 (11/02) p.O. Box 501 concord nh 03302-0501 509 route 3a bow nh 03304 800-258-3708 603-225-6684 fax 603-225-8497 www.Pitco.Com.
