600 series gas broiler installation – operation - maintenance magikitch'n p.O. Box 501 concord nh 03302-0501 603-225-6684 fax 603-225-8497 www.Magikitch'n.Com l25-001 r5 (2/15).
To the purchaser, owner and store manager please review these warnings prior to posting them in a prominent location for reference. To the purchaser post in a prominent location the instructions to be followed in the event that an operator smells gas. Obtain this information from your local gas supp...
Australian addendum to l25-001 r3 nominal gas consumption of models: (fm, cm, apm, apl) 624 66 mj/h (fm, cm, apm, apl) 648 165 mj/h (fm, cm, apm, apl) 630 99 mj/h (fm, cm, apm, apl) 660 214.5 mj/h (fm, cm, apm, apl) 636 115.5 mj/h (fm, cm, apm, apl) 672 264 mj/h test point pressures: natural gas 1.0...
L25-001 r5 (2/15) table of contents australian addendum to l25‐001 r3 ................................................................................................................... 3 installation ......................................................................................................
L25-001 r5 (2/15) installation units are to be installed in non-combustible locations only to utilize a 0" (0 mm) minimum clear- ance to non-combustible construction. Not approved for installations in combustible constructions. In north america this installation must conform to local codes. In the a...
L25-001 r5 (2/15) gas hook up an adequate gas supply is imperative undersized lines or low-pressures will restrict the volume of gas required for satisfactory performance. A steady supply pressure between 7'' and 8'' w.C. (1.75 and 2 kpa) for natural gas or 11'' to 12" w.C. (2.75 to 3.0 kpa) for pro...
L25-001 r5 (2/15) gas settings regulator pressure must be measured and adjusted before the unit goes into service, following installation and when operational performance is in question. A soft blue flame, just short of a yellow tip, gives the best results; combustion air can be adjusted by opening ...
L25-001 r5 (2/15) smb 600 series models without safety pilot a.) turn all burners to off. B.) remove the top grid(s). D.) turn the runner tube valve to on. E.) light the runner tube through the gap in the front of the coal support as shown. Note: if the runner tube does not light, wait a few seconds...
L25-001 r5 (2/15) off shut-off valve on rmb 600 series -s models with safety pilot 1. Turn all burners to off. 2. Remove the top grid. 3. Remove a radiant. 4. Turn the shut off valve to on. 5. Press and hold the reset (blue) button on the safety pilot valve. Wait 15-30 seconds. Light the runner tube...
L25-001 r5 (2/15) initial set-up all models proper set up of the broiler - after the installation of the broiler by a qualified technician, a thorough cleaning is necessary. After this cleaning, be sure the broiler is set up properly. Top grid - your top cooking grid has two positions, either flat o...
L25-001 r5 (2/15) rmb 600 series models stainless steel radiant - it is very important that the stainless steel radiants are placed over the burners. This will provide radiant heat and protect the burners from dripping grease. Preheating - it is necessary to preheat a cold broiler each time before c...
L25-001 r5 (2/15) coals - use only magicoals supplied by magikitch'n. Do not use lava rock or other replacement coals. They do not perform as well or last as long as the magicoals that were designed for this application. Place the coals evenly across the surface of the coal support. Do not pile them...
L25-001 r5 (2/15) cleaning and maintenance daily cleaning and maintenance top grid - the top grid can be cleaned in numerous ways. The recommended procedure is to remove the grid and clean the frame, tubes and angles on front, sides and back with steel wool. The rods need only be scraped free of all...
L25-001 r5 (2/15) typical 600 series illustration ( model rmb 636 shown ) note: your unit may vary from this typical diagram..
L25-001 r5 (2/15) typical smb 600 series illustration (model smb 636 shown) note: your unit may vary from this typical diagram..
L25-001 r5 (2/15) accessory/ parts list for rmb / smb 600 series models not all parts are illustrated, nor are all parts are listed. If you need a part that is not listed here, call magikitch'n for a quote. Always have your model and unit serial numbers available when phoning or ordering. These part...
Original equipment warranty (for u.S. And canada) magikitch’n warrants to each original buyer that its gas‐fired charbroilers / outdoor grills* / griddles / fryers will be free from defects in material and workmanship for the period specified below. Magikitch’n’s obligation under this warranty shall...
In the event of problems with or questions about your order, please contact the magikitch'n factory at: (603) 225-6684 world wide www.Magikitchn.Com in the event of problems with or questions about your equipment, please contact the magikitch'n authorized service and parts representative (asap) cove...
