1. DL manuals
  2. Majestic
  3. Outdoor Fireplace
  4. Vermont Castings ODSHR42
  5. Homeowner's Installation And Operating Manual

Majestic Vermont Castings ODSHR42 Homeowner's Installation And Operating Manual

Other manuals for Vermont Castings ODSHR42: Homeowner's Installation & Operating Manual
Manual is about: ODSHR Series Outdoor Woodburning Fireplace

Summary of Vermont Castings ODSHR42

  • Page 1

    1384 shr cover 5/27/99 djt homeowner's installation and operating manual do not discard this manual: retain for future use. 20002264 10/06 rev. 17 model: odshr42 underwriter's laboratories report no. Mh20546 odshr series outdoor woodburning fireplace.

  • Page 2: Table of Contents

    2 odshr outdoor woodburning fireplace 20002264 please read this manual before installing and using fireplace. Important: read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. Saf...

  • Page 3: Safety Information

    3 odshr outdoor woodburning fireplace 20002264 safety information description the odshr series (super hearth) fireplace is a clean- faced, solid fuel, woodburning fireplace. Precautions cfm corporation fireplaces and component parts have been highly tested and will operate safely when installed in acco...

  • Page 4

    4 odshr outdoor woodburning fireplace 20002264 minimum rough opening height 42" (1067 mm) 52 " (1327 mm) 44" (1118 mm) " " " (610 mm) " (189 mm) 13 " dia. Minimum rough opening width 53 " (1365 mm) minimum rough opening depth 62 " (1578 mm) " (2232 mm) " ...

  • Page 5

    5 odshr outdoor woodburning fireplace 20002264 fp554a sh series 1/28/99 djt chase installation insulation methods shown are optional for cold climate, not a requirement for unit operation or exterior installation . Fp554a fig. 4 fireplace and chase parts identification. Termination cap storm collar p...

  • Page 6

    6 odshr outdoor woodburning fireplace 20002264 chimney requirements - offset installations 0 0 0 0 0 3" 11" 1 0 0 0 0 8 ¹⁄₄ " 20" 0 1 0 0 0 11 ¹⁄₄ " 25 ¹⁄₄ " 2 0 0 0 0 13 ¹⁄₂ " 29 ¹⁄₄ " 1 1 0 0 0 16 ¹⁄₂ " 34 ¹⁄₄ " 0 0 1 0 0 20 ¹⁄₄ " 40 ³⁄₄ " 2 1 0 0 0 21 ³⁄₄ " 43 ¹⁄₂ " 0 0 0 1 0 26 ¹⁄₄ " 51 ¹⁄₄ " 0 ...

  • Page 7: Planning Information

    7 odshr outdoor woodburning fireplace 20002264 planning information the ten foot rule major u.S. Building codes specify a minimum chimney height above the roof top. The “ten foot rule” is a fire safety rule and not a draft rule. To ensure proper draft, it is recommended that you always meet or exceed...

  • Page 8: Installation

    8 odshr outdoor woodburning fireplace 20002264 chimney supports the chimney system is supported by the fireplace for vertical chimney heights less than 30' (9 m) above the hearth. Chimney supports are required if the vertical height exceeds 30' (9 m) with 11cf chimneys. Locate chimney supports at cei...

  • Page 9

    9 odshr outdoor woodburning fireplace 20002264 locate center point of the chimney on ceiling as though a straight up chimney arrangement is to be used. Mea- sure your offset dimension from straight up chimney center point on ceiling. Ceiling chimney hole/ possible obstructions the size of the hole i...

  • Page 10

    10 odshr outdoor woodburning fireplace 20002264 cutting the hole cover fireplace collar opening and cut proper sized chimney hole in chimney. Framing the ceiling hole frame the ceiling chimney hole as shown in figure 13. It is good practice to use framing lumber that is the same size as the ceiling j...

  • Page 11

    11 odshr outdoor woodburning fireplace 20002264 positioning, safety strips, securing the fireplace slide fireplace into position. Lift the fireplace front slightly and slide the metal safety strips under front bottom edge about 1 ¹⁄₂ " (38 mm), allowing the remainder to extend in front of firebox. Over...

  • Page 12

    12 odshr outdoor woodburning fireplace 20002264 installing the chimney system start by attaching the first chimney section to the collar on top of the fireplace. Install the pipe as pictured in figure 17. When you get a good lock, you will hear the pipe clearly snap together. Once sections are snap-lo...

  • Page 13

    13 odshr outdoor woodburning fireplace 20002264 firestop spacers are not available for, nor are they required on, vertical walls. The cfm corporation chimney components have been tested and approved with the area where the outer pipe slides through the firestop spacer sealed with a noncombustible cau...

  • Page 14

    14 odshr outdoor woodburning fireplace 20002264 finish wall finish the wall with material of your choice. Do not install a combustible mantel shelf less than 12" (305 mm) from the top of the fireplace opening. Do not install a mantel face plate less than 6" (154 mm) from top of fireplace opening. (fig...

  • Page 15

    15 odshr outdoor woodburning fireplace 20002264 fp531 surround flush with finish wall 12/20/01 djt 12" (305mm) max. 12" (305mm) min. * 1 ¹⁄₂ " 12" (305mm) max. 12" (305mm) min. 1 ¹⁄₂ " 6" (159mm) min. 1" mantel clearance - no noncombustible facing material combustible mantel and trim finished wall h...

  • Page 16

    16 odshr outdoor woodburning fireplace 20002264 side wall protection adjacent combustible side walls that are within dimen- sions shown in figure 25 of fireplace opening must be protected with cfm corporation wall shield model sp40 or a specifically built wall shield described in figure 26. The specia...

  • Page 17

    17 odshr outdoor woodburning fireplace 20002264 common materials and factors material k* r minimum thickness eh2416 common brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** (cfm corporation) r value is for inch. * units of k = btu/sq ft/hr/˚f/in ** thickness of listed material fp533add addendum 6/...

  • Page 18

    18 odshr outdoor woodburning fireplace 20002264 installing line for gas logs cfm corporation fireplaces are designed to accept a 1/2 inch gas line for installation of an approved gas ap- pliance. (cfm corporation manufactures a wide variety of gas logs for use in majestic fireplaces units.) be sure t...

  • Page 19

    19 odshr outdoor woodburning fireplace 20002264 * two (2) required ** four (4) required cfm corporation reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. 2264pts odshr replacement parts 1/5/00 djt 1 2 5 7 6...

  • Page 20: Accessories

    20 odshr outdoor woodburning fireplace 20002264 the following accessories for this appliance are available from your local cfm corporation products distributor. Should you need additional information beyond what your distributor can furnish, contact: cfm corporation, 2695 meadowvale blvd., mississau...

  • Page 21

    21 odshr outdoor woodburning fireplace 20002264 accessory description model no. Extended round top chimney sections chimney elbows top housing with upper baffle chimney reducer kit attic insulation shield for use with type "11cf" chimney sys- tems. Used to terminate chimney at top of chase. Adapter k...

  • Page 22

    22 odshr outdoor woodburning fireplace 20002264.

  • Page 23

    23 odshr outdoor woodburning fireplace 20002264 limited warranty & 30 year protection plan for majestic fireplaces pre-engineered fireplace systems cfm corporation warrants its pre-engineered fireplace (“fireplace”) and the cfm corporation-supplied firegrate, glass doors, outside air system, fan moto...

  • Page 24

    2695 meadowvale blvd. • mississauga, ontario, canada l5n 8a3 800-668-5323 • www.Cfmcorp.Com cfm corporation.