- DL manuals
- Majestic
- Outdoor Fireplace
- Vermont Castings ODSHR42
- Homeowner's Installation & Operating Manual
Majestic Vermont Castings ODSHR42 Homeowner's Installation & Operating Manual
Summary of Vermont Castings ODSHR42
Page 1
Odshr series outdoor woodburning fireplace homeowner's installation & operating manual do not discard this manual: retain for future use. 20002264 2/03 rev. 9 model: odshr42 2264 underwriter's laboratories report no. Mh20546.
Page 2: Safety Information
2 odshr series 20002264 safety information please read this manual before installing and using fireplace. Important: read all instructions and warnings carefully before starting installation. Failure to follow these instructions may result in a possible fire hazard and will void the warranty. Descri...
Page 3
3 odshr series 20002264 rough opening height 42" 52 ¹⁄₄ " 44" ³⁄₄ " ³⁄₄ " 24 " 7⁷⁄₁₆ " 13 ³⁄₈ " dia. Rough opening width 53 ³⁄₄ " rough opening depth 62 ¹⁄₈ " 62 ¹⁄₈ " 87⁷⁄₈ " 10³⁄₈ " 26³⁄₄ " 35 " 48 ¹⁄₄ " 44⁹⁄₁₆ " ³⁄₄ " ³⁄₄ " ³⁄₄ " 12 ¹⁄₂ " 11" dia. 15 ⁵⁄₈ " 13 ³⁄₄ " 7 ³⁄₄ " 14 ¹⁄₂ " outside air ga...
Page 4
4 odshr series 20002264 note: if the fireplace is a freestanding unit, it must be located a minimum of 10' from the opening of the firebox to a combustible structure. A minimum height of 6'- 4" measured from the base of the firebox to the bottom of the termination cap is permitted. 10' min. 6'4" min...
Page 5
5 odshr series 20002264 chimney requirements - offset installations 0 0 0 0 0 3" 11" 1 0 0 0 0 8 ¹⁄₄ " 20" 0 1 0 0 0 11 ¹⁄₄ " 25 ¹⁄₄ " 2 0 0 0 0 13 ¹⁄₂ " 29 ¹⁄₄ " 1 1 0 0 0 16 ¹⁄₂ " 34 ¹⁄₄ " 0 0 1 0 0 20 ¹⁄₄ " 40 ³⁄₄ " 2 1 0 0 0 21 ³⁄₄ " 43 ¹⁄₂ " 0 0 0 1 0 26 ¹⁄₄ " 51 ¹⁄₄ " 0 1 1 0 0 28 ¹⁄₂ " 55 ¹⁄₄...
Page 6: Planning Information
6 odshr series 20002264 planning information the ten foot rule major u.S. Building codes specify a minimum chimney height above the roof top. The “ten foot rule” is a fire safety rule and not a draft rule. To ensure proper draft, it is recommended that you always meet or exceed the “ten foot rule,” ...
Page 7: Installation
7 odshr series 20002264 chimney supports the chimney system is supported by the fireplace for vertical chimney heights less than 30 feet above the hearth. Chimney supports are required if the vertical height exceeds 30 feet with 11cf chimneys. Locate chimney supports at ceiling holes or other struct...
Page 8
8 odshr series 20002264 locate center point of the chimney on ceiling as though a straight up chimney arrangement is to be used. Measure your offset dimension from straight up chim- ney center point on ceiling. Ceiling chimney hole/ possible obstructions the size of the hole in ceiling will vary wit...
Page 9
9 odshr series 20002264 cutting the hole cover fireplace collar opening and cut proper sized chimney hole in chimney. (fig. 10 & 11) framing the ceiling hole frame the ceiling chimney hole as shown in figure 11. It is good practice to use framing lumber that is the same size as the ceiling joists; t...
Page 10
10 odshr series 20002264 4. Positioning, safety strips, securing the fireplace slide fireplace into position. Lift the fireplace front slightly and slide the metal safety strips under front bottom edge about 1 ¹⁄₂ inches, allowing the remainder to extend in front of firebox. Overlap strips at least ...
Page 11
11 odshr series 20002264 5. Installing the chimney system start by attaching the first chimney section to the collar on top of the fireplace. Install the pipe as pictured in figure 14. When you get a good lock, you will hear the pipe clearly snap to- gether. Once sections are snap-locked in place, i...
Page 12
12 odshr series 20002264 firestop spacers are not available for, nor are they required on, vertical walls. The majestic fireplaces' chimney components have been tested and approved with the area where the outer pipe slides through the firestop spacer sealed with a noncombustible caulk if desired, or...
Page 13
13 odshr series 20002264 7. Finish wall finish the wall with material of your choice. Do not install a combustible mantel shelf less than 12 inches above the front opening. If a combustible material is used below a flat mantel shelf, consult your local building codes for minimum clearance from top o...
Page 14
14 odshr series 20002264 stud 2 x 4 finished header covered wall ledge bracket finished wall noncombustible decorative facing must be sealed with noncombustible material surround fp1167 fig. 20 facing on fireplace surround flush with finished wall. Side wall protection adjacent combustible side wall...
Page 15
15 odshr series 20002264 8. Hearth installation a hearth extension is required to protect a combustible floor in front of the fireplace. See figure 24 for mini- mum dimensions and mounting detail. Note: hearth extension must not cover the air inlet opening of a fireplace. The hearth extension descri...
Page 16
16 odshr series 20002264 common materials and factors material k* r minimum thickness eh2416 common brick 0.458 5.0 1.09 0.50 in.** 0.10 5.46 in.** (majestic products company) r value is for ¹⁄₂ inch. * units of k = btu/sq ft/hr/˚f/in ** thickness of listed material fp533add fig. 25 hearth extension...
Page 17
17 odshr series 20002264 from inside the fireplace, locate the knockout on the firebrick -- be sure you are on the appropriate or "gas line" side of the fireplace. Using a flat bladed screw- driver or small chisel and hammer, carefully tap around the knockout until it loosens and falls out. Install ...
Page 18
18 odshr series 20002264 2264 * two (2) required ** four (4) required vermont castings, majestic products reserves the right to make changes in design, materials, specifications, prices and discontinue colors and products at any time, without notice. 1 2 5 7 6 4 3 12 11 8 10 9a,b 13 ref. Description...
Page 19: Accessories
19 odshr series 20002264 the following accessories for this appliance are available from your local vermont castings, majestic products products distributor. Should you need additional information beyond what your distributor can furnish, contact: vermont castings, majestic products, 410 admiral blv...
Page 20
20 odshr series 20002264 accessory description model no. Extended round top chimney sections chimney elbows top housing with upper baffle chimney reducer kit for use with majestic type "11cf" chim- ney systems. Used to terminate chimney at top of chase. Adapter kit included. Flashing not included. U...
Page 21
21 odshr series 20002264 limited warranty & 30 year protection plan for vermont castings, majestic products pre-engineered fireplace systems vermont castings, majestic products warrants its pre-engineered fireplace (“fireplace”) and the vermont castings, majestic products- supplied firegrate, glass ...
Page 22
22 odshr series 20002264 © vermont castings, majestic products 410 admiral blvd. • mississauga, ontario, canada l5t 2n6 • 905-670-7777 www.Majesticproducts.Com • www.Vermontcastings.Com vermont castings, majestic products.