1. DL manuals
  2. Megamaster
  3. Grill
  4. Blaze 200
  5. Operating Instructions Manual

Megamaster Blaze 200 Operating Instructions Manual

Manual is about: 1185/18/RSA-08/A

Summary of Blaze 200

  • Page 1

    Assembly & operating instructions assembly & operating instructions important: read these instructions for use carefully so as to familiarize yourself with the appliance before connecting it to its gas container. Keep these instructions for future reference lpgsasa permit number (1185/18/rsa-08/a) w...

  • Page 2

    Table of contents lighting instruction. . . . . . . . . . . . . . . . . . . . 27 safety instruction . . . . . . . . . . . . . . . . . . . . . 2-7 care and maintenance . . . . . . . . . . . . . . . . . Trouble shooting . . . . . . . . . . . . . . . . . . . . . Grill cooking chart . . . . . . . . . . ...

  • Page 3

    Danger safety instruction 1. Never operate this appliance unattended. 2. Never operate this appliance within 10 ft (3 m) of any structure, combustible material or other gas cylinder. 3. Never operate this appliance within 25 ft (7.5 m) of any flammable liquid. F f 4. Do not fill cooking vessel beyon...

  • Page 4

    Warning do not try lighting this appliance without reading the “lighting instructions” section of this manual caution: beware of flashback caution: spiders and small insects occasionally safety instruction grill installation codes check your local building codes for the proper lighting instructions ...

  • Page 5

    Safety instruction lp-gas supply system • storage of an outdoor cooking gas appliance indoors is permissible only if the cylinder is disconnected and removed from the outdoor cooking gas appliance. • when your gas grill is not in use the gas must be • if the information is not followed exactly, a fi...

  • Page 6

    Proper placement and clearance of grill • never use your gas grill in a garage, porch, shed, breezeway or any other enclosed area. Warning your grill will get very hot. Never lean over the cooking area while using your grill. Do not touch cooking surfaces, grill housing, lid or any other grill parts...

  • Page 7

    Do not heat unopened food containers. A build-up of pressure may cause the containers to burst. Use a covered hand when opening the grill lid safety instruction keep the area surrounding the grill free from combustible materials including, fluids, trash, and vapors such as gasoline or charcoal light...

  • Page 8

    Package contents list b. Bottom panel----1pc c. Side panel----3pcs d. Side panel right, top ----1pc a. Firebox assembly----1pc f. Cart leg front, left----1pc g. Cart leg rear, left----1pc h. Cart leg front, right ----1pc e. Front panels----2pcs i. Cart leg rear, right----1pc j. Side shelf, left----1...

  • Page 9

    Z. Side tube burner----1pc aa. Control knob----1pc ab. Pulse igniter module ----1pc y. Cart caster insert----2pcs ad. Temperature gauge ----1pc ac. 1.5 volt “aa” size alkaline battery----1pc ae. Grease tray latch ----1pc af. Temperature gauge seat ----1pc ag. Side burner igniter wire ----1pc 9.

  • Page 10

    Hardware contents ref# description specification qty truss head screw h1 5/32’’ x 10mm 10pcs. H2 truss head screw 1/4’’ x 12mm 14pcs. Nut h3 1/4‘’ 2pcs. H4 flat washer (aluminum) m4 4pcs. Flat washer h5 m5 2pcs. H6 flat washer (aluminum) m6 6pcs. Fl t w h (bl k) h7 flat washer (black) m6 2pcs. Befor...

  • Page 11

    Explode view 04 01 03 02 05 56 59 55 06 02 60 61 07 61 52 53 54 57 21 08 10 09 07 58 47 51 48 49 50 20 19 22 42 43 46 44 41 45 12 15 14 18 17 13 16 11 40 21 41 39 37 38 18 24 28 27 26 30 39 24 25 23 29 29 31 30 33 34 11 23 26 32 33 35 36 34 34.

  • Page 12

    No . Part (description) warranty coverage (year) qty no . Part (description) warranty coverage (year) qty 1 main lid 1 1 32 cart leg front, right 1 1 2 main lid screw 1 2 33 wheel 1 2 3 temperature gauge 1 1 34 wheel cap 1 2 3 temperature gauge 1 1 34 wheel cap 1 2 4 temperature gauge seat 1 1 35 cy...

  • Page 13

    Assembly instructions 1. Cart assembly a) place the cart caster inset (y) into the cart leg front left (f) and cart leg rear left (g). As shown in fig. 1. Fig. 1 f g y b) loosen but do not remove the eight screws that were pre-assembled on the cart leg front left (f) and cart leg rear left (g). Atta...

  • Page 14

    Fig. 4 2. Bottom panel assembly a) loosen but do not remove the screws that were pre- assembled on the side of the bottom panel (b), align the holes on the cart leg front left (f) and cart leg rear left (g), then place the cart legs onto the screws that were loosened in the bottom panel (b). As show...

  • Page 15

    4. Triangle bracket assembly a) loosen but do not remove four screws on bottom panel (b), two screws on cart leg rear left (g) and two screws on cart leg rear right (i). Align the holes of the triangle brackets with the screws in the bottom panel (b) and cart leg rear left (g) and cart leg rear fig....

  • Page 16

    7. Firebox assembly note: the firebox assembly is heavy and will require two or more people to lift and position onto grill cart. Failure to do so may result in injury. Be sure to remove all packaging material during assembly. Fig. 9 a 4xh2 a) remove the firebox assembly (a) from the carton and care...

  • Page 17

    Fig. 11 9. Side shelf left assembly a) loosen but do not remove two screws which were pre- assembled on left side of firebox (a). Align the holes and secure the side shelf left (j) from inside firebox by using 3pcs truss head screws (h2) and 3pcs flat washers (h6) to attach the side shelf left (j) t...

  • Page 18

    Fig. 13 a 10. Side burner right assembly a) loosen but do not remove two screws which are pre- assembled on right side of firebox (a). Align the holes and secure the side burner right (k) from inside firebox by using 3pcs truss head screws (h2) and 3pcs flat washers (h6) to attach the side burner ri...

  • Page 19

    Fig. 16 d) insert the ignition wires to the pulse ignition module (ab) located on the right side burner control panel. As shown in fig.16. 12. Side burner installation ab fig. 17 a) loosen the screws which from underneath the side burner to remove two screws which are pre-assembled on the bottom of ...

  • Page 20

    Fig. 19 c) loosen the screws which pre-assembled on the side burner gas valve then align the screws to the valve with the large side of the holes on the bezel, fix with vertical gourd holes, then tighten the screws. As shown in fig. 19. Fi 20 d) insert side burner control knob (aa) into the valve st...

  • Page 21

    Fig. 23 c) then attached grease cup support bracket a (u) to grease box support bracket b (v) by using 2pcs truss head screws (h1). As shown in fig.23. Note: make sure the grease cup support bracket a (u) is attached in the right position, as show in fig.23. V 2xh1 u d) install the grease tray (l) f...

  • Page 22

    Fig. 26 b） insert legs of warming rack (o) into the holes on the top of firebox side panels. Place side burner cooking grid (p) into the side burner. As shown in fig.26. O p p fig. 27 15. Liquid propane tank installation from rear of grill place the liquid propane gas cylinder into the bottom panel ...

  • Page 23

    Gas hook - up never connect an unregulated gas supply line to the appliance. Use the regulator/hose assembly supplied. This is a lp gas configured grill. Do not attempt to use a natural gas supply, the grill has not been regulator connection g pp y g approved for natural gas use. Total gas consumpti...

  • Page 24

    Installer final check list 9 minimum clearance from sides and back of unit to combustible construction, 24 inches (61cm) from sides and 24 inches (61cm) from back 9 all internal packaging removed. 9 knobs turn freely. User, please retain this manual for future reference. Lp gas cylinder cautions a) ...

  • Page 25

    Leak testing continued cautions place dust cap on cylinder valve outlet when the cylinder is not in use. Only install the type of dust cap on the cylinder valve outlet that is provided with the cylinder valve. Other types of caps or plugs may result in leakage of lp gas . The gas must be turned off ...

  • Page 26

    Operating instructions general use of the grill each main burner is rated at 13,500 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. The igniter knobs are located on note: the hot grill sears the food, sealing i...

  • Page 27

    Grill lighting instructions continued flame characteristics check for proper burner flame characteristics. Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting. If any of these conditions exist call our customer service line if the flame is yellow visually check t...

  • Page 28

    Care and maintenance stainless steel there are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Specks of grease can gather on the surfaces of the stainless steel and bake on to the surface and i th f t f l i...

  • Page 29

    Trouble shooting spider and insect warning checking and cleaning burner/ venture tubes for insects and insect nests. A clogged tube can lead to a fire beneath the grill. Spiders and small insects occasionally spin webs or make nests in the grill burner tubes during transit and warehousing. These web...

  • Page 30

    Trouble shooting continued problem solution when attempting to light my grill, it will not light immediately. Make sure you have a spark while you are trying to light the burner (if no spark) ensure that the wire is connected to the electrode assembly. Clean wire (s) and / or electrode with rubbing ...

  • Page 31

    Grill cooking chart warning: to ensure that it is safe to eat, food must be cooked to the minimum internal listed in the table below. Usda* safe minimum internal temperatures fish 65 0 c fish 65 c pork 70 0 c egg dishes 70 0 c steaks and roasts of beef, veal or lamb 65 0 c ground beef, veal or lamb ...

  • Page 32

    This grill has a one (1) year limited warranty. The warranty period is valid from the date of purchase. Thi i bj t t t bl t d l i t f th d t limited warranty this is subject to correct assembly, use, storage and regular maintenance of the product. Please refer to page 12 of this manual for list of r...

  • Page 33: Blaze 400 Pro

    Blaze 400 pro for outdoor use only patio gas braai warning read and follow all safety, assembly, and use & care instructions in this guide before assembling and cooking with this grill. Failure to follow all instructions in this use & care guide may lead to fire or explosion, which could result in p...