1. DL manuals
  2. NAD
  3. Other
  4. M2 - CONNECTING A SUBWOOFER
  5. Service Manual

NAD M2 - CONNECTING A SUBWOOFER Service Manual

Other manuals for M2 - CONNECTING A SUBWOOFER: Specifications, Manual, Owner's Manual, Owner's Manual
Manual is about: C/AH Direct Digital Amplifier

Summary of M2 - CONNECTING A SUBWOOFER

  • Page 1

    L a u n a m e ci vr es l a u n a m e ci vr es m2 c/ah $%, / -- , ! 5 . ! - % #) 6 2% 3 © nad 2010 nad electronics international toronto m2 h a/ c direct digital amplifier direct digital amplifier m2 h a/ c direct digital amplifier.

  • Page 2: Contents

    Contents front panel/rear panel view 3 specifications 4 trouble shooting 5-6 schematic diagram 7-22 pcb layout 23-34 electrical parts list 35-63 exploded view 64-65 exploded view parts list 66 packing diagram 67 packing parts list 68 dismantling amplfiier . . . . . . . . . . . . . . . . . . . . . . ...

  • Page 3

    45"/%#: -&% 45"/%#: #6550/ 7"$66. '-603&4$&/5 %*41-":7'% 70-6.& $0"9 $0"9 015*$"- 015*$"- "&4 #"-"/$&% 4*/(-&&/%&% -001%*(*5"- 130$&4403 -001 .&/6 '30/51"/&-"/%3&"31"/&-7*&8 '30/5 1"/&-$0/530-4 #"-"/$&% 4*/(-&&/%&% %*(*5"- "6%*0$0"9 %*(*5"- "6%*0015*$"- %*(*5"- "6%*0 015*$"- -001015*$"- -001 065 015...

  • Page 4

    Analog input (balanced, single-ended) input impedance 36 kΩ//200 pf input sensitivity 296 mv (ref.100w) 418 mv (ref. Rated power) maximum input level 5.6 vrms (at -9db level trim setting) frequency response (a/d converter section) ±0.3db (ref. 10 hz - fs/2; fs = 48 khz, 96 khz, 192 khz) digital inpu...

  • Page 5

    Board check psua fuse701 yes check psua check dsp board 5vds right? Check ic700 ic701 yes check cable from psua to dsp no no amber led on? No power or power shuts off immediately 3v3 right? No no short circuit of 3v3? Replace u106 check u110 u301 u302 check ic523 check 108m mclk check u131 u118 u120...

  • Page 6

    Q617 q618 d607 rl601 yes display check amp main board "startup error" ? Yes check amp module board no no output relay open and b n41vl n41vr right? No no short circuit of n41vl&r? Replace ic506 ic510 check amp module check cable from dsp to analog board d602 d603 q603 q604 yes check amp feedback sig...

  • Page 7

    Modd 1 modb 2 moda 3 fst 4 fsr 5 sck t 6 sck r 7 vccs 8 gnds 9 hck t 10 vcclq 11 gndq 12 hck r 13 sdo0 14 vcchq 15 sdo1 16 sdo2i3 17 sdo3i2 18 sdo4i1 19 sdo5i0 20 vccs 21 gnds 22 ss 23 mosi 24 miso 25 sc k 26 hre q 27 pint 28 re se t 29 nc 30 v ccp 31 p cap 32 gndp 33 e xta l 34 v cch q 35 gndq 36 v...

  • Page 8

    Modd 1 modb 2 moda 3 fst 4 fsr 5 sck t 6 sck r 7 vccs 8 gnds 9 hck t 10 vcclq 11 gndq 12 hck r 13 sdo0 14 vcchq 15 sdo1 16 sdo2i3 17 sdo3i2 18 sdo4i1 19 sdo5i0 20 vccs 21 gnds 22 ss 23 mosi 24 miso 25 sc k 26 hre q 27 pint 28 re se t 29 nc 30 v ccp 31 p cap 32 gndp 33 e xta l 34 v cch q 35 gndq 36 v...

  • Page 9

    A1 1 gnd 2 a2 3 y2 4 vcc 5 y1 6 u301 nc7wz17 j302 scj349-sd 3v3i c305 4n7 r303 2k2j 232 gnd irini trigini trig in j301 scj351-ds sw c301 100n r305 10kj r306 6k8 ir in d302 4v7 1 2 3 s301 sw spdt trig sw soft clip on 1 2 3 s302 sw spdt on d303 4v7 c311 100n 3v3i softoni dgndi r304 2k7 q301 ksa1220 r3...

  • Page 10

    J205 rca1-bk j200 rca1-bk j202 xlr3f c200 1u r200 1m r242 100k r222 332r r259 56k2f c244 180pj c201 1u r201 1m r260 56k2f c204 1u r204 1m r263 56k2f c205 1u r205 1m r264 56k2f agnd agnd agnd j201 xlr3f c202 1u r202 1m r261 56k2f c203 1u r203 1m r262 56k2f agnd agnd + + - - 2 3 1 u202a lm4562 6 5 7 u...

  • Page 11

    D7 1 d6 3 vcc 2 vcc 4 vcc 6 d5 5 d4 7 gnd 8 d3 9 gnd 10 d2 11 gnd 12 d1 13 gnd 14 d0 15 test 16 wr 17 sel 18 rxd 19 busy 20 m400 20s207da1 vfdst b a 1 b 2 qa 3 qb 4 qc 5 qd 6 gnd 7 clk 8 clr 9 qe 10 qf 11 qg 12 qh 13 vcc 14 u403 hc164 a 1 b 2 qa 3 qb 4 qc 5 qd 6 gnd 7 clk 8 clr 9 qe 10 qf 11 qg 12 q...

  • Page 12

    K701 relay-spst d704 1n4001 c700 4n7/400v op711 pc817 c715 10n r721 220 r742 220 s702 c714 100p r743 2k op703 pc817 r741 680r 5vds dsgnd dsgnd q701 2sc2878 5vds r714 330r op705 pc817 120--240vac :t1al/250v 2 1 3 4 br700 2a800v d702 1n5822 op702 pc817 c703 10nf/400v c706 104 l702 d700 uf4006 dsgnd c7...

  • Page 13

    Cx800 330nf/250vac r800 330k l802 18uh r802 330k r801 330k c820 470uf/16v c823 100n -5vz cx802 330nf/250vac vi 1 vo 2 g 3 vd 4 u800 ka78r12 r822 10k c809 470uf/25v c837 100n vi 1 vo 2 g 3 vd 4 u801 ka78r08 r823 10k c829 100n d805 sk56c d803 sk56c d804 sk56c d806 sk56c l803 18uh l804 18uh c838 100n/1...

  • Page 14

    8v n53vl n41vl a2v5 8v n5v 5v 8v n2v5 n5v 2v5 8v 3v3 8v 1v2 5v p53vl n53vr p53vr 8v n53vr n41vr c3v3 n53vl dacp 8v /25v /63v /63v /63v for ic505 /63v /25v /63v /63v /16v /100v /100v /16v /2w fb501 bmb2a0300ln2 fb501 bmb2a0300ln2 r501 150 r501 150 ic505 lm337t ic505 lm337t o 2 i 3 adj 1 c521 100nf c5...

  • Page 15

    C3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 c3v3 ch3mc1 ch3mc0 mca mcx ch0mc0 ch0mc1 ch1mc0 ch1mc1 ch2mc0 ch2mc1 add extra length to this track to give total length 72mm ic513 nc7sv86p5x ic513 nc7sv86p5x 1 2 4 5 3 ic519 nc7sv86p5x ic519 nc7sv86p5x 1 2 4 5 3 c533 1uf c5...

  • Page 16

    D7 d6 d5 d4 d3 d2 d1 d0 1v2 3v3 3v3c 2v5 5v 3v3 5v 3v3 3v3c 2v5 1v2 ch1d3 ch1ts1 ch1d2 ch1ts0 ch1d1 ch1d0 ch0d3 ch0ts1 ch0d2 ch0ts0 ch0d1 ch0d0 ch2d0 ch2d1 ch2ts0 ch2d2 ch2ts1 ch2d3 ch3d0 ch3d1 ch3ts0 ch3d2 ch3ts1 ch3d3 sd1 wc1 gp0 gp1 gp2 gp3 key1 key0 wr cs0 ini cck0 spiint spid spics spibc opt0 c...

  • Page 17

    D7 d6 d5 d4 d3 d2 d1 a0 a1 a2 a3 a4 a5 a6 a7 a8 a9 a10 a11 a12 a13 a14 a15 a16 a17 a18 a19 a0 a1 a2 a3 a10 a4 a11 a5 a9 a6 a8 a7 a13 a12 a14 a15 a17 a16 a18 a19 d0 2v5 5v 3v3 pg0 cck0 key1 key0 mcb wr cs0 mca dn0 ini d1 d2 d3 d4 d5 d6 d7 d0 onetimeprogrammable m27c801-100b1 supply by zetex c581 1uf ...

  • Page 18

    A2v5 a2v5 a2v5 n2v5 a2v5 dacp n2v5 n2v5 n2v5 dacp dacp dacp ch0opfb ch0d1 ch0d0 ch0d2 ch0mc1 ch0d3 ch0mc0 ch0ts0 ch0ts1 ch0fb0 ch0fb1 c844khz ch0gndfb /0.1% /0.1% /0.1% r5j4 0 r5j4 0 r561 240 r561 240 c5a6 1uf c5a6 1uf c5a1 100pf c5a1 100pf r562 4.99meg r562 4.99meg r577 0 r577 0 c584 100pf c584 100...

  • Page 19

    A2v5 a2v5 dacp a2v5 n2v5 a2v5 dacp dacp n2v5 n2v5 n2v5 dacp ch1opfb ch1d1 ch1d0 ch1d2 ch1mc1 ch1d3 ch1mc0 ch1ts0 ch1ts1 ch1fb0 ch1fb1 c844khz ch1gndfb /0.1% /0.1% /0.1% cp d q gnd vcc ic540 nc7sz374p6x cp d q gnd vcc ic540 nc7sz374p6x 1 2 3 4 5 6 c5g6 1uf c5g6 1uf c5f9 10pf c5f9 10pf r583 49.9k r583...

  • Page 20

    A2v5 a2v5 dacp a2v5 n2v5 a2v5 dacp dacp n2v5 n2v5 n2v5 dacp ch2opfb ch2d1 ch2d0 ch2d2 ch2mc1 ch2d3 ch2mc0 ch2ts0 ch2ts1 ch2fb0 ch2fb1 c844khz ch2gndfb /0.1% /0.1% /0.1% r5a8 240 r5a8 240 r5e3 150 r5e3 150 c5k9 1uf c5k9 1uf r5a5 19k6 r5a5 19k6 r5e7 3k3 r5e7 3k3 vcc gnd ic547 nc7nzu04k8x vcc gnd ic547...

  • Page 21

    A2v5 a2v5 dacp a2v5 n2v5 a2v5 dacp dacp n2v5 n2v5 n2v5 dacp ch3opfb ch3d1 ch3d0 ch3d2 ch3mc1 ch3d3 ch3mc0 ch3ts0 ch3ts1 ch3fb0 ch3fb1 c844khz ch3gndfb /0.1% /0.1% /0.1% c5l4 100pf c5l4 100pf c5m6 1uf c5m6 1uf vcc gnd ic553 nc7nzu04k8x vcc gnd ic553 nc7nzu04k8x 1 2 3 4 5 6 7 8 r5h4 150 r5h4 150 c5l8 ...

  • Page 22

    Lopa lopb ropa ropb n41vl p53vl n53vl n53vl p53vl p53vl n53vl n53vl p53vl n41vl p53vr n53vr n53vr p53vr n41vr p53vr n53vr n53vr p53vr n41vr 3v3 3v3 3v3 3v3 3v3 3v3 spibc spid spics ch0opfb ch0bot ch0ton opoff ch1opfb ch1bot ch1ton opoff ch2opfb ch2bot ch2ton opoff ch3opfb ch3bot ch3ton opoff ch0opfb...

  • Page 23

    Opapreind opa_relay opa opa opb opa opb n48vl n48vl n38vl p48vl n48vl opoff n38vl p48vl n38vl p48vr p48vl n48vl p48vl bota topa ch0gndfb ch0toff bota topa opoff ch0gndfb thermal protect relay 2 relay 1 ch0gndfb /16v /5w /100v /63v /63v /16v /16v /100v /100v /100v /100v /100v /100v /100v l601 define:...

  • Page 24

    Opbpreind opb n38vr p48vr n48vr n48vr n38vr p48vr n48vr n38vr p48vr n48vr p48vr botb topb relay 2 relay 1 ch0opfb botb topb ch0opfb ch0opfb thermal protect thermal protect /16v /5w /63v /63v /16v /16v this sheet contains the circuit for the b half bridge, identical to a half, but without the common ...

  • Page 25

    Left channel: w901 solder with red wire and w902 solder with black wire right channel: w901 solder with black wire and w902 solder with red wire c921 470pf c921 470pf c903 470pf c903 470pf c930 470pf c930 470pf c917 470pf c917 470pf w902 pad w902 pad c911 470pf c911 470pf c922 470pf c922 470pf c915 ...

  • Page 26

    Analog board - solder side c236 c235 r266 u208 c264 analog board - component side c259 c 205 r204 r265 h2 c2 0 9 r 215 r 210 r l204 c 212 r 2 0 7 u 211 q200 r 2 0 6 c2 0 6 c 215 q203 r205 r l201 c 216 r 216 q204 r2 11 c2 10 u 212 r l205 c 248 agnd -18v agnd j204 h1 c269 c268 c276 +18v vap agnd copyr...

  • Page 27

    T10 0 t10 3 c opyr ig h t 2009 n a d ele ctron ic h s4- m2 -b0 0 8 -c ox- vm 1 r181 c189 c19 7 d103 c152 r114 d104 r104 r107 c101 c181 c190 c c106 r1 0 5 r 101 j 111 j 103 c 178 ms 0 1 22c t 101 j 101 m s 01 22 c c1 7 7 c19 6 coax board - solder side coax board - component side j 100 m s01 2 2 c c19...

  • Page 28

    C148 c150 c153 r110 c198 r109 r124 r125 c199 c166 c168 c165 r174 c176 r18 c19 c143 z gnd z gnd z sd0 zip c z gnd z bc0 z gnd z wc0 z gnd z spi bc z gnd z spi cs z spi d z spret z gnd z gnd z gnd z gnd z3v 3 z3v 3 c167 c14 7 c1 2 5 d1 0 1 d102 c161 c160 j108 c353 c146 c132 c126 c127 c136 c188 c183 c1...

  • Page 29

    Interface board - solder side interface board - component side c306 r3 1 3 r312 dgnd c313 j3 03 d3 0 5 d304 r314 c3 1 5 c310 c309 c308 c302 c307 u302 d3 06 c3 16 r315 r300 j3 0 1 q301 s302 r302 q302 r311 s301 d307 c317 r3 0 9 j3 05 r305 r306 d303 c301 r310 c312 r308 c304 r3 16 c3 14 c311 d302 j3 02 ...

  • Page 30

    Encoder board - component side c413 r419 c o p y rig ht 2009 n a d e le ct ro nic encoder board - solder side hs 4-m 2-b 008-e nc-v m 1 r420 c412 s401 c j401b c432.

  • Page 31

    C423 c403 c433 optical 2 k404 menu k401 r417 j401a l402 c404 c427 c428 r425 r426 c425 c4 2 6 r427 r424 q400 q402 q401 c4 1 9 l401 c410 r403 r401 r402 u400 r400 c421 c422 j404 c431 c400 c402 r430 u401 u403 c411 r418 d407 c424 u409 u402 c434 c435 c401 analog 1 r409 analog 2 loop u407 c409 k409 u406 k4...

  • Page 32

    R9 0 1 r902 r903 mains filter board - component side mains filter board - solder side cx904 cy904 j902 l n cy90 2 cy 903 n l j901 cx903 l90 2 cx901 cx902 l901 copyrig ht c 2009 nad e lectron ic hs4-m2 -b0 08 -ps uc-v m1.0 cy901.

  • Page 33

    R811 r809 c847 r816 c845 r812 r810 d801 c823 r815 r814 c828 c827 d806 r813 ic801 r824 c84 8 c824 c829 c834 c837 c825 c826 c830 c831 d804 c842 c832 r819 c841 d805 r823 c835 r822 c838 r821 c833 c836 r808 r817 r818 c840 c844 c803 c804 c843 r820 r807 r806 r805 r804 r802 r801 r800 d803 d802 c839 c801 uti...

  • Page 34

    R707 r702 r704 r708 c704 r705 c702 r703 r701 j709 k a r742 q708 r762 r72 1 q703 r728 op707 op708 r729 q702 q7 0 6 op712 r761 c721 c714 c722 c715 d709 r7 4 1 op703 r743 d704 c153 d106 d105 c710 r115 c7 1 2 r711 r710 r712 c706 r709 r713 op702 ic701 d701 q704 r7 2 7 r720 c723 r760 op709 d710 op704 c724...

  • Page 35

    M2_powamp board - solder side ic 521 ic 558 m2_powamp board - component side c5 n8 r5 h3 c 5l9 r5 g5 r5 g 4 c 5m8 r5 g8 c 5m3 r5 h4 c5 n4 ic 5 5 2 r5 n6 r5 n7 r5 n8 r5 n9 c5 x8 c5 y1 c5 y3 c5 p4 l505 p 514b c5 t1 r5 x4 gp0 c 581 c 567 c 579 c5 x7 c5 x9 c5 y2 r5 n3 r5 n2 c5 p3 r 5n 4 r5 n5 c5t7 r 5 w...

  • Page 36

    R6 07 r6 13 c6 1 0 q60 8 c630 m 2 po w eram p m o dul e v m2.0 oct. 12. 2009 c619 r618 gnda c617 rl601 d607 l601 tp602 c 618 c606 c607 c602 c611 ic 60 4 r603 r606 r6 1 7 r6 1 6 c616 c613 c612 d606 d604 c6 0 1 d603 d601 c605 c603 d602 c604 c608 q603 r6 1 4 c609 q604 r 6 1 5 ic601 r6 0 1 c 627 c6 2 0 ...

  • Page 37

    Binding post r board - solder side binding post l board - solder side p 905 m2 bi nd in g po s t boa rd vm 1 .0 ju l .2 2 .09 p9 0 7 c 929 c932 c9 30 c931 c9 13 c914 c915 c9 16 p908 c927 c9 09 c928 c9 26 c 925 c911 c910 c91 2 binding post r board - component side binding post l board - component sid...

  • Page 38

    Designator description part type part number footprint ah p/n 00-50200-10 c p/n 00-50200-20 p/n 01-50201-00 pcb1 board (dsp board ) diode d100 schottky barrier rectifier ss12 33-20012-01 sma d101 switch diode 1ss352 33-40352-01 sod-323 d102 switch diode 1ss352 33-40352-01 sod-323 d105 switch diode 1...

  • Page 39

    Designator description part type part number footprint r110 chip resistor 100kΩ, 1/10w, ±5% 07-90104-00 sm/r_0603 r111 chip resistor 100Ω, 1/10w, ±5% 07-90101-00 sm/r_0603 r112 res net 100rj 07-90101-10 r0603x4 r113 chip resistor 100Ω, 1/10w, ±5% 07-90101-00 sm/r_0603 r115 chip resistor 100Ω, 1/8w, ...

  • Page 40

    Designator description part type part number footprint r360 chip resistor 0Ω, 1/10w, ±5% 07-90000-00 sm/r_0603 r361 chip resistor 0Ω, 1/10w, ±5% 07-90000-00 sm/r_0603 r362 chip resistor 0Ω, 1/10w, ±5% 07-90000-00 sm/r_0603 r363 chip resistor 0Ω, 1/10w, ±5% 07-90000-00 sm/r_0603 r364 chip resistor 0Ω...

  • Page 41

    Designator description part type part number footprint c163 ceramic capacitor smd 100nk, 25v, 0603, x7r 26-10421-10 sm/c_0603 c165 ceramic capacitor smd 100nk, 25v, 0805, x7r 26-10421-01 sm/c_0805 c166 ceramic capacitor smd 100nk, 25v, 0805, x7r 26-10421-01 sm/c_0805 c167 ceramic capacitor smd 100nk...

  • Page 42

    Designator description part type part number footprint p/n 01-50202-00 pcb2 board (analog board) diode d200 switch diode 1n4148w-nr 33-44148-17 sod123 d201 switch diode 1n4148w-nr 33-44148-17 sod123 d202 switch diode 1n4148w-nr 33-44148-17 sod123 d203 switch diode 1n4148w-nr 33-44148-17 sod123 d204 ...

  • Page 43

    Designator description part type part number footprint r214 chip resistor 4.7kΩ, 1/10w, ±5% 07-90472-00 sm/r_0603 r215 chip resistor 4.7kΩ, 1/10w, ±5% 07-90472-00 sm/r_0603 r216 chip resistor 4.7kΩ, 1/10w, ±5% 07-90472-00 sm/r_0603 r217 chip resistor 4.7kΩ, 1/10w, ±5% 07-90472-00 sm/r_0603 r218 chip...

  • Page 44

    Designator description part type part number footprint r281 chip resistor 100Ω, 1/10w, ±5% 07-90101-00 sm/r_0603 r282 chip resistor 82Ω, 1/10w, ±1% 07-98209-00 sm/r_0603 r283 chip resistor 100Ω, 1/10w, ±5% 07-90101-00 sm/r_0603 r284 chip resistor 100Ω, 1/10w, ±5% 07-90101-00 sm/r_0603 r285 chip resi...

  • Page 45

    Designator description part type part number footprint c254 ceramic capacitor smd 10uf, 25v, 1206, x5r 26-10621-12 sm/c_1206 c255 chip tan capacitor 100uf,6.3v,20%,3528 27-10160-00 3528b c256 ceramic capacitor smd 22uf, 6.3v, 0805, x5r 26-22660-11 sm/c_0805 c257 chip tan capacitor 100uf,6.3v,20%,352...

  • Page 46

    Designator description part type part number footprint resistor r300 chip resistor 3.9Ω, 1/8w, ±1% 07-93908-01 sm/r_0805 r301 chip resistor 10Ω, 1/8w, ±5% 07-90100-01 sm/r_0805 r302 chip resistor 10kΩ, 1/10w, ±5% 07-90103-00 sm/r_0603 r303 chip resistor 2.2kΩ, 1/10w, ±5% 07-90222-00 sm/r_0603 r304 c...

  • Page 47

    Designator description part type part number footprint u401 octal buffer nc7wz16p6x 03-00716-01 sc70-6 u402 register 74vhc164mx-nl j03-00164-01 soic14 u403 register 74vhc164mx-nl j03-00164-01 soic14 u404 ir sensor fm-5038ln-5cn 03-05038-00 u406 register mm74hc165m 03-00165-01 soic16 u407 register mm...

  • Page 48

    Designator description part type part number footprint l402 inductor smd 10uh,hj-1812-100k / p1812r-103k 08-04100-07 sm/l_1812 connector j401a connector socket xhb 2 .5a-4aw 13-22504-05 j404 ffc socket smd 1.0-9-20pwb 13-21020-05 smd20*1.0mm switch k400 tact switch kan1211-1001c 11-04101-14 k401 tac...

  • Page 49

    Designator description part type part number footprint ic539 buffer nc7nzu04k8x j03-07048-01 us8 ic540 ic nc7sz374p6x 03-03746-01 sc70_6 ic541 ic nc7sz374p6x 03-03746-01 sc70_6 ic542 ic nc7sz374p6x 03-03746-01 sc70_6 ic543 ic nc7sz374p6x 03-03746-01 sc70_6 ic544 op-amp lt1806cs6 j03-01806-01 sot23-6...

  • Page 50

    Designator description part type part number footprint r543 chip resistor 240Ω, 1/10w, ±1% 07-92400-00 sm/r_0603 r544 chip resistor 100kΩ, 1/8w, ±1% 07-91003-01 sm/r_0805 r545 chip resistor 47kΩ, 1/8w, ±1% 07-94702-01 sm/r_0805 r546 chip resistor 4k7Ω, 1/10w, ±1% 07-94701-00 sm/r_0603 r547 chip resi...

  • Page 51

    Designator description part type part number footprint r5e7 chip resistor 3k3Ω, 1/8w, ±1% 07-93301-01 sm/r_0805 r5e8 chip resistor 150Ω, 1/8w, ±1% 07-91500-01 sm/r_0805 r5e9 chip resistor 3k3Ω, 1/10w, ±1% 07-93301-00 sm/r_0603 r5f2 chip resistor 10kΩ, 1/10w, 0.1% 07-91002-11 sm/r_0805 r5f3 chip resi...

  • Page 52

    Designator description part type part number footprint r5t4 chip resistor 33Ω, 1/10w, ±1% 07-93309-00 sm/r_0603 r5t5 chip resistor 33Ω, 1/10w, ±1% 07-93309-00 sm/r_0603 r5t6 chip resistor 33Ω, 1/10w, ±1% 07-93309-00 sm/r_0603 r5t7 chip resistor 33Ω, 1/10w, ±1% 07-93309-00 sm/r_0603 r5t8 chip resisto...

  • Page 53

    Designator description part type part number footprint c534 ceramic capacitor smd 1uf, 25v, ±10%, 0603, x5r 26-10521-10 sm/c_0603 c535 ceramic capacitor smd 4.7uf, 25v, 0805, y5v 26-47521-01 sm/c_0805 c536 ceramic capacitor smd 10pj, 50v, 0603, npo 26-10051-00 sm/c_0603 c537 ceramic capacitor smd 1u...

  • Page 54

    Designator description part type part number footprint c599 ceramic capacitor smd 10pj, 50v, 0805, npo 26-10051-01 sm/c_0805 c5a1 ceramic capacitor smd 100pj, 50v, 0805, npo 26-10151-01 sm/c_0805 c5a2 ceramic capacitor smd 1uf, 25v, ±10%, 0603, x5r 26-10521-10 sm/c_0603 c5a3 ceramic capacitor smd 1u...

  • Page 55

    Designator description part type part number footprint c5l1 ceramic capacitor smd 100nk, 50v, 0805, x7r 26-10451-11 sm/c_0805 c5l2 tan capacitor 47uf, ±20%, 25v 27-47021-02 case-d c5l3 ceramic capacitor smd 100pj, 50v, 0805, npo 26-10151-01 sm/c_0805 c5l4 ceramic capacitor smd 100pj, 50v, 0805, npo ...

  • Page 56

    Designator description part type part number footprint c5y8 ceramic capacitor smd 1.2nf, 200v, 1206, npo 26-12222-12 sm/c_1206 c5y9 ceramic capacitor smd 1.2nf, 200v, 1206, npo 26-12222-12 sm/c_1206 inductor fb501 ferrite bead smd bmb2a0300ln2 08-04300-01 sm/l_0805 fb502 ferrite bead smd bmb2a0300ln...

  • Page 57

    Designator description part type part number footprint ic605 logic gate nc7sz58p6x 03-00758-01 sc70_6 ic606 logic gate nc7sz58p6x 03-00758-01 sc70_6 tp601 thermal protector st-22 90c l type ja07-70022-09 to220ac resistor r601 chip resistor 2r2Ω, 1/4w, ±1% 07-92208-02 sm/r_1206 r602 chip resistor 33Ω...

  • Page 58

    Designator description part type part number footprint c616 polypropylene film capacitor mmkp82, 220nf, 100v, ±5% 25-22412-08 c617 polypropylene film capacitor mmkp82, 220nf, 100v, ±5% 25-22412-08 c618 ceramic capacitor smd 2200pf, 100v, 0805, npo 26-22212-11 sm/c_0805 c619 polypropylene film capaci...

  • Page 59

    Designator description part type part number footprint p605a header cnt-m254-2*10-gs-6/3-n 13-12520-01 p/n 01-50207-00 pcb7 board (power supply board upper) diode dw700 zener diode 12v, 1/2w 33-11200-00 do-35 dw701 zener diode 30v, 1/2w 33-13000-10 ll34 dw702 zener diode 30v, 1/2w 33-13000-10 ll34 d...

  • Page 60

    Designator description part type part number footprint r704 chip resistor 1.8megΩ, 1/4w, ±5% 07-90185-02 sm/r_1206 r705 chip resistor 1.8megΩ, 1/4w, ±5% 07-90185-02 sm/r_1206 r706 metal oxide film resistor 68kΩ, 1w, ±5% 07-30683-11 pitch=5mm r707 chip resistor 10Ω, 1/8w, ±5% 07-90100-01 sm/r_0805 r7...

  • Page 61

    Designator description part type part number footprint c706 ceramic capacitor smd 100nk, 50v, 0805, x7r 26-10451-11 sm/c_0805 c708 alu electrolytic capacitor 1000uf, 16v, ±20%, 105 06-10211-08 c709 alu electrolytic capacitor 1000uf, 16v, ±20%, 105 06-10211-08 c710 ceramic capacitor smd 100nk, 50v, 0...

  • Page 62

    Designator description part type part number footprint d806 schottky rectifier diodes sk56c 33-20056-00 do-214ab br800 rectifier bridge kbu810,8a/1000v 33-30813-01 tvs800 transient suppressor p6ke-200a 33-26200-00 ic ic800 power controller ic top246yn j03-00246-00 to220-7c ic801 regulator tl431bcdbz...

  • Page 63

    Designator description part type part number footprint c827 ceramic capacitor smd 100nk, 50v, 1206, x7r 26-10451-02 sm/c_1206 c828 ceramic capacitor smd 100nk, 50v, 1206, x7r 26-10451-02 sm/c_1206 c829 ceramic capacitor smd 100nk, 50v, 1206, x7r 26-10451-02 sm/c_1206 c830 ceramic capacitor smd 100nk...

  • Page 64

    Designator description part type part number footprint switch s401 encode ec16b243040f j37-16243-00 connector j401b connector socket xhb 2 .5a-4aw 13-22504-05 p/n 01-50210-00 pcb10 board (coax board ) diode d103 switch diode 1ss352 33-40352-01 sod-323 d104 switch diode 1ss352 33-40352-01 sod-323 res...

  • Page 65

    Designator description part type part number footprint c 904 c eramic c apacitor s md 470p j , 200v , 1206, np o 26-47122-02 s m/c _1206 c 905 c eramic c apacitor s md 470p j , 200v , 1206, np o 26-47122-02 s m/c _1206 c 906 c eramic c apacitor s md 470p j , 200v , 1206, np o 26-47122-02 s m/c _1206...

  • Page 66

    Designator description part type part number footprint c 932 c eramic c apacitor s md 470p j , 200v , 1206, np o 26-47122-02 s m/c _1206 connector w901&w902 wire one terminal:69-119008-0, another terminal strip&tin wire:ul1015#16awg l=150mm 14-50202-05 assembly parts p ower module alp 0400-5300 01-5...

  • Page 67

    F001 f002 f004 f005 f003 f006 f007 f008 f010 f013 f009 f012 f011 f014 s021 s021 s023 s026 s027 s022 s025 s024 f015.

  • Page 68

    0 0 0 f 5 0 0 c 4 0 0 c 3 0 0 c 1 0 0 c 2 0 0 c 1 0 0 r 2 0 0 r 3 0 0 r 7 0 0 r 5 0 0 r 4 0 0 r 6 0 0 c 7 0 0 c 7 1 0 c 8 0 0 c 9 0 0 c 1 0 0 t 0 1 0 c 1 1 0 c 2 1 0 c 8 1 0 c 3 1 0 c 4 1 0 c 8 1 0 c 5 1 0 c 6 1 0 c 9 1 0 c 8 0 0 r 9 0 0 r 0 1 0 r 1 1 0 r 2 1 0 r 5 1 0 r 6 1 0 r 1 0 0 s 4 0 0 s 2 0 ...

  • Page 69

    Ref.No part no. Description qty. Ref.No part no. Description qty. C001 01-50250-00 m2_powamp board (w/o 01-50206-00) 1 r006 01-50213-00 binding post board l 1 c002 01-50206-00 m2_module board 2 r007 01-50214-00 binding post board r 1 c003 01-50207-00 power switch a 1 r008 67-119003-5d real panel 1 c...

  • Page 70

    1 2 3 3 4 6 5 8 7 9 10 11 12 13 14 15 or 16 17 18 19 20

  • Page 71

    Item part no. Description qty 1 88-119001-0b shipping box 1 2 88-119002-0b gift box 1 3 89-119001-0 m2polyfoam 2 4 89-048004-0 little polyfoam b 1 5 88-043004-0 m series box sheet 1 6 88-043003-0 m series accessories box 1 7 90-119001-0 non-woven bag 1 8 90-119002-0 polybag 1 9 90-001002-0 manu poly...

  • Page 72: !"#$%

    !"#$% !#&!$ %' % $()% !"# "#*%"!+$!#*"!$%,-!"!%",! ', $ !."$,!#&!$ %/,!+$!# %"% " "& & #' '%'()""( '(& & #'""((&*(" ((+("&.

  • Page 73

    ,& #'(%((+&- ". /((+'"((((&*( ((% "%+(("%"& & #'("("&("() "&.

  • Page 74

    , 0& 1"+('%'" ( "%23%"" (" "&4( (""(%"& 5& /( "(%'"'& +)(( "&*((" (" "((&6 "("&.

  • Page 75

    & /("(% "&( %% "+%+" &.