1. DL manuals
  2. Napoleon
  3. Indoor Fireplace
  4. GI 3600-N
  5. Installation And Operation Instructions Manual

Napoleon GI 3600-N Installation And Operation Instructions Manual

Summary of GI 3600-N

  • Page 1

    1 w415-0061 / b / 01.11.05 installer: these instructions must be conveyed to and remain with the homeowner. Wolf steel ltd., 24 napoleon rd., barrie, on l4m 4y8 canada • (705)721-1212 • fax(705)722-6031 www.Napoleonfireplaces.Com • ask@napoleon.On.Ca certified under canadian and american national st...

  • Page 2

    2 w415-0061 / b / 01.11.05 pg 2-5 introduction warranty general instructions general information care of glass, & plated parts 5 installation 6-7 finishing brick panels log placement/charcoal embers louvre installation logo placement 7 operation / maintenance spill switch venting action check 8 oper...

  • Page 3

    3 w415-0061 / b / 01.11.05 napoleon gas fireplaces are manufactured under the strict standard of the world recognized iso 9001 : 2000 quality assurance certificate. Napoleon products are designed with superior components and materials, assembled by trained craftsmen who take great pride in their wor...

  • Page 4

    4 w415-0061 / b / 01.11.05 this gas fireplace should be installed and serviced by a qualified installer to conform with local codes. Installation practices vary from region to re- gion and it is important to know the specifics that apply to your area, for example: in massachusetts state: • the firep...

  • Page 5

    5 w415-0061 / b / 01.11.05 remove the securing screw from the front of the dilution plate. Push the dilution draft hood out of the securing clips and attach the liner using 3 screws equally spaced. Pack insulation around the liner at the damper area to prevent air flow from entering the chimney. Mov...

  • Page 6

    6 w415-0061 / b / 01.11.05 figure 5 an on/off switch has been included and can be located at the right side trim.For ease of accessibility, this switch may be replaced with a wall switch or substituted with a millivolt thermostat that may be installed in a convenient location on any wall. Route a 2 ...

  • Page 7

    7 w415-0061 / b / 01.11.05 figure 6 to give your insert that authentic masonry fireplace look, optional fibre firebrick panels are available at your napo- leon / wolf steel ltd. Dealer. Complete installation and main- tenance instructions are included with the kit. Phazer tm logs and charcoal embers...

  • Page 8

    8 w415-0061 / b / 01.11.05 when lit for the first time, the fireplace will emit a slight odour for a few hours. This is a normal temporary condi- tion caused by the curing of the logs and the "burn-in" of internal paints and lubricants used in the manufacturing process and will not occur again. Simp...

  • Page 9

    9 w415-0061 / b / 01.11.05 turn off the gas and electrical power before servicing the fireplace. Caution: label all wires prior to disconnection when ser- vicing controls. Wiring errors can cause improper and dan- gerous operation. Verify proper operation after servicing. This insert and its venting...

  • Page 10

    10 w415-0061 / b / 01.11.05 figure 12 figure 11 figure 12 figure 13 figure 14 the napoleon gas fireplace insert comes standard with a blower, a heat sensor, variable on/off speed control and a power cord. Because the blower is thermally activated, when turned on, it will automatically start approxim...

  • Page 11

    11 w415-0061 / b / 01.11.05 # part # description 1 gl-610 log set assembly c / w charcoal embers 2 w135-0007 back log 3 w135-0052 front log 4 w135-0015 right log 5 w135-0016 left log 6 w135-0009 center log 7* w550-0001 charcoal embers 8* w385-0245 napoleon logo 9 w725-0036 natural gas valve - remote...

  • Page 12

    12 w415-0061 / b / 01.11.05.

  • Page 13

    13 w415-0061 / b / 01.11.05 pilot goes out when the gas knob is re- leased. System is not correctly purged. Out of propane gas. - purge the gas line with the glass door removed. - fill the tank. - gently twist the pilot head to improve the flame pattern around the thermopile. Pilot flame is not larg...

  • Page 14

    14 w415-0061 / b / 01.11.05 main burner goes out; pilot goes out. Refer to "main burner goes out; pilot stays on" liner disconnected from insert. - wait ten minutes. Shut off all exhaust fans in the house (ie: kitchen and bathrooms), furnace, and clothes dryer. Open windows and/or doors. Start firep...

  • Page 15

    15 w415-0061 / b / 01.11.05 w olf steel fir eplace ser vice histor y this fireplace must be serviced annually depending on usage. Date service technician name service performed special concerns dealer name.

  • Page 16

    16 w415-0061 / b / 01.11.05 notes.