1. DL manuals
  2. Napoleon
  3. Patio Heater
  4. PTH31GT
  5. User Manual

Napoleon PTH31GT User Manual

Other manuals for PTH31GT: Instructions Manual, User Manual, Manual

Summary of PTH31GT

  • Page 1

    Warning do not try to light this appliance without reading the “lighting” instructions section of this manual. Do not store or use gasoline or other flammable liquids or vapors in the vicinity of this or any other appliance. An l.P. Cylinder not connected for use must not be stored in the vicinity o...

  • Page 2: Conditions and Limitations

    2 www.Napoleongrills.Com napoleon products are designed with superior components and materials, and are assembled by trained craftsmen who take great pride in their work. Every component has been thoroughly inspected by a qualified technician before packaging and shipping to ensure that you, the cus...

  • Page 3: Safe Operating Practices

    3 www.Napoleongrills.Com warning! Failure to follow these instructions could result in property damage, personal injury or death. Read and follow all warnings and instructions in this manual prior to operating this gas patio torch. Safe operating practices • read the entire instruction manual before...

  • Page 4: General Information

    4 www.Napoleongrills.Com general information this gas torch is certified under canadian and american national standards, csa 2.37a – 2008 and ansi z83.26a - 2008 respectively for outdoor patio heaters and must be installed to conform with local codes. When an appliance is for connection to a fixed p...

  • Page 5

    5 www.Napoleongrills.Com propane cylinder installation: set cylinder into hole in bottom shelf. Tighten strap over cylinder to secure it in place. Cylinder connection: ensure the gas regulator hose is kink free. Remove the cap from the cylinder fuel valve. Insert the black qcc1 regulator nipple onto...

  • Page 6: Leak Testing Instructions

    6 www.Napoleongrills.Com leak testing instructions warning! A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. Warning! Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you ...

  • Page 7: Lighting Instructions

    7 www.Napoleongrills.Com lighting instructions warning! Never use the torch while it is raining, the glass tube could crack or break causing serious injury. Warning! Ensure burner controls are in the off position. Slowly turn on the gas supply valve. 1. Turn burner control to ‘light’ position. 2. Pr...

  • Page 8: Operating The Patio Torch

    8 www.Napoleongrills.Com operating the patio torch initial lighting: when lit for the first time, the patio torch emits a slight odor. This is a normal temporary condition caused by the “burn-in” of internal paints and lubricants used in the manufacturing process and does not occur again. Simply run...

  • Page 9

    9 www.Napoleongrills.Com warning! Always wear protective gloves and safety glasses when cleaning your patio torch. Warning! To avoid the possibility of burns, maintenance should be done only when the patio torch is cool. Avoid unprotected contact with hot surfaces. Ensure burner is turned off. Turn ...

  • Page 10: Troubleshooting

    10 www.Napoleongrills.Com troubleshooting problem possible causes solution low heat / low flame when valve turned to high. For propane - improper lighting procedure. For natural gas - undersized supply line. Ensure lighting procedure is followed carefully. The valve must be in the off position when ...

  • Page 11: Getting Started

    25 www.Napoleongrills.Com attention! Lors du déballage et de l’assemblage, nous vous conseillons de porter des gants de travail et des lunettes de sécurité pour votre protection. Malgré tous nos efforts pour assurer que l’assemblage soit aussi sécuritaire et sans problème que possible, il se peut qu...

  • Page 12

    26 www.Napoleongrills.Com control box removal is not required. For step 2, use the short philips screwdriver (supplied) to assemble the lower supports. L’enlèvement du boîtier de contrôle n’est pas requis. Pour l’étape 2, utilisez le tournevis phillips (fourni) pour assembler les supports inférieurs...

  • Page 13

    27 www.Napoleongrills.Com 3. 4. 16 x (m5 x 8) 4 x (m5 x 8) assemble the plate cover (7) onto the middle plate (1) using the (m5 x 8mm) screws (17). Fixez le couvercle de plaque (7) sur la plaque centrale (1), à l’aide de vis (m5 x 8 mm) (17). Assemble the four upper supports (5) to the lower support...

  • Page 14

    28 www.Napoleongrills.Com 5. 6. 3 x (m5 x 8) 3 x (m5 x 8) assemble the reflector (10) onto the damper (9) using the (m5 x 8mm) screws (17). Installez le réflecteur (10) sur le registre (9), à l’aide de vis (m5 x 8 mm) (17). Control box removal is not required. For step 2, use the short philips screw...

  • Page 15

    29 www.Napoleongrills.Com 7. 8. Carefully install the glass tube (8) by lifting up and inserting through the center hole in the upper plate (6). Ensure the black silicone ring is attached to the lower edge of the glass tube as illustrated. Slide the glass tube through the hole of the lower plate cov...

  • Page 16: 10.

    30 www.Napoleongrills.Com 9. 10. 12 x (m5 x 8) attach the three side panels (15) to the torch using the (m5 x 8mm) screws (17). Note: do not cover the front side where the control knob is. Fixez les trois panneaux latéraux (15) sur le torche-patio, à l’aide de vis (m5 x 8 mm) (17). Note: ne recouvre...

  • Page 17

    31 www.Napoleongrills.Com propane only – proper hose connection warning! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. Propane seulement - branchement adéquat du boyau avertissement! Assurez-vous que le boyau ne touche à aucune surface à haut...

  • Page 18: Leak Testing Instructions

    32 www.Napoleongrills.Com leak testing instructions warning! A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. Warning! Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you...

  • Page 19: Parts List

    34 www.Napoleongrills.Com item # description/part # qty picture comments 1 middle plate - lh230-1-3-0 1 2 control box assy - lh200-30 includes: burner lp - lh100-3-8-0 burner nat - lh200-3a-8-0 pilot lp - lh100-3-7a-0 pilot nat - lh200-3a-7-0 valve assy lp - lh200-3-2-0 valve assy nat - lh200-3a-2-0...

  • Page 20: Parts List

    35 www.Napoleongrills.Com item # description/part # qty picture comments 12 tube connectors - lh200-8 8 13 upper protective guards lh230-7 4 14 fixing brackets - lh100-10 4 15 side panel - lh230-11a 3 16 front panel - lh230-12-3-0 1 a chain is preassembled in this panel 17 screw m5 x 8mm 58 preassem...

  • Page 21: Ordering Replacement Parts

    11 www.Napoleongrills.Com keep your receipt as proof of purchase to validate your warranty. Ordering replacement parts warranty information model: date of purchase: serial number: (record information here for easy reference) before contacting the customer care department, check the nac website for m...

  • Page 22: Fax To: 705 727 4282

    38 www.Napoleongrills.Com fax to: 705 727 4282 contact name:______________________________________________________________________ ship to :_____________________________________________________________________________ __________________________________________________________________________________...

  • Page 23

    12 www.Napoleongrills.Com.