Nation Flooring Equipment 3474-L-SUN Instruction Manual - Machine Operation
Machine Operation
FIG. B
UNPACKING
When unpacking the machine, please check that the following accessories are included:
•
The hose with end fi ttings
• Handle
• Floor
nozzle
If any of the above mentioned parts are missing, please contact your distributor or our
sales representative. Assemble the front wheels using the bolt, washer and nut that are
included in the package.
FUNCTION
The machine is designed for sucking and separating dry, non-com-
bustible dust with an explosion limit value of >0.1mg/m3
The motor is started by the switch. Dust-laden air is then sucked through the inlet valve
at high speed via the suction hose. The air is slowed down by the cyclone and coarse
dust particles are separated out, partly by centrifugal force and partly be gravity. Air and
fi ner particles then pass through the main fi lter where separation is made. The machine
is designed for fi lter cleaning by reverse air pulse.
The separated dust accumulates in the cyclone until the machine is switched off, when it
drops through the bottom fl ap into the plastic bag.
MACHINE USE
Before use, the user must be trained in handling the machine and the hazardous dust.
Connect the electric plug to an outlet with the correct voltage (see designation plate).
The fi lter must be cleaned from time to time (see Page 11). This must be done before
changing the plastic bag and can also be done when the work is complete or when there
is poor suction.
REPLACING BAG
3474-L are equipped with Longopac system for effective dust storage. This is a 65’
long plastic tube that will be divided into plastic bags using the striped attached with the
machine
Release the belt holding the bag.
1. Remove the holder.
2. Put in a new Longopac bag, pull out the inner end upwards.
3. Mount the holder on to the machine and the strap the upwards end with the belt.
4. Pull down to outside end and close it using the stripe.
Only change the Longopac or bag after jet pulsing the fi lter.
Fax: 763-535-8255
info@nationalequipment.com
10
Belt
Longopac Bag
Stripe