Summary of NEPTUNE SPACE PREDATOR
Page 1
1 owner’s manual pr ed at o r pr ed at o r pr ed at o r.
Page 2
Neptune space predator manual rel 2.3 december 2008 2.
Page 3
3 neptune space predator owner’s manual table of contents neptune space predator 1. Premise and warnings 4 2. Introduction 5 3. Technical characteristics 6 4. Use of conventional regulators 9 5. 1st stage sl 35tx 9 6. Quick steps 10 7. Equalization 11 8. Purging 11 9. Serial number 11 10. Replacemen...
Page 4
Neptune space predator manual rel 2.3 december 2008 4 the dpis (individual protective device) scrutinized in these operating instructions have undergone every possible test for design validation by: germanisher lloyd vorsetzen 35 20459 hamburg—germany notified body n.: 0098 full face mask neptune sp...
Page 5
5 neptune space predator introduction the neptune space predator mask was developed through experience gained from producing products for military personnel protection. All designs and materials were tested to obtain superior performance and increased safety. The high quality of the product does not...
Page 6
Neptune space predator manual rel 2.3 december 2008 6 when diving in cold water (below 45 0 f, or 7 0 c), you must have received training and certification in the techniques of cold water diving from a recognized training agency. The neptune space predator is designed and intended for use only with ...
Page 7
7 with the official measuring procedure used in the los alamos scientific laboratory charts at the sbccom mask fit facility-aberdeen proving ground (maryland, usa). Before purchasing a mask, the customer may use the caliper to take two simple face measurements. Using the full face mask size recommen...
Page 8
Neptune space predator manual rel 2.3 december 2008 8 the oral-nasal pocket, limiting the mixing of this air (containing high amounts of co2) with the fresh air from the regulator. The direction of exhaled air is controlled by a four position exhaust valve. The adjustable valve allows exhaust to flo...
Page 9
9 temperature range of operations between -40°c and 70°c (-40°f and 158°f). The purge button protection bezel is made of a high impact-resistant double metallized/coated techno polymer. Use of conventional regulators a special adapter allows the connection of several kinds of regulators. The adaptor...
Page 10
Neptune space predator manual rel 2.3 december 2008 10 quick steps 1. Before diving don the mask (make sure surface air valve or octopus port is open to allow air in). Adjust the straps and test equalization. Remove mask and adjust equalization system, if needed (see diagram on this card). Connect t...
Page 11
11 equalization the neptune space predator is equipped with a simple patented internal device to close the nostrils and allow underwater equalization. By loosening the screw it is possible to move the plate up and down to find the most comfortable position to equalize. The silicone caps may easily b...
Page 12
Neptune space predator manual rel 2.3 december 2008 12.
Page 13
13 neptune space predator rel.2.2 part code key q.Ty part code key q.Ty m-8 strap for frb2 buckle 9003 1 1 o-ring balanced poppet 2.6 x 1 15439 37 1 polar mesh strap 9007 1 1 quick release 6810 4 2 ss clamping band w/buckles—predator rel 2.0 or006 803 3 1 spring l 33-Ø thread 0,9-Ø.Int.8,4 6966 39 1...
Page 14
Neptune space predator manual rel 2.3 december 2008 14.
Page 15
15 key code r-din r-yoke designation 1 9810 1 1 retaining cap 2 9811 1 1 diaphragm Ø33 x 1.5 3 9812 1 1 pressure piston 4 9813 1 1 intermediate ring 5 9814 1 1 anti freeze kit 6 9815 1 1 adjusting screw 7 9816 1 1 spring 8 9817 1 1 spring plate 9 9818 1 1 friction ring 10 9819 1 1 diaphragm Ø36.9 x ...
Page 16
Neptune space predator manual rel 2.3 december 2008 16 maintenance and cleaning for optimum longevity of the mask and the proper functioning of its parts we recommend rinsing the mask thoroughly in fresh water after every use. Do not clean the visor with any abrasive materials. We recommend drying t...
Page 17
17 to assemble the swivel, first unscrew the hose from the second stage with a proper tool. Then connect the swivel to the second stage and tighten with proper tool (w/open wrench; not included). Next connect the hose to the threaded part of the swivel connector and tighten. This operation should no...
Page 18
Neptune space predator manual rel 2.3 december 2008 18 troubleshooting visor fogs warning signal that mask is not positioned correctly on face! A) orinasal mask positioned incorrectly or pinched b) orinasal mask improperly seated—check that it is properly tucked around communication port and exhaust...
Page 19
19.
Page 20
Neptune space predator manual rel 2.3 december 2008 20 www.Oceanreefgroup.Com ocean.Reef@oceanreefgroup.Com ocean reef, inc. 1699 la costa meadows dr. Suite 101 san marcos, ca 92078 (usa) phone +1 760 744 9430 fax +1 760 744 9525 toll free phone: 1 (800) 922-1764 ocean reef via arvigo 2 16010 sant’o...