1. DL manuals
  2. Pleasant Hearth
  3. Wood stove
  4. HWS-230292
  5. User Manual

Pleasant Hearth HWS-230292 User Manual

Other manuals for HWS-230292: Owner's Manual
Manual is about: High Efficiency Wood Stove - Large

Summary of HWS-230292

  • Page 1

    60-10-001 wa r m i n g yo u r h o m e. W a r m i n g y o u r h e a r t. 8280 austin avenue morton grove, il 60053 877-447-4768 questions, problems, missing parts? Before returning to your retailer, call our customer service department at 877-447-4768 8:30 a.M. - 4:30 p.M. Cst, monday - friday or e-m...

  • Page 2

    1 caution after reading these instructions, if you have any doubt about your ability to complete your installation in a pro- fessional like manner you should obtain the services of an installer versed in all aspects as to the correct and safe installation. Do not use temporary makeshift com- promise...

  • Page 3

    2 pedestal base and leg installation before installing stove, follow these steps for pedestal base and leg installation. Model: hws-230292 large wood stove w/pedestal base pedestal base is pre-installed at the factory. No action is required. Model: ws-3029 large wood stove w/pedestal base and legs r...

  • Page 4

    3 installation 1. Remove all parts from inside the stove body. 2. Select the proper location for the stove. These appliances must not be installed any closer than the minimum clearance to combustible materials shown in brick pattern (figure 1). The stove must be installed on a non combustible surfac...

  • Page 5

    4 installation on a concrete floor an appliance installed on a concrete floor does not require floor protection. If carpeting or any other com- bustible floor covering is installed, a clearance around the stove must be maintained equivalent to the size of the floor protector described in the followi...

  • Page 6

    5 inspect appliance & components and pre-use check list 1. Place the appliance in a location near the final installation area and follow the procedures below: 2. Open the appliance and remove all the parts and articles packed inside the component pack. Inspect all the parts and glass for shipping da...

  • Page 7

    6 typical stove systems stove system with masonry chimney consists of: • stove • chimney connector (stove pipe) • thimble • masonry chimney • hearth pad floor protection stove system with prefabricated metal chimney consists of: • stove • chimney connector (stove pipe) • thimble (for exterior chimne...

  • Page 8

    7 chimney systems prefabricated metal chimney • must be a 6 inch (152mm) diameter (id) high tempera- ture chimney listed to ul 103ht (2100°f) or ulc s627. • must use components required by the manufacturer for installation. • must maintain clearances required by the manufacturer for installation. • ...

  • Page 9

    8 thimble site constructed for masonry chimney installation: components • a minimum length of 12 inches [05mm] (longer for thicker walls) of solid insulated factory-built chimney length constructed to ul 103 type ht 6 inch (152mm) inside diameter. Chimney needs to extend a minimum of 2 inches (51mm)...

  • Page 10

    9 solid pack chimney with metal supports as a thimble (cont’d) chimney height / rise and run this product was designed for and tested on a 6 inch (152mm) chimney, 14 to 16 feet (420-480cm) high, (includes stove height) measured from the base of the appliance. The further your stack height or diamete...

  • Page 11

    10 chimney termination requirements follow manufacturer’s instructions for clearance, securing flashing and terminating the chimney. • must have an approved and listed cap • must not be located where it will become plugged by snow or other material • must terminate at least feet (91cm) above the roo...

  • Page 12

    11 4 2 6 5 3 warning! Risk of fire close open close and securely latch the door after the fire has started, and after refueling, to prevent: • spillage of smoke, flame and carbon monoxide • spillage of sparks, coals and logs • over-firing do not leave the stove unattended with the door open. Startin...

  • Page 13

    12 do not use a grate or elevate fire. Build wood fire directly on hearth. When the stove is used for the first time the solvents in the paint will smoke off. Wood this heater is designed to burn natural wood only. Higher efficiency and lower emissions generally result when burning air dried seasone...

  • Page 14

    13 the following use and safety tips should be observed: 1. Inspect the glass regularly for cracks and breaks. If you detect a crack or break, extinguish the fire immediately, and contact your dealer for replacement. 2. Do not slam door or otherwise impact the glass. When closing doors, make sure th...

  • Page 15

    14 note: coals may still be hot even though stove feels cool to the touch. 1. Make sure stove is completely cool. 2. Open glass door and lift up the firebrick for ash drawer using a fireplace poker through the metal hook raised from the top of the brick and set aside in firebox. 3. Using a small han...

  • Page 16

    15 g) once the kindling has started to burn, start by adding some of your smaller pieces of seasoned (dry) firewood. Note: adding large pieces at the early stages will only serve to smother the fire. Continue adding small pieces of seasoned (dry) firewood, keeping the door slightly open until each p...

  • Page 17

    16 environmental conditions high trees, low lying house location such as in a valley, tall buildings or structures surrounding your house and windy conditions can cause pool draft or down drafting. Cold chimney temperature avoid cold chimney temperatures by burning a hot fire for the first fifteen t...

  • Page 18

    17 caution! Allow the appliance to completely cool down before performing any cleaning or maintenance. Start the first inspection after the first 2 months of use, or if performance changes, and adjust your schedule accordingly. Maintenance is required for safe operation and must be performed to main...

  • Page 19

    18 item no. Description qty. Part no. 1. Door assembly 1 75-21-503 2. & 3. Glass (13.00”w x 8.38”h) and gasket 1 75-21-514 3. 1/8” glass gasket 4.3’ 75-21-123 4. 5/8” door gasket 5.1’ 75-21-143 5. Spring handle 1 75-20-140 6. Air control spring handle 1 75-20-141 7. Glass clip 6 75-25-131 8. Screw 6...

  • Page 20: 5 Year Warranty

    19 ghp group warrants that your new woodburning stove or masonry wood insert is free from manufacturing and material defects for a period of five years from the date of sale, subject to the following conditions and limitations. 1. This warranty is extended to the original owner only, for residential...