1. DL manuals
  2. Quadra-Fire
  3. Wood stove
  4. 31ST-ACC
  5. Owner's Manual

Quadra-Fire 31ST-ACC Owner's Manual

Manual is about: 3100 WOOD STOVE SERIES Automatic Combustion Control (ACC)

Summary of 31ST-ACC

  • Page 1

    Www.Quadrafi re.Com 7033-277n august 3, 2015 warning if the information in these instruc- tions is not followed exactly, a fi re may result causing property damage, personal injury, or death. • do not store or use gasoline or other fl am- mable vapors and liquids in the vicinity of this or any other...

  • Page 2: Caution

    Page 2 7033-277n august 3, 2015 r 3100 wood stove series (acc) hearth & home technologies welcomes you to our tradi- tion of excellence! In choosing a quadra-fire appliance, you have our assurance of commitment to quality, durabil- ity, and performance. This commitment begins with our research of th...

  • Page 3

    August 3, 2015 7033-277n page 3 3100 wood stove series (acc) r section 1: listing and code approvals a. Appliance certifi cations ......................4 b. Mobile home approved ......................4 c. Glass specifi cations ............................4 d. Btu & effi ciency specifi cations .........

  • Page 4

    Page 4 7033-277n august 3, 2015 r 3100 wood stove series (acc) 1 listing and code approvals the quadra-fire 3100 series wood stove (acc) meets the u.S. Environmental protection agency’s crib wood emission limits for wood heaters sold after may 15, 2015. A. Appliance certifi cation c. Glass specifi c...

  • Page 5

    August 3, 2015 7033-277n page 5 3100 wood stove series (acc) r 2 getting started a. Design, installation & location consider ations consideration must be given to: • safety • convenience • traffi c fl ow • chimney and chimney connector required it is a good idea to plan your installation on paper, u...

  • Page 6

    Page 6 7033-277n august 3, 2015 r 3100 wood stove series (acc) recommended location marginal location location not recommended recommended location location not recommended multi-level roofs windward leeward outside air kit termination cap figure 6.1 c. Negative pressure draft is the pressure differ...

  • Page 7

    August 3, 2015 7033-277n page 7 3100 wood stove series (acc) r exterior conditions such as roof line, surrounding trees, prevailing winds and nearby hills can influence stove performance. Your local dealer is the expert in your geographic area and can usually make suggestions or discover solutions t...

  • Page 8

    Page 8 7033-277n august 3, 2015 r 3100 wood stove series (acc) floor protector chimney connector insulated " t " flashing listed termination cap trim collar on inside wall listed chimney storm collar wall support roof brace (if required) thimble floor protector chimney connector ceiling support list...

  • Page 9

    August 3, 2015 7033-277n page 9 3100 wood stove series (acc) r 3 dimensions and clearances 26-11/16 in. (668mm) 24-5/16 in. (618mm) 6-11/16 in. (170mm) 16 in. (406mm) 11-1/2 in. (292mm) 20-3/4 in. (527mm) cl 4-1/2 in (108mm) outside air connection c l a. Appliance dimensions figure 9.2 front view fi...

  • Page 10

    Page 10 7033-277n august 3, 2015 r 3100 wood stove series (acc) appliance dimensions (cont.) figure 10.1 figure 10.2 figure 10.3 figure 10.4 31st-acc (step top model with pedestal) 31st-acc (step top model with queen ann legs) 23-7/8 in. (606mm) 33-1/8 in. (841mm) 15-1/16 in. (383mm) 19-1/16 in. (48...

  • Page 11

    August 3, 2015 7033-277n page 11 3100 wood stove series (acc) r b. Clearances to combustibles (ul and ulc) backwall / sidewall a b c d e f f e corner installation c alcove top view g a alcove side view note: clearances may only be reduced by means approved by the regulatory authority having jurisdic...

  • Page 12

    Page 12 7033-277n august 3, 2015 r 3100 wood stove series (acc) a. Hearth protection requirements floor protection: floor protector must be non-com- bustible material, extending beneath heater and to the front, sides and rear as indicated. The fl oor must be non-com- bustible or otherwise adequately...

  • Page 13

    August 3, 2015 7033-277n page 13 3100 wood stove series (acc) r note: • illustrations and photos refl ect typical installations and are for design purposes only. • i llustrations/diagrams are not drawn to scale. • actual installation may vary due to individual design preference • hearth & home techn...

  • Page 14

    Page 14 7033-277n august 3, 2015 r 3100 wood stove series (acc) figure 14.1 - floor & rear installation flex line wire tie wire tie flex adapter termination cap for floor installa- tions remove circular “knock-out” in base of pedestal. Figure 14.2 - floor installation alternative cover plate rope to...

  • Page 15

    August 3, 2015 7033-277n page 15 3100 wood stove series (acc) r warning do not draw outside combustion air from: • wall, fl oor or ceiling cavity • enclosed space such as an attic or garage • close proximity to exhaust vents or chimneys fumes or odor may result fire risk. Asphyxiation risk. Asphyxia...

  • Page 16

    Page 16 7033-277n august 3, 2015 r 3100 wood stove series (acc) d. Blower (optional) 1. Remove the 3 bolts (1/4”-20 phillips head) on the outer skin at the bottom rear of appliance. 2. Align holes in mounting fl ange of blower with bolt holes in appliance. Blower should be positioned at bottom of re...

  • Page 17

    August 3, 2015 7033-277n page 17 3100 wood stove series (acc) r note: i n canada when using a factory-built chimney it must be safety listed, type ul103 ht (2100 o f) class “a” or conforming to can/ulc-s629m, standard for 650 o c factory-built chimneys. 5 chimney requirements floor protector chimney...

  • Page 18

    Page 18 7033-277n august 3, 2015 r 3100 wood stove series (acc) thimble site constructed for masonry chimney installation: components • a minimum length of 12 inches [305mm] (longer for thicker walls) of solid insulated factory-built chimney length constructed to ul 103 type ht 6 inch (152mm) inside...

  • Page 19

    August 3, 2015 7033-277n page 19 3100 wood stove series (acc) r chimney height / rise and run this product was designed for and tested on a 6 inch (152mm) chimney, 14 to 16 feet (420-480cm) high, (includes stove height) measured from the base of the appliance. The further your stack height or diamet...

  • Page 20

    Page 20 7033-277n august 3, 2015 r 3100 wood stove series (acc) d. Chimney termination requirements follow manufacturers instructions for clearance, securing, fl ashing and terminating the chimney. • must have an approved and listed cap • must not be located where it will become plugged by snow or o...

  • Page 21

    August 3, 2015 7033-277n page 21 3100 wood stove series (acc) r figure 21.1 sparkarestor cap roof flashing storm collar joist shield/firestop double wall connector pipe floor protector outside air floor vent outsideair rear vent caution the structural integrity of the mobile home floor, wall and cei...

  • Page 22

    Page 22 7033-277n august 3, 2015 r 3100 wood stove series (acc) 7 appliance set up figure 22.3 do not operate before fully assembling components. Burning your stove without a pedestal or leg kit attached: • will void your warranty. • may result in property damage or personal injury. Warning note: th...

  • Page 23

    August 3, 2015 7033-277n page 23 3100 wood stove series (acc) r pedestal and ash removal system (cont.) installing pedestal assembly 1. Remove screws on adapter and slide pedestal over adapter on bottom of stove. Figure 23.1. 2. Line up holes in sides of pedestal with holes in adapter. 3. Securely t...

  • Page 24

    Page 24 7033-277n august 3, 2015 r 3100 wood stove series (acc) do not tilt the unit on the cast iron legs. • tilting could lead to property damage. • lift the unit upright and place it into position on the fl oor protector. Caution lay stove flat on its back on protective padding or pallet insert 2...

  • Page 25

    August 3, 2015 7033-277n page 25 3100 wood stove series (acc) r figure 25.1 figure 25.2 the 31le units are now being shipped with a tile panel securing clip on both sides of the units. Please remove and discard pins prior to use. ( fig. 25.3 and 25.4 ) figure 25.4 figure 25.3.

  • Page 26: Warning

    Page 26 7033-277n august 3, 2015 r 3100 wood stove series (acc) 8 operating instructions b. Wood selection & storage burn only dry seasoned wood. Store wood under cover, out of the rain and snow. Dry and well-seasoned wood will not only minimize the chance of creosote formation, but will give you th...

  • Page 27

    August 3, 2015 7033-277n page 27 3100 wood stove series (acc) r 2. Second stage the next stage of burning, the secondary stage, is the period when the wood gives off fl ammable gases which burn above the fuel with bright fl ames. During this stage of burning it is very important that the fl ames be ...

  • Page 28

    Page 28 7033-277n august 3, 2015 r 3100 wood stove series (acc) f. Burn rates and operating effi ciency for maximum operating effi ciency 1. This appliance has a timer system (acc) that operates the stove at its maximum effi ciency removing any guess work for the homeowner. Follow the instructions b...

  • Page 29: Incorrect Positions

    August 3, 2015 7033-277n page 29 3100 wood stove series (acc) r note: operate appliance on high burn 15 minutes a day to help keep fl ue/chimney clean. Incorrect positions g. Correct baffl e & blanket placement ceramic blanket and baffl e board are not in con- tact with the back of the fi rebox. Cer...

  • Page 30

    Page 30 7033-277n august 3, 2015 r 3100 wood stove series (acc) h. Building a fire before lighting your fi rst fi re in the stove: 1. Confi rm the baffl e is correctly positioned. It should be even with the front tube and resting on all tubes. Figure 30.1. 2. Follow instructions on page 34 for clean...

  • Page 31

    August 3, 2015 7033-277n page 31 3100 wood stove series (acc) r j. Opacity (smoke) this is the measure of how cleanly your appliance is burn- ing. Opacity is measured in percent; 100% opacity is when an object is totally obscured by the smoke column from a chimney, and 0% opacity means that no smoke...

  • Page 32

    Page 32 7033-277n august 3, 2015 r 3100 wood stove series (acc) 9 maintaining & servicing your appliance a. Quick reference maintenance guide ceramic blanket back of firebox baffle board baffle retainer bracket 2 2 floor protector chimney connector ceiling support listed chimney listed termination c...

  • Page 33

    August 3, 2015 7033-277n page 33 3100 wood stove series (acc) r b. General maintenance inspection: inspect the system at the appliance connection and at the chimney top. Cooler surfaces tend to build creosote deposits quicker, so it is important to check the chimney from the top as well as from the ...

  • Page 34

    Page 34 7033-277n august 3, 2015 r 3100 wood stove series (acc) 4. Cleaning plated surfaces • frequency: prior to first burn and then as desired • by: homeowner clean all the fi ngerprints and oils from plated surfaces before fi ring the appliance for the fi rst time. If not cleaned properly before ...

  • Page 35

    August 3, 2015 7033-277n page 35 3100 wood stove series (acc) r 9. Replace the door on the appliance. Quadra-fire stoves are equipped with ceramic super heat- resistant glass, which can only be broken by impact or misuse. Do not slam stove door or impact the glass. When closing door, make sure that ...

  • Page 36

    Page 36 7033-277n august 3, 2015 r 3100 wood stove series (acc) e. Baffl e removal 1. Remove all ash from the fi rebox, and extinguish all hot embers before disposal into a metal container. 2. The baffl e board has 2 pieces. With the ceramic blanket still in place, slide one baffl e piece over the t...

  • Page 37

    August 3, 2015 7033-277n page 37 3100 wood stove series (acc) r g. Tube channel assembly replacement removing tube channel assembly 1. Remove the right side shield by removing 2 screws in the back using a phillips head screw driver. 2. Remove 4 screws from channel access cover and remove cover. 3. L...

  • Page 38

    Page 38 7033-277n august 3, 2015 r 3100 wood stove series (acc) 10 troubleshooting with proper installation, operation, and maintenance your wood stove will provide years of trouble-free service. If you do experience a prob- lem, this troubleshooting guide will assist a qualifi ed service person in ...

  • Page 39: 31M-Acc

    August 3, 2015 7033-277n page 39 a. Exploded drawing & service parts service parts r 31m-acc beginning manufacturing date: july 2006 ending manufacturing date: active millennium - wood stove advanced combustion control (acc) part number list on following page. 31m-acc-mbk (7/06 - active), 31m-acc-gt...

  • Page 40: 31M-Acc

    Page 40 7033-277n august 3, 2015 service parts r 31m-acc beginning manufacturing date: july 2006 ending manufacturing date: active important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in ...

  • Page 41: 31M-Acc

    August 3, 2015 7033-277n page 41 service parts r 31m-acc beginning manufacturing date: july 2006 ending manufacturing date: active important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in ...

  • Page 42: 31M-Acc

    Page 42 7033-277n august 3, 2015 service parts r 31m-acc beginning manufacturing date: july 2006 ending manufacturing date: active important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in ...

  • Page 43: 31M-Acc

    August 3, 2015 7033-277n page 43 service parts r 31m-acc beginning manufacturing date: july 2006 ending manufacturing date: active important: this is dated information. When requesting service or replacement parts for your appliance please provide model number and serial number. All parts listed in ...

  • Page 44: 31St-Acc

    Page 44 7033-277n august 3, 2015 service parts r 31st-acc beginning manufacturing date: sept. 2006 ending manufacturing date: active step top - wood stove 31st-acc (advanced combustion control) part number list on following page. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 03/15 b. Exploded drawing & service p...

  • Page 45: 31St-Acc

    August 3, 2015 7033-277n page 45 service parts r 31st-acc beginning manufacturing date: sept. 2006 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers . Provide m...

  • Page 46: 31St-Acc

    Page 46 7033-277n august 3, 2015 service parts r 31st-acc beginning manufacturing date: sept. 2006 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers . Provide m...

  • Page 47: 31St-Acc

    August 3, 2015 7033-277n page 47 service parts r 31st-acc beginning manufacturing date: sept. 2006 ending manufacturing date: active #17 door assembly fiber baffle ceramic blanket this tab sits behind the front tube. Baffle protection channel sits in between front tube and fiber baffle. Side view fr...

  • Page 48: 31St-Acc

    Page 48 7033-277n august 3, 2015 service parts r 31st-acc beginning manufacturing date: sept. 2006 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers . Provide m...

  • Page 49: 31M-Acc-Le

    August 3, 2015 7033-277n page 49 3100 wood stove series (acc) r c. Exploded drawing & service parts service parts 31m-acc-le beginning manufacturing date: sept. 2014 ending manufacturing date: active r part number list on following page. 04/15 14 1 2 3 4 5 7 8 9 11 10 13 12 15 16 17 6 18.

  • Page 50: 31M-Acc-Le

    Page 50 7033-277n august 3, 2015 r 3100 wood stove series (acc) service parts 31m-acc-le beginning manufacturing date: sept. 2014 ending manufacturing date: active r important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell ...

  • Page 51: 31M-Acc-Le

    August 3, 2015 7033-277n page 51 3100 wood stove series (acc) r service parts 31m-acc-le beginning manufacturing date: sept. 2014 ending manufacturing date: active r important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell ...

  • Page 52: 31M-Acc-Le

    Page 52 7033-277n august 3, 2015 r 3100 wood stove series (acc) service parts 31m-acc-le beginning manufacturing date: sept. 2014 ending manufacturing date: active r important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell d...

  • Page 53: 31M-Acc-Le

    August 3, 2015 7033-277n page 53 3100 wood stove series (acc) r service parts 31m-acc-le beginning manufacturing date: sept. 2014 ending manufacturing date: active r important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell ...

  • Page 54

    Page 54 7033-277n august 3, 2015 r 3100 wood stove series (acc) d. Warranty policy 4021-645c 12-29-10 page 1 of 2 hearth & home technologies inc. Limited lifetime warranty hearth & home technologies inc., on behalf of its hearth brands (”hht”), extends the following warranty for hht gas, wood, pelle...

  • Page 55

    August 3, 2015 7033-277n page 55 3100 wood stove series (acc) r warranty conditions: ! " " this warranty is void if: # !! $# !! ! !! " % ! ! Limitations of liability: '* ' ! !* ! !! ! !! + 8 * + ! ; ! $ @$kn@ 8>u @ warranty exclusions: _ ! * n ! ! ! !! !! * @ % _ !! "!"! ! !! - [* ! ! - n _`q{ ! ! !...

  • Page 56

    Hearth & home technologies 1445 north highway colville, wa 99114 division of hni industries 7033-277n august 3, 2015 page 56 contact information: please contact your quadra-fire dealer with any questions or concerns. For the number of your nearest quadra-fire dealer, log onto www.Quadrafi re.Com dat...