- DL manuals
- Quadra-Fire
- Indoor Fireplace
- 5100I-GD-B
- Owner's Manual
Quadra-Fire 5100I-GD-B Owner's Manual - page 13
Page 1
5100-I ACT WOOD INSERT
R
438-0380D
September1,2008
Figure 13.1
F. Wiring Diagram
&AN#ONTROL3PEED
#ONTROL2HEOSTAT
3NAP$ISC
3NAP$ISC
"Y0ASS
3WITCH
,INE
'ROUND
.EUTRAL
&AN
&AN
&
&
G. Optional Offset Adapter
FULLY EXTENDED
FULLY CLOSED
3-1/4"
7-3/4"
12-1/4"
Center to Center
Chimney Liner
12-1/4"
4-1/2"
7-3/4"
3-1/16"
2-1/2" 3-3/4"
1-1/4"
16-3/4"
Drill points
Center to Center
Slide gasket
between
halves
Offset Adapter
Chimney
Liner
Mounting
Bracket
Slide gasket
between
halves
Drill holes
both sides,
secure with
screws
Apply bead of stove cement
Apply bead of
stove cement
Determine offset needed and adjust adapter accordingly
however, DO NOT OVER EXTEND ADAPTER. Follow
the detailed instructions that are supplied with the offset
adapter.
Figure 13.2
Figure 13.3
Summary of 5100I-GD-B
Page 1
Do not discard this manual notice • important operating and maintenance in- structionsincluded. • leavethismanualwith party responsible for useandoperation. • read, understand and followtheseinstructions forsafeinstallationand operation. Do n ot dis car d warning iftheinformationintheseinstruc- tion...
Page 2
5100-i act wood insert page september1,2008 r 438-0380d and welcome to the quadra-fire family ! H earth & home technologies welcomes you to our tradition of excellence! In choosing a quadra-fire appliance, you have our assurance of commitment to quality, durability, and perfor- mance. This commitmen...
Page 3
Page 5100-i act wood insert r 438-0380d september1,2008 section 1: listing and code approvals a. Appliance certifications......................4 b. Mobilehomeapproved......................4 c. Glass specifications............................4 d. Btu & efficiency specifications..........4 section 2: ...
Page 4
5100-i act wood insert page september1,2008 r 438-0380d 1 listing and code approvals the quadra-fire 5100-i act wood inserts meets the u.S. Environmental protection agency’s 1990 particulate emis- sionstandards. Model: 5100-iactwoodinsert laboratory: omnitestlaboratories,inc. Report no. 061-s-59-2 t...
Page 5
Page 5 5100-i act wood insert r 438-0380d september1,2008 2 getting started a. Design, installation & location considerations considerationmustbegivento: • safety • convenience • traffic flow • chimney and chimney connector required itisagoodideatoplanyourinstallationonpaper,usingexact measurements ...
Page 6
5100-i act wood insert page 6 september1,2008 r 438-0380d c. Negative pressure draftisthepressuredifferenceneededtoventappliances successfully.Considerationsforsuccessfuldraftinclude: • preventing negative pressure • locationofapplianceandchimney negative pressure resultsfromtheimbalanceofairavail- ...
Page 7
Page 5100-i act wood insert r 438-0380d september1,2008 d. Flue draft considerations location of the appliance and chimney will affect perfor- mance.Asshownin figure 6.1thechimneyshould: • beinstalledthroughthewarmspaceenclosedbythe buildingenvelope.Thishelpstoproducemoredraft, especially during lig...
Page 8
5100-i act wood insert page 8 september1,2008 r 438-0380d 3 dimensions and clearances a. Appliance dimensions top view side view front view a b 39-1/8" (994mm) 26-3/4" (679mm) 9-1/8" (232mm) 22-1/4" (565mm) 21-1/8" (537mm) 29-5/8" (752mm) 10-1/2" (267mm) 34-3/16" (919mm) cl 25-5/8" (651mm) 12-7/8" (...
Page 9
Page 9 5100-i act wood insert r 438-0380d september1,2008 in canada a full length 6 inch (15mm) ulc s65 flue liner required as per ulc s68. Note: when installing into a masonry fireplace, the fire- place must be built to ubc chapter standards. Do not remove brick or mortar from masonry fireplace to ...
Page 10
5100-i act wood insert page 10 september1,2008 r 438-0380d thermal protection must be 1/2 inch (13mm) minimum thickness (“k” value = 0.8) or equivalent material. All floor protection must be non-combustible (i.E., metals, brick, stone, mineral fiber boards, etc.). Any organic materi- als(i.E.,plasti...
Page 11
Page 11 5100-i act wood insert r 438-0380d september1,2008 note: ifyourhomeisfairlyairtight,itisrecommendthatyou installtheoutsideairthatcomesstandardwiththeappliance. If you are installing into a mobile home, outside air is required. The fireplace must have an outside air supply coming into it in o...
Page 12
5100-i act wood insert page 1 september1,2008 r 438-0380d the5100-iinsertcomesstandardwith2blowers,installed atthefactorywiththepowercordonrightsideofinsert(as youfacetheunit).Donotroutethepowercordunderorin frontofappliance. The power cord can also be installed on the left side. Follow instructions...
Page 13
Page 1 5100-i act wood insert r 438-0380d september1,2008 figure 13.1 f. Wiring diagram &an#ontrol3peed #ontrol2heostat 3nap$isc 3nap$isc "y0ass 3witch ,ine 'round .Eutral &an &an & & g. Optional offset adapter fully extended fully closed 3-1/4" 7-3/4" 12-1/4" center to center chimney liner 12-1/4" ...
Page 14
5100-i act wood insert page 1 september1,2008 r 438-0380d 5 chimney requirements a. Venting components chimney connector: it is also known as flue pipe or stove pipe. It must be 6 inches(152mm)minimumdiameterstainlesssteelconnector pipe. Chimney: thechimneycanbeneworexisting,masonryorprefabricated a...
Page 15
Page 15 5100-i act wood insert r 438-0380d september1,2008 floor ceiling caulk floor (secondstory) non-combustible firestopping material minimum 1 inch (25mm) clearance from exterior chimney to sheathing firestopping 2inch (51mm) non-combustible fire stopping material minimum 2 inch (51mm) clearance...
Page 16
5100-i act wood insert page 16 september1,2008 r 438-0380d d. Chimney termination requirements follow manufacturers instructions for clearances, securing, flashing and terminating the chimney. • musthaveanapprovedandlistedcap • mustnotbelocatedwhereitwillbecomepluggedby snoworothermaterial • mustter...
Page 17
Page 1 5100-i act wood insert r 438-0380d september1,2008 f. Masonry fireplace ul 1777 insulated stainless steel liner or other approved lining system follow manufacturer’s instructions on insulation and support for zero or other non-code clearances, follow approved liner manufacturer’s specific ins...
Page 18
5100-i act wood insert page 18 september1,2008 r 438-0380d g. Factory-built zero clearance fireplace the quadra-fire 5100-i insert is listed to ul 18 standard andisapprovedforinstallationintolistedfactory-builtzero clearance fireplaces listed to ul 1 conforming to the follow- ing specifications and ...
Page 19
Page 19 5100-i act wood insert r 438-0380d september1,2008 spark arestor cap roof flashing storm collar joist shield/firestop listed stainless steel liner 6 mobile home installation 1. Anoutsideairinletmustbeprovidedforcombustion see page 11 fordetailedinformation. 2. Appliancemustbesecuredtothemobi...
Page 20
5100-i act wood insert page 0 september1,2008 r 438-0380d figure 20.1 figure 20.2 figure 20.3 two leveling bolts, 3/8” x 4” are shipped inside the com- ponent pack found inside the firebox. Note: not all installations will require the use of the level- ingbolts. 1. Remove the bolts from the componen...
Page 21
Page 1 5100-i act wood insert r 438-0380d september1,2008 figure 21.1 figure 22.2 there are two options to secure the liner to the chimney ring: optionone:ifthereisenoughroomonthetopoftheinsert to work, hand bend the tabs upward 90°. Secure the liner withthesuppliedhexheadbolts1/4-20-3/4. Optiontwo:...
Page 22
5100-i act wood insert page september1,2008 r 438-0380d figure 22.1 figure 22.2 figure 22.3 figure 22.4 e. Zero clearance adjustable trim support size: 12” d x 50” w, 2-10” h 1. The10screwsoneachsetofscissorswillalreadybe loosewhenshipped. Figure 22.1. 2. Expand scissors to desired height. Tighten s...
Page 23: Warning
Page 5100-i act wood insert r 438-0380d september1,2008 8 operating instructions a. Over-firing your appliance do not over-fire. Over-firing may ignite creosote or will damage thestoveandchimney. To prevent over-firing your stove, do not: • use flammable liquids • overloadwithwood • burntrashorlarge...
Page 24
5100-i act wood insert page september1,2008 r 438-0380d primary aircontrol start-up aircontrol figure 24.1 warming your home and establishing the flue draft, not evapo- ratingthemoistureoutofwet,unseasonedwood,resulting inwastedheat. Theaircontrolintherightsideofthegrilleiscalledthestart- up air con...
Page 25
Page 5 5100-i act wood insert r 438-0380d september1,2008 1. Starting fire: open(pushin)bothcontrolsfully.Aftera woodloadhasbeenburningfor5to15minutes(longer for very large pieces) close the start-up air control by pullingitout. 2. High burn rate: leave the primary air control fully open. Itisimport...
Page 26
5100-i act wood insert page 6 september1,2008 r 438-0380d this appliance is equipped with a 110° thermally operated snapdiscwhichwillautomaticallyturnthebloweronwhen theinsertreachesthistemperature. Thesnapdiscislocatedatthecenteroftheinsert,underthe lowergrille.Thereisamanualoverrideswitchontherigh...
Page 27
Page 5100-i act wood insert r 438-0380d september1,2008 odorsandvaporsarereleasedduringinitialoperation. • curingofhightemperaturepaint. • openwindowsforaircirculation. Odorsmaybeirritatingtosensitiveindividuals. Caution j. Frequently asked questions issues solutions odorfromappliance when first ope...
Page 28
5100-i act wood insert page 8 september1,2008 r 438-0380d 9 maintaining & servicing your appliance a. General maintenance inspection:inspectthesystemattheapplianceconnection and at the chimney top. Cooler surfaces tend to build creosote deposits quicker, so it is important to check the chimneyfromth...
Page 29
Page 9 5100-i act wood insert r 438-0380d september1,2008 quadra-fire stoves are equipped with ceramic super heat- resistant glass, which can only be broken by impact or misuse.Donotslamstovedoororimpacttheglass.When closing door, make sure that logs do not protrude against the glass. Inspect glass ...
Page 30
5100-i act wood insert page 0 september1,2008 r 438-0380d d. Door handle assembly replacement 1. Installwasherondoorhandleshaft. 2. Slidedoorhandlethroughdoor. 3. Installsecondwasher(s)asshown. . Install key in groove. 5. Align groove in latch cam with key; slide latch cam overshaft 6. Install lockn...
Page 31
Page 1 5100-i act wood insert r 438-0380d september1,2008 the firebox is lined with high quality firebrick, which has exceptionalinsulatingproperties.Thereisnoneedtousea grate; simply build a fire on the firebox floor. Do not operate appliance without firebrick. E. Firebrick replacement • frequency:...
Page 32
5100-i act wood insert page september1,2008 r 438-0380d 1. Removethepanelandtrimset.See pages 20-21 forcompletedetails. 2. Remove2screwsonblowerhousing. . Unhook the wires from the blower. 4. Slideblowerhousingout. 5. Remove 2 screws from blower and remove from housing. 6. Attachnewblowertohousing. ...
Page 33: Correct Position
Page 5100-i act wood insert r 438-0380d september1,2008 correct position incorrect positions firebox damage due to improper baffle place- mentisnotcoveredbywarranty.Operatethe wood burning appliance with the baffle in the correctpositiononly. Notdoingsocouldresultin: • reduced efficiency • overheati...
Page 34
5100-i act wood insert page september1,2008 r 438-0380d 10 troubleshooting with proper installation, operation, and maintenance your appliance provideyearsoftrouble-freeservice.Ifyoudoexperienceaproblem, this troubleshooting guide will assist a qualified service person in the diagnosis of a problem ...
Page 35
Page 5 5100-i act wood insert r 438-0380d september1,2008 3. I smell smoke in the house during operation. What is causing it? Diagnostic question possible causes of condition solutions do fires start and burn well? No: • chimneyobstruction • not enough kindling and/or fuel toestablishdraft • inadequ...
Page 36
5100-i act wood insert page 6 september1,2008 r 438-0380d 11 reference materials a. Exploded views beginningmanufactureddate:november1,2004 figure 36.1 - front door & glass assembly figure 36.3 - wood insert figure 36.2 -side window 7 5 6 4 1 10 9 8 3 2 grooveforglass placement 13 11 12 29 14 15 16 ...
Page 37
Page 5100-i act wood insert r 438-0380d september1,2008 important: this is dated information . The most current information is located on the quadra-fire web site at www.Quadrafire.Com. When ordering, supply serial and model numbers to ensure correct part. B. Service parts & accessories item # part ...
Page 38
5100-i act wood insert page 8 september1,2008 r 438-0380d item # part description alphabetical order sku part description alphabetical order serial number sku grilleassembly,gold 832-3100 grille assembly, nickel 832-3100nl panel, standard, gold, 0-1/” h x ” w 831-1452 panel standard, nickel, 0-1/” h...
Page 39
Page 9 5100-i act wood insert r 438-0380d september1,2008 date of service performed by description of service c. Service and maintenance log.
Page 40
5100-i act wood insert page 0 september1,2008 r 438-0380d date of service performed by description of service c. Service and maintenance log (cont’d).
Page 41
Page 1 5100-i act wood insert r 438-0380d september1,2008 d. Homeowner’s notes.
Page 42
5100-i act wood insert page september1,2008 r 438-0380d e. Warranty policy hearth & home technologies limited warranty hearth & home technologies (“hht”) and its respective brands extends the following warranty for hht gas, wood, pellet and electric appliances purchased from an authorized hht dealer...
Page 43
Page 5100-i act wood insert r 438-0380d september1,2008 hearth & home technologies limited warranty (cont’d) hht’sobligationunderthiswarrantydoesnotextendtodamagesresultingfrom:(1)installation,operationormain- tenanceoftheappliancenotinaccordancewiththeinstallationinstructions;operatinginstructionsa...
Page 44
Page september1,2008 438-0380d r • do not discard this manual. • important operating and maintenance instructions included. • read, understand and follow these instruci- tons for safe installation and operation. • leave this manual with party responsible for use and operation. Caution hearth & home ...