Quadra-Fire QV32B-A Owner's Manual - page 3
Quadra-Fire • QV32B-A, QV36B-A • 2014-900 Rev. J • 7/08
3
Î = Contains updated information.
Table of Contents
1 Listing and Code Approvals
A. Appliance Certifi cation . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
B. Glass Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
C. BTU Specifi cations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
D. High Altitude Installations . . . . . . . . . . . . . . . . . . . . . . . . . . 4
E. Non-Combustible Materials Specifi cation. . . . . . . . . . . . . . 4
F. Combustible Materials Specifi cation . . . . . . . . . . . . . . . . . 4
G. Requirements for the Commonwealth of Massachusetts . . 5
2 Getting Started
A. Design and Installation Considerations . . . . . . . . . . . . . . . 6
B. Tools and Supplies Needed . . . . . . . . . . . . . . . . . . . . . . . . 6
C. Inspect Appliance and Components . . . . . . . . . . . . . . . . . . 6
3 Framing and Clearances
A. Selecting Appliance Location . . . . . . . . . . . . . . . . . . . . . . . 7
B. Constructing the Appliance Chase . . . . . . . . . . . . . . . . . . . 8
C. Clearances . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
D. Mantel Projections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
4 Termination Locations
A. Vent Termination Minimum Clearances . . . . . . . . . . . . . . 10
5 Vent Information and Diagrams
A. Vent Table Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
B. Use of Elbows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
C. Measuring Standards . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
D. Vent Diagrams . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
6 Vent Clearances and Framing
A. Pipe Clearances to Combustibles . . . . . . . . . . . . . . . . . . 24
B. Wall Penetration Framing . . . . . . . . . . . . . . . . . . . . . . . . . 25
C. Vertical Penetration Framing . . . . . . . . . . . . . . . . . . . . . . 26
D. Install Attic Insulation Shield . . . . . . . . . . . . . . . . . . . . . . . 27
7 Appliance Preparation
A. Top Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
B. Rear Vent . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
C. Securing and Leveling the Appliance . . . . . . . . . . . . . . . . 30
8 Installing Vent Pipe (DVP and SLP Pipe)
A. Assemble Vent Sections (DVP Pipe Only) . . . . . . . . . . . . 31
B. Assemble Vent Sections (SLP Pipe Only) . . . . . . . . . . . . 32
C. Assemble SLP or DVP Slip Sections . . . . . . . . . . . . . . . . 32
D. Secure the Vent Sections . . . . . . . . . . . . . . . . . . . . . . . . . 33
E. Disassemble Vent Sections . . . . . . . . . . . . . . . . . . . . . . . 33
F. Install Decorative Ceiling Components (SLP only) . . . . . . 34
G. Install Metal Roof Flashing . . . . . . . . . . . . . . . . . . . . . . . . 35
H. Assemble and Install Storm Collar . . . . . . . . . . . . . . . . . . 35
I. Install RF4-8 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
J. Install Vertical Termination Cap . . . . . . . . . . . . . . . . . . . . 37
K. Install Decorative Wall Components (SLP only) . . . . . . . . 37
L. Heat Shield Requirements for Horizontal Termination . . . 37
M. Install Horizontal Termination Cap (DVP and SLP Pipe) . 38
9 Gas Information
A. Fuel Conversions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
B. Gas Pressures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
C. Gas Connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 39
10 Electrical Information
A. Recommendation for Wire . . . . . . . . . . . . . . . . . . . . . . . . 41
B. Connecting to the Appliance. . . . . . . . . . . . . . . . . . . . . . . 41
C. Standing Pilot Ignition System Wiring . . . . . . . . . . . . . . . 41
D. Junction Box Installation. . . . . . . . . . . . . . . . . . . . . . . . . . 42
E. Wall Switch Installation for Fan (Optional) . . . . . . . . . . . . 42
11 Finishing
A. Mantel Projections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
B. Facing Material . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 44
12 Appliance Setup
A. Remove Shipping Materials . . . . . . . . . . . . . . . . . . . . . . . 45
B. Clean the Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
C. Accessories . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
D. Lava Rock, Vermiculite, Rockwool/Ember Placement . . . 45
E. Positioning the Logs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
F. Glass Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
G. Screen Mesh . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
H. Grilles and Trim . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
I. Hood . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
J. Air Shutter Setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48
13 Operating Instructions
A. Before Lighting Appliance. . . . . . . . . . . . . . . . . . . . . . . . . 49
B. Lighting Appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
C. After Appliance is Lit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
D. Frequently Asked Questions . . . . . . . . . . . . . . . . . . . . . . 51
14 Troubleshooting
A. Standing Pilot Ignition System . . . . . . . . . . . . . . . . . . . . . 52
15 Maintaining and Servicing Appliance
A. Maintenance Tasks
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
16 Reference Materials
A. Appliance Dimension Diagram . . . . . . . . . . . . . . . . . . . . . 56
B. Vent Components Diagrams . . . . . . . . . . . . . . . . . . . . . . 57
C. Service Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
D. Limited Lifetime Warranty . . . . . . . . . . . . . . . . . . . . . . . . . 68
E. Contact Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69