1. DL manuals
  2. Quadra-Fire
  3. Stove
  4. SANTAFE-MBK
  5. Owner's Manual

Quadra-Fire SANTAFE-MBK Owner's Manual

Manual is about: SANTA FE PELLET STOVE

Summary of SANTAFE-MBK

  • Page 1

    1 7050-146d april 01, 2016 notice: do not discard this manual santa fe pellet stove model(s): santafe-mbk o-t l tested and listed by portland oregon usa omni-test laboratories, inc. C us owner’s manual operation & care installer: leave this manual with party responsible for use and operation. Owner:...

  • Page 2: Released

    2 7050-146d april 01, 2016 santa fe freestanding b. Sample of serial number / safety label location: back of stove confidential property of hearth & home technologies inc. Part name: drawn by: scale: material: sheet: part number: rev: this print is checked and controlled by the engineering departmen...

  • Page 3

    April 01, 2016 7050-146d 3 santa fe freestanding table of contents safety alert key: • danger!Indicates a hazardous situation which, if not avoided will result in death or serious injury. • warning! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • caut...

  • Page 4

    4 7050-146d april 01, 2016 santa fe freestanding page 54 7022-122 january 19, 2011 r castile pellet insert 4021-645c 12-29-10 page 1 of 2 hearth & home technologies inc. Limited lifetime warranty hearth & home technologies inc., on behalf of its hearth brands (”hht”), extends the following warranty ...

  • Page 5

    April 01, 2016 7050-146d 5 santa fe freestanding r january 19, 2011 7022-122 page 55 castile pellet insert 4021-645c 12-29-10 page 2 of 2 warranty conditions: ...

  • Page 6

    6 7050-146d april 01, 2016 santa fe freestanding model santa fe pellet stove laboratory omni test laboratories, inc. Report no. 061-s-77d-6.2 type solid fuel room heater/pellet fuel burning type standard astm e1509-04, ulc s627-00 and ulc/ord-c1482-m1990 room heater pellet fuel burning type and (um)...

  • Page 7: User Guide

    April 01, 2016 7050-146d 7 santa fe freestanding user guide 2 operating instructions a. Fire safety to provide reasonable fire safety, the following should be given serious consideration: • install at least one smoke detector and co monitor on each floor of your home. • locate detectors away from th...

  • Page 8

    8 7050-146d april 01, 2016 santa fe freestanding performance • higher ash content requires the ash drawer to be emptied more frequently • hardwoods require more air to burn properly • premium wood pellets produce the highest heat output. • burning pellets longer than 1-1/2 inches (38mm) can cause an...

  • Page 9

    April 01, 2016 7050-146d 9 santa fe freestanding hot while in operation. Keep children, clothing and furniture away. Contact may cause skin burns. Caution j. Ignition cycles 1. At the beginning of each ignition cycle, it is normal to see some smoke in the firebox. The smoke will stop once the fire s...

  • Page 10

    10 7050-146d april 01, 2016 santa fe freestanding k. Clear space mantel: avoid placing candles and other heat-sensitive objects on mantel or hearth. Heat may damage these objects. Notice:clearances may only be reduced by means ap- proved by the regulatory authority having jurisdiction. Fire risk. Ke...

  • Page 11

    April 01, 2016 7050-146d 11 santa fe freestanding this pellet heater has a manufacturer-set minimum low burn rate that must not be altered. It is against federal regulations to alter this setting or otherwise operate this pellet heater in a manner inconsistent with operating instructions in this man...

  • Page 12: Warning

    12 7050-146d april 01, 2016 santa fe freestanding c. General maintenance and cleaning 1. Types of fuel depending on the type of fuel you are burning will dictate how often you have to clean your firepot. If the fuel you are burning has a high dirt or ash content or you are burning shelled field corn...

  • Page 13

    April 01, 2016 7050-146d 13 santa fe freestanding figure 13.1 cleaning rods 10 heat exchanger tubes 6. Cleaning heat exchanger chambers & drop tube • frequency: monthly or every 1 ton of fuel • by: homeowner the amount of ash buildup in the firepot will be a good guide to determine how often you sho...

  • Page 14

    14 7050-146d april 01, 2016 santa fe freestanding 10. Soot and fly ash: formation & need for removal in exhaust venting system. • frequency: yearly or more frequently depending on ash build-up. • by: qualified service technician/homeowner be sure the appliance is allowed to cool, has been unplugged ...

  • Page 15

    April 01, 2016 7050-146d 15 santa fe freestanding 16. Preparing firebox for non-burn season • frequency: yearly at the end of the heating season • by: homeowner a. Be sure the appliance is allowed to cool, has been un- plugged and the exhaust blower is off. B. Remove all ash from the firebox and vac...

  • Page 16

    16 7050-146d april 01, 2016 santa fe freestanding f. Thermostat battery installation, replacement, and operation note: 2 aa batteries are included with the thermostat and must be installed before the appliance can be oper- ated. Install fresh batteries immediately when the replace battery warning be...

  • Page 17

    April 01, 2016 7050-146d 17 santa fe freestanding with proper installation, operation, and maintenance your appliance will provide years of trouble-free service. If you do experience a prob- lem, this troubleshooting guide will assist a qualified service person in the diagnosis of a problem and the ...

  • Page 18

    18 7050-146d april 01, 2016 santa fe freestanding symptom possible cause corrective action slow or smoky start-up (cont’d) dirty exhaust and/or venting system. Check for ash build up in unit, includ- ing behind rear panels, firebox, heat exchanger, exhaust blower and venting. Feed system fails to st...

  • Page 19

    April 01, 2016 7050-146d 19 santa fe freestanding symptoms possible cause corrective action convection blower fails to start. #1 snap disc defective. Blower not plugged in. Blower is defective. Control box is defective. Replace snap disc. Check that blower is plugged into wire har- ness. Replace blo...

  • Page 20

    20 7050-146d april 01, 2016 santa fe freestanding a. Glass replacement - door assembly (replace with 5mm ceramic glass only) 1. Open the face and remove door from the appliance by lifting door off of hinge pin and lay on a flat surface face down. 2. Using a screwdriver, tap the bottom of the rope re...

  • Page 21

    April 01, 2016 7050-146d 21 santa fe freestanding 2. Combustion blower replacement a. Turn down the thermostat, let appliance completely cool and then unplug appliance before servicing. B. Remove both upper and lower side curtains. Figure 21.1. Remove the upper and lower rear curtains . Figure 21.3....

  • Page 22

    22 7050-146d april 01, 2016 santa fe freestanding 3. Snap disc #2 replacement note: combustion blower gasket is also required. Sold separately under part number 240-0812. A. Turn down thermostat, let appliance cool completely if running. Then unplug appliance before servicing. Dis- connect appliance...

  • Page 23

    April 01, 2016 7050-146d 23 santa fe freestanding d. Baffle & brick set removal 1. Follow proper shutdown procedures in section 10. 2. The top baffle has a hook on the bottom left side that rests on the top lip of the cast brick. There is a tab on the bottom right side that hooks into the side brack...

  • Page 24

    24 7050-146d april 01, 2016 santa fe freestanding right brick installed lift brick, pull forward at an angle and drop down into notches opening at left side of baffle insert baffle tab into slot figure 24.1 figure 24.2 figure 24.3 figure 24.4.

  • Page 25

    April 01, 2016 7050-146d 25 santa fe freestanding 6 reference materials 2. Convection blower the convection blower is mounted at the bottom rear of the appliance. There are 2 impellers, one on each side of the motor. The convection blower pushes heated air through the heat exchange system into the r...

  • Page 26

    26 7050-146d april 01, 2016 santa fe freestanding blower on and off as needed. Power is always present at snap disc #1. 18. Snap disc #2 (fuel delivery interrupt) 250°f snap disc #2 is also located on the back side of the feed drop tube. There are 2 orange wires connected to it. This snap disc will ...

  • Page 27

    April 01, 2016 7050-146d 27 santa fe freestanding red call light fuse control box vacuum switch junction box high med low heat output switch reset button reset button combustion blower convection blower terminal block center 2 screws for thermostat wires power outlet figure 27.1 figure 27.2 figure 2...

  • Page 28: Santafe-Mbk

    28 7050-146d april 01, 2016 santa fe freestanding service parts santafe-mbk beginning manufacturing date: june 2009 ending manufacturing date: active pellet stove part number list on following page. 1 3 4 5 6 7 8 9 10 11 12 13 14 21 15 16 17 18 19 20 2 04/16 c. Exploded drawings & service parts.

  • Page 29: Santafe-Mbk

    April 01, 2016 7050-146d 29 santa fe freestanding service parts santafe-mbk beginning manufacturing date: june 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...

  • Page 30: Santafe-Mbk

    30 7050-146d april 01, 2016 santa fe freestanding service parts santafe-mbk beginning manufacturing date: june 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...

  • Page 31: Santafe-Mbk

    April 01, 2016 7050-146d 31 santa fe freestanding service parts santafe-mbk beginning manufacturing date: june 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...

  • Page 32: Santafe-Mbk

    32 7050-146d april 01, 2016 santa fe freestanding service parts santafe-mbk beginning manufacturing date: june 2009 ending manufacturing date: active important: this is dated information . Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...

  • Page 33

    April 01, 2016 7050-146d 33 santa fe freestanding.

  • Page 34

    34 7050-146d april 01, 2016 santa fe freestanding.

  • Page 35

    April 01, 2016 7050-146d 35 santa fe freestanding.

  • Page 36

    36 7050-146d april 01, 2016 do not discard this manual caution • important operating and maintenance instruc- tions included. • leave this manual with party responsible for use and operation. • read, understand and follow these instruc- tions for safe installa- tion and operation. Do not discard con...