Quadra-Fire VOYAGEUR-MBK Owner's Manual - Caution
2
7063-512E
July 8, 2015
VOYAGEUR
CONFIDENTIAL
PROPER
TY
OF HEAR
TH & HOME
TECHNOLOGIES INC.
PAR
T NAME:
DRA
WN BY
:
SCALE:
MA
TERIAL:
SHEET
:
PAR
T NUMBER:
REV
:
THIS PRINT
IS CHECKED
AND CONTROLLED BY
THE ENGINEERING
DEP
AR
TMENTS OF HEAR
TH & HOME
TECHNOLOGIES INC.
ECO #
DA
TE
BY
REV
UNLESS OTHER
WISE SPECIFIED DIMS
ARE INCHES[MM] & :
TOLERANCES
ARE: (2) PLACE DEC : ± 0.03 (3) PLACE DEC: ± 0.005
ANGLE: ± 2° FRACTION: ± 1/16
OUTSIDE MA
TERIAL.
NORMAL
DIM & INSIDE MA
TERIAL.
OUTSIDE
APEX
INSIDE
APEX - DIMS ENCLOSED BY
AN OV
AL
ARE CRITICAL
DIMENSIONS
REVISIONS
ITEM
PAR
T NUMBER
PAR
T NAME
QTY
17.25
LISTED ROOM HEATER, SOLID
FUEL TYPE.
"For Use with Solid
Wood Fuel Only." Also for use in
Mobile Home.
PREVENT HOUSE FIRES
Install and use only in accordance with manufacturer's installation, venting and operating
instructions.
CONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS ABOUT RESTRICTIONS AND
INSTALLATION INSPECTION IN YOUR AREA
Refer to manufacturer's instructions and local codes for precautions required for passing chimney
through a combustible wall or ceiling.
WARNING - For Mobile Homes: Do not install in a sleeping room. An outside combustion air
inlet must be provided and unrestricted while unit is in use. The structural integrity of the mobile
home floor, ceiling and walls must be maintained. The insert must be properly grounded to the
frame of the mobile home. A complete relining of the chimney system with a 6 inch (152mm)
diameter listed stainless liner is required. Must be equipped with a spark arrestor cap. Outside
Air comes standard on the insert and must be installed before operating insert.
When used as a masonry insert stove, install only in a masonry fireplace built to national and/or
local codes. Do not remove brick or mortar to accommodate insert. Installation requires a 5 foot
minimum length of a starter pipe into existing chimney with airtight face seal.
Install only on a non-combustible hearth. Approved for installation and use in factory built
zero-clearance fireplaces conforming to minimum fire chamber specifications.
Components required for installation: positive or direct flue connection assembly or listed vent
liner.
In Canada a full length
6 inch (152mm)
S635 flue liner is required as per ULC S628-93.
WARNING - Inspect and clean chimney frequently. Under certain conditions of use, creosote
buildup may occur rapidly.
Do not connect this unit to a chimney serving another appliance.
DANGER: Risk of electrical shock. Disconnect power supply before servicing. Route power
cord away from unit. Do not route cord under or in front of appliance.
Electrical Rating: 115 VAC
1.4
AMPS 60 Hz
Do not use grate or elevate fire. Build wood fire directly on firebrick. Do not overfire. If heater or
chimney connector glows, you are
overfiring. Operate only with doors
closed. Open only to add fuel to the fire.
Replace glass only with 5mm ceramic
available from your dealer.
Minimum Clearances To Combustible Material
Masonry, Heat Circulating &
Factory-Built
USA ONLY
A Sidewall to Fuel Loading Door
20-1/2 in.
B Mantel to Fuel Loading Door
29 in.
C Top Trim to Fuel Loading Door
22 in.
D Side Trim to Fuel Loading Door
10-1/2 in.
E Hearth Extension from Glass
16 in.
F Hearth Extenson from Fuel Loading Door
8 in.
Refer to Clearances on other label for Canada
HOT WHILE IN OPERATION DO NOT
TOUCH, KEEP CHILDREN
CAUTION
:
AND CLOTHING AWAY. CONTACT MAY CAUSE SKIN
BURNS. KEEP FURNISHINGS AND OTHER
COMBUSTIBLE MATERIAL FAR AWAY FROM THE
APPLIANCE. SEE NAMEPLATE AND INSTRUCTIONS.
Model:
VOYAGEUR
WOOD INSERT
Report: 100116597
R
TESTED TO:
UL 1482, ULC S628-93
Serial No.
007022
2015
2016
2017
DO NOT REMOVE THIS LABEL
Mfg by:
1445 N. Highway, Colville, WA 99114 www.quadrafire.com
Made in U.S.A. of US and
imported parts.
Jan Feb Mar Apr May June July Aug Sept Oct. Nov. Dec.
7063-174C
NOTICE:
All measurements are from the fuel loading
door opening.
TRIM DEPTH
*Maximum 1-1/2 (38mm) Top Trim Depth
**Maximum 3-1/2 (89mm) SideTrim Depth
Factory-Built
Floor
Protection under Hearth
Extension
Thermal & Ember Protection
Floor height 0 to 3.5 inches below
Insert Base: 1 inch (25mm) R=0.52
Ember Protection Only
Greater than 3.5 inches below
Insert Base:
Hearth Extension
A
B
*C
**
D
F
E
Insert
SideW
all
Maximum Mantel Depth - 12 inch (305mm)
Fascia or Trim
Mantel
Fuel Door
OWNERS MANUAL
INSTALLATION MANUAL
U.S. ENVIRONMENTAL PROTECTION AGENCY
- Certified to comply with 2015 particulate emission
standards at 4.1
g/hr EPA Method 28 and 5G.
Not approved for sale after May 15, 2020.
This wood heater needs periodic
inspection and repair for proper
operation. Consult the owner’s
manual for further information. It
is against federal regulations to
operate this wood heater in a
manner inconsistent with the
operating instructions in the
owners’s manual.
A. Congratulations
Hearth & Home Technologies welcomes you to our tradition
of excellence! In choosing a Quadra-Fire appliance, you
have our assurance of commitment to quality, durability, and
performance.
This commitment begins with our research of the market,
including ‘Voice of the Customer’ contacts, ensuring we
make products that will satisfy your needs. Our Research
and Development facility then employs the world’s most
advanced technology to achieve the optimum opera-
tion of our stoves, inserts and fireplaces. And yet we are
old-fashioned when it comes to craftsmanship. Each unit
is meticulously fabricated and gold and nickel surfaces are
hand-finished for lasting beauty and enjoyment. Our pledge
to quality is completed as each model undergoes a quality
control inspection.
We wish you and your family many years of enjoyment in
the warmth and comfort of your hearth appliance. Thank
you for choosing Quadra-Fire.
B. Sample of Serial Number / Safety Label
LOCATION: UNDER ASH LIP ON PULL-OUT PLATE
NOTE: Clearances may only be reduced by means
approved by the regulatory authority having jurisdiction
SAMPLE
Test Lab & Report
Number
Mfg Date
Serial Number
Model Name
and Welcome to the Quadra-Fire Family
!