R.P.S. Corporation XR 2010 Operator's Manual - Page 8
PAGE 8
Controls and Functions
1. Steering wheel:
Steers the machine.
2. Adjustable seat with arm rests:
Your machine is equipped with an adjustable seat with arm rests.
3. Recovery tank lid:
Latch must be secured for recovery tank to seal properly.
4. Polyurethane rollers:
Helps prevent damage to machine and objects you may drive close to.
5. Adjustable disk deck side wipers:
Controls water on turns by directing it to the squeegee.
6. On board charger (optional):
Plugs into any three pronged 20 amp dedicated outlet to charge machine
7. Horn button:
Sounds the horn for warning oncoming traffic.
8. Headlight switch:
Turns headlight on and off.
9. Adjustable steering:
Four settings for operator comfort and ease of entry.
10. Hour meter:
Keeps track of total hours of use on the machine.
11. Battery hour meter:
keeps track of total hours of use on the batteries.
12. Water control lockout:
locks out the solution flow control so it cannot be changed.
13. Down pressure lockout:
locks out the scrub deck down pressure so it cannot be changed.
14. Serial # plate:
Have machines individual serial number stamped on it.
15. Headlight:
helps you see in low light areas and to warn oncoming traffic.
16. Foot pedal:
Controls the acceleration and deceleration of the machine.
17. Cup holder:
Holds beverage container.
18. Pre-Treat soap door:
Holds (2) pre-treat soap jugs.
19. Strobe light:
(optional) Warns people that the machine is in operation.
20. Recovery drain hose:
Allows for controlled draining of recovery tank dirty water.
21. Site tube/ sol. drain hose:
Shows how much solution is in the tank and drains the solution tank.
22. Spray hose:
(optional) Permits cleaning in remote areas.
23. Squeegee/vacuum hose:
Vacuumizes squeegee.
Note:
keep free and clear of blockage.
24. Rear bumper:
Offers squeegee system protection from damage.
25. Tank latch:
Permits access to tank.
26. Tie down points:
Location for tie down straps during transport.
27. Squeegee rollers:
Help protect the squeegee.
28. Rear Tire:
Solid Tire.
29. Adjustable cylindrical deck side Wipers:
Controls water on turns by directing it to the squeegee.
30. Cylindrical Deck Access Door:
Provides easy access to the decks belts & pulleys.
31. Charger Port:
(Grey 175) Receives charger input. (Only use OEM charger provided)
32. Side Brooms:
Extends the cleaning path up to walls.
33. Recovery tank:
Holds approximately 68-gallons of dirty "recovery" water.
34. Drain saver:
Prevents debris from clogging drain.
35. Foam protection screen:
Used to protect vacuum motor from debris.
36. Vacuum screen box:
Houses the stainless vac screen & shutoff ball.
37. Solution fill port:
Holds approximately 68-gallons of clean water.
38. LCD screen:
Lists functions and setting of the machine. (See page 9)
39. High water recovery light (red):
Indicates when the recovery tank is nearly full.
40. Low solution light (yellow):
Indicates when the solution tank is nearly empty.
41. Menu control:
Scrolls through different options on the LCD display.
42. Scrub deck down pressure switch:
Controls the pressure put on the scrub deck.
43. Squeegee switch:
Raises and lowers the squeegee.
44. Scrub deck switch:
Raises and lowers the scrub deck.
45. Solution control:
(-) to reduce & (+) to increase flow of solution.
46. "Uni-touch" button:
Activates brushes, squeegee, and solution flow simultaneously.
47. Forward/reverse switch (red):
Controls the direction of the traction motor.
48. Spray jet (blue):
(optional) Activates spray pump for remote spray wand.
49. Vacuum switch (white):
(optional) For use with remote vacuum wand.
50. Econ Switch:
51. Key switch:
Turns the main power on and off.
52. Circuit breaker:
(15 amp) positive bus bar.
53. Circuit breaker:
(15 amp) negative bus bar.
54. Circuit breaker:
(10 amp) side broom motors.
55. Circuit breaker:
(2 amp) side broom lift actuator.
56. Side broom (yellow):
lifts and lowers side brooms which turn on automatically.
57. Suds switch:
58. Emergency stop:
shuts machine down in a emergency