™ the ec4 series is tested and certified by the wqa to nsf/ansi 44 for the specific performance claims as verified and substantiated by test data. See the performance data sheet for specific reduction claims. Part no.: 15929 rev: m 04/13 e ec c4 4 s se er riie es s w wa at te er r t tr re ea at tm m...
2 table of contents information on water treatment systems ................................................ 3 application limitations ................................................................................ 3 operational specifications ...........................................................
3 congratulations on your purchase of a rainsoft water treatment system. This owner’s manual is designed to assist with the operation, mainte- nance, and installation of your water treatment system. It is our sincere hope that this manual is clear, concise, and helpful to you as a new owner. Questio...
4 operational specifications plumbing 3/4 inch to 1 1/4 inch i.D. Drain line 1/2 inch i.D. Water pressure 20 psi _ 120 psi (1.38 bar _ 6.89 bar) operating temperatures 40° f _ 100° f (4.4° c _ 37.8° c) electrical requirements a properly grounded alternating current supply (110 vac 60 hz or 230 vac 5...
Data chart for ion-x 2000 v resin 5 * * the conditioners are efficiency rated according to nsf/ansi 44. The efficiency of the conditioner is valid only at the stated salt dosage. Higher or lower pressure will affect the effi- ciency of the system. † only the following models are certified in the sta...
Operational specifications continued from page 5 data chart for ion-x 100 t resin 6 * the conditioners are efficiency rated according to nsf/ansi 44. The efficiency of the conditioner is valid only at the stated salt dosage. Higher or lower pressure will affect the efficiency of the system. ** ec4 7...
7 salt requirements two salt types are recommended for water conditioners: block salt: water conditioner block salt is reasonably priced, low in impurities, and will not cake in the salt container. Solar salt: solar salt is reasonably priced and low in impurities. Resin cleaners it is always wise to...
8 installation instructions 1. Safety precautions • to prevent an accident and/or injury, do not hoist the unit over your shoulder. Use a hand truck to transport the unit. • do not lay the unit on its side. • wear safety glasses and work gloves during installation. 2. Test the raw water • if water c...
9 • do not point the soldering torch directly at the mineral tank or control valve. These composite materials will last a lifetime, but cannot withstand the intense heat from a torch. • avoid short connections of pipe between the system and the water heater. If you can’t avoid a short connection, mo...
Installation instructions continued from page 9 10. Install the drain line and air gap (air gap not supplied) • for all drain lines, use at least a 1/2 inch i.D. Line. • connect the drain line to the drain outlet on back of the valve, opposite the inlet connection (see figure 4). A fitting is requir...
12. Install the brine line • slide the brass compression nut over the end of the brine line, followed by the ferrule and tube support. Attach the brine line to the brass fitting on the right side of the valve (see figure 7). • insert a tube support into the other end of the brine line and push the b...
12 system start up 1. Turn on the water and check for leaks • close all faucets and turn the water back on at the water meter or pressure tank. • check for leaks. If a leak is present, drain the plumbing again before soldering. 2. Flush the remaining debris from the system • open the cold water fauc...
13 an overview of the regeneration process your rainsoft ec4 water conditioner performs a periodic regeneration cycle to clean itself and restore its capacity. How often it regenerates depends on your water use, incoming water hardness, and several other factors, but 1 - 2 times a week is typical. A...
14 brine draw / slow rinse cycle after the system is backwashed for several minutes, the valve moves to the brine draw position. In this posi- tion, the valve creates a vacuum to pull the brine solution out of the brine tank. The brine solution flows slowly through the mineral bed, removing the hard...
15 15 helpful tip: the scale for block salt is designated by levels 1 _ 4. The scale for bag salt or potas- sium chloride is designated by levels 1 _ 5. For larger tanks, a salt scale sticker is available through your rainsoft dealer, part number 19024. ! Important note: when you exit the customer s...
Customer settings continued from page 15 the computer will display: salt alarm – on • use the adjust up or adjust down key to select “off”. • if you chose to keep the alarm “on”, press the menu forward key. Use the adjust up and adjust down keys to change the alarm time, if desired. The computer wil...
17 17 system alarms your system is equipped with several alarm tones: low salt, no salt, and service required. Please see below for information on the alarms: salt alarms: when your system’s salt alarm sounds, you will have the option of refilling the salt tank now or postponing the alarm until late...
18 18 if the troubleshooting guide did not resolve the symptom, please contact your local rainsoft dealer for service. If you cannot locate your local rainsoft dealer, please contact rainsoft customer service at 1-800-860-7638 or logon to www.Rainsoft.Com for the name and location of your nearest au...
19 limited lifetime warranty for as long as you own the equipment rainsoft division of aquion, inc. Believing its water treatment system to be of exceptional quality, hereby warrants said equipment to its first purchaser at retail as follows: the treatment tank, valve, salt container, electrical com...
20 20 valve exploded view.
21 valve parts list item quantity part number description 1 1 17863 composite valve body 2 1 17864 spacer end 3 4 17865 internal spacer 4 5 17866 internal seal 5 1 18160 retainer & down flow piston 6 1 10258 o-ring - 017 7 1 17869 end plug assembly 8 5 17870 10-24 x .812 screw hex washer head 9 1 17...
22 control exploded view 22.
23 23 item quantity part number description 1 1 17487 rear housing 2 1 17501 brine cam gear 3 1 17492 brine cam gear bracket 4 1 17537 valve motor w/computer cam 24v 50/60 hz 5a 2 17526 switch 45 deg actuator gold contact 5b 1 19536 sealed switch c-nc male connector red 5c 1 19537 sealed switch c-no...
24 24 capacity and salt settings demand initiated water treatment system california performance data sheet page 1 of 2 ec4 75 cv demand initiated treatment system the system should be installed in an area not affected by extreme heat, cold, or the elements. This system must be installed in accordanc...
25 25 state of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1803 06 - rainsoft ec4 75 cv n/a manufacturer: rainsoft, a division of aquion, inc. The water treatment device(s) listed on this...
26 26 demand initiated water treatment system california performance data sheet page 1 of 2 ec4 100 cv demand initiated treatment system the system should be installed in an area not affected by extreme heat, cold, or the elements. This system must be installed in accordance with all applicable stat...
27 27 demand initiated water treatment system california performance data sheet page 2 of 2 state of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1802 06 - rainsoft ec4 100 cv n/a manufact...
28 28 capacity and salt settings demand initiated water treatment system california performance data sheet page 1 of 2 ec4 150 cv demand initiated treatment system the system should be installed in an area not affected by extreme heat, cold, or the elements. This system must be installed in accordan...
29 29 state of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1801 06 - rainsoft ec4 150 cv n/a manufacturer: rainsoft, a division of aquion, inc. The water treatment device(s) listed on thi...
30 ™ rainsoft division of aquion, inc. 2080 east lunt avenue elk grove village, illinois 60007 main switchboard: 1.847.437.9400 customer service: 1.800.860.7638 www.Rainsoft.Com ©2013 rainsoft, a division of aquion, inc..
Rainsoft división de aquion, inc 2080 avenida este lunt elk grove village, illinois, 60007 1.847.437.9400 or 1.800.860.7638 www.Rainsoft.Com ™ este producto se fabrica en una planta con certificado iso 9001:2008. Desde 1953 tomando la preocupación fuera del agua manual de manual de propietario propi...
32 indice de materias información del sistema de tratamiento de agua...................................33 aplicación de restricciones ........................................................................33 especificaciones de operación ............................................................3...
33 `felicitaciones por su compra del sistema de tratamiento de agua rainsoft. Este manual del usuario está diseñado para ayudarlo con el funcionamiento, mantenimiento e instalación de su sistema de tratamiento de agua. Deseamos sinceramente que este manual sea claro, conciso y útil para ud. Como nue...
34 conocida como agua clara de hierro, el máximo rango de separación se basa en la condición local del agua.El rango es generalmente 2 a 10 partes por millón. Su equipo podría requerir una programación especial asi como un aditivo al tanque de salmuera para maximizar la capacidad del equipo en remov...
35 cuadro de datos para resina ion-x 2000 v * el índice de eficacia de los acondi- cionadores está de acuerdo con nsf/ansi 44.La eficacia del acondicionador es válida sólo con la cantidad establecida de sal. Mayor o menor presion afectaria la eficacia del sistema. † sólo los siguientes modelos están...
36 operational specifications continued from page 33. Cuadro de datos para resina ion-x 100 t * el índice de eficacia de los acondi- cionadores está de acuerdo con nsf/ansi 44.La eficacia del acondicionador es válida sólo con la cantidad establecida de sal. Mayor o menor presion afectaria la eficaci...
37 requisitos de sal 2 tipos de sal son recomendadas para los acondicionadores de agua: sal en bloque: el precio de sal bloque para acondicionador de agua es económico, bajo en impureza y no se endurecerá en el envase se sal. Sal solar: sal solar en bastante económica y baja en impurezas. Limpiadore...
38 instrucciones para instalación 1. Medidas de precaución •para prevenir un accidente y/o daño no levante la unidad sobre su hombro. Utilice un camión de mano para transportar la unidad. •no coloque la unidad de lado. •utilice lentes de seguridad y guantes de trabajo durante la instalación. 2. Prue...
39 • evite conecciones cortas del tubo entre el sistema y el calentador de agua. Si ud. No lo pudiera evitar mueva el sistema a otra ubicación. Como último recurso instale una trampa de calor o válvula de detec- ción.Si esto causa un “golpe de agua” instale un supresor de golpe de agua. 7. Proveer a...
40 installation instructions continued from page 39 10. Instalar la linea de desague y boquete de aire (boquete de aire no proporcionada) • para todas las líneas de desague use una línea de por lo menos 1/2 pulgadai.D. • conecte la linea de desague a la salida del desague atrás de la válvula en fren...
41 12. Instalar la linea de salmuera • deslice la tuerca de lata de compresión sobre el final de la línea de salmuera seguido por el regetón y tubo de apoyo.Unir la linea de salmuera al accesorio de lata en el lado derecho de la válvula. (ver figura 7). • inserte el tubo de soporte dentro del otro f...
42 sistema de puesta en marcha 1. Encienda el agua y verifique que no haya fugas • cerrar todas las cañerias y vuela a abrirlas en el medidor de agua o tanque de presión. • verifique que no haya fugas. De presentar fugas vacie la tuberia nuevamente antes de soldarla. 2. Enjuagar los restos del siste...
43 una visión general del proceso de regeneración su acondicionador de agua rainsoft ec4 desarrolla un ciclo de regeneración periódica para limpiarse a si mismo y restaurar su capacidad. Con que frecuencia se regenere depende de su uso de agua, de la dureza del agua, y varios otros factores, pero 1 ...
44 extracción de salmuera / ciclo lento de enjuague después que el sistema es lavado por varios minutos, la válvula se mueve a la posición de extracción de salmuera. En esta posición, la válvula crea un vacío para extraer la solución de salmuera el tanque de salmuera. La solución de salmuera fluye l...
45 configuraciones del cliente el modo de configuraciones del cliente permite el acceso a una variedad de opciones de programación: nivel de sal: esta función determina los niveles de sal del tanque de sal. Modo de vacaciones: esta función pone el sistema en pausa mientras ud. Esta de vacaciones o h...
46 customer settings continued from page 45. La computadora mostrará: alarma de sal– encendido. • usar la tecla de ajustar hacia arriba o ajustar hacia abajo para seleccionar “apagado”. • si ud. Ha elejido mantener la alarma “encendido” presione la tecla adelantar del menú use las teclas para ajusta...
47 sistema de alarmas su sistema está equipado con varios tonos de alarma: poca sal, no sal, y requiere servicio. Favor ver la siguiente información de alarmas: alarma de sal: cuando suene la alarma de sal de su sistema, ud. Tendrá la opción de rellenar el tanque de sal ahora o posponer la alarma ha...
48 si la guia de solución de problemas no resuelve estos indicios, favor contactárse con su distribuidor local de rainsoft para servicio. Si ud. No puede localizar a su distribuidor local de rainsoft, favor comuníquese al servicio al cliente de rainsoft al 1-800-860-7638 o entrar a www.Rainsoft.Com ...
49 garantía de por vida limitada por el tiempo que ud.Posea el equipo rainsoft division of aquion, inc. Cree que su sistema de tratamiento de agua es de excepcional calidad, por eso la garantía es dada al primer comprador del equipo al por menor como sigue: el tanque de tratamiento, valvula, recipie...
50 vista detallada de la válvula.
51 artículo cantidad número de parte descripción 1 1 17863 composite valve body 2 1 17864 spacer end 3 4 17865 internal spacer 4 5 17866 internal seal 5 1 18160 retainer & down flow piston 6 1 10258 o-ring - 017 7 1 17869 end plug assembly 8 5 17870 10-24 x .812 screw hex washer head 9 1 17871 pisto...
52 vista detallada de control.
53 artículo cantidad número de parte descripción 1 1 17487 rear housing 2 1 17501 brine cam gear 3 1 17492 brine cam gear bracket 4 1 17537 valve motor w/computer cam 24v 50/60 hz 5a 2 17526 switch 45 deg actuator gold contact 5b 1 19536 sealed switch c-nc male connector red 5c 1 19537 sealed switch...
54 capacidad y ajuste de sal demanda iniciada sistema de tratamiento de agua hoja de datos de funcionamiento de california pagina 1 de 2 ec4 75 cv demanda iniciada en sistema de tratamiento el sistema debe ser instalado en un area no afectada por calor intenso, frio u otros elementos. Este sistema d...
55 state of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1803 06 - rainsoft ec4 75 cv n/a manufacturer: rainsoft, a division of aquion, inc. The water treatment device(s) listed on this ce...
56 capacidad y ajuste de sal demanda iniciada sistema de tratamiento de agua hoja de funcionamiento de datos de california página 1 de 2 ec4 100 cv demanda iniciada de sistema de tratamiento el sistema debe ser instalado en un area no afectada por calor intenso, frio u otros elementos. Este sistema ...
State of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1802 06 - rainsoft ec4 100 cv n/a manufacturer: rainsoft, a division of aquion, inc. The water treatment device(s) listed on this cert...
58 capacidad y ajuste de sal demanda iniciada sistema de tratamiento de agua hoja de datos de funcionamiento de california página 1 de 2 ec4 150 cv requerimiento inicial del sistema de tratamiento el sistema debe ser instalado en un area no afectada por calor intenso, frio u otros elementos. Este si...
59 tomando la preocupación fuera del agua desde 1953 state of california department of public health water treatment device certificate number date issued: july 28, 2011 trademark/model designation replacement elements 1801 06 - rainsoft ec4 150 cv n/a manufacturer: rainsoft, a division of aquion, i...
™ rainsoft división de aquion, inc. 2080 avenida este lunt elk grove village, illinois, eeuu 60007 principal conmutador: 1.847.437.9400 servicio al cliente: 1.800.860.7638 www.Rainsoft.Com ©2013 rainsoft, una división de aquion, inc..